2003 CHEVROLET ASTRO CARGO VAN parking brake

Long Trip/Highway Scheduled
Maintenance
The services shown in this schedule up to 100,000 miles
(166 000 km) should be repeated after 100,000 miles
(166 000 km) at the same intervals for the life of
this vehicle. The services shown at 150,000 miles
(240 000 km) should be repeated at the same interval
after 150,000 miles (240 000 km) for the life of this
vehicle.
See
Part B: Owner Checks and Services on page 6-26andPart C: Periodic MaintenanceInspections on
page 6-30.
Footnotes
²The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify the
emission warranty or limit recall liability prior to the
completion of the vehicle's useful life. We, however, urge
that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
#Lubricate the front suspension, ball joints and kingpin
bushings, steering linkage and transfer case shift linkage,
parking brake cable guides and brake pedal springs.
+A good time to check your brakes is during tire
rotation. See Brake System Inspection on page 6-31.
7,500 Miles (12 500 km)
qChange engine oil and ®lter (or every 12 months,
whichever occurs ®rst).An Emission Control
Service.
qLubricate chassis components (or every 12 months,
whichever occurs ®rst).(See footnote #).
qCheck rear/front axle ¯uid level and add ¯uid as
needed. Check constant velocity joints and axle seals
for leaking.
qRotate tires. See
Tire Inspection and Rotation on
page 5-64for proper rotation pattern and additional
information.(See footnote +).
6-18

Starter Switch Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake and the regular
brake. See
Parking Brake on page 2-26if
necessary.
Do not use the accelerator pedal, and be ready to
turn off the engine immediately if it starts.
3. Try to start the engine in each gear. The starter
should work only in PARK (P) or NEUTRAL (N).
If the starter works in any other position, your
vehicle needs service.
Automatic Transmission Shift Lock
Control System Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a level
surface.
2. Firmly apply the parking brake. See
Parking Brake
on page 2-26if necessary.
Be ready to apply the regular brake immediately if
the vehicle begins to move.
3. With the engine off, turn the key to the RUN
position, but don't start the engine. Without applying
the regular brake, try to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle needs service.
6-28

Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
·The key should turn to LOCK only when the
shift lever is in PARK (P).
·The key should come out only in LOCK.
Parking Brake and Automatic
Transmission Park (P)
Mechanism Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
·To check the parking brake's holding ability: With
the engine running and transmission in NEUTRAL
(N), slowly remove foot pressure from the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
·To check the PARK (P) mechanism's holding
ability: With the engine running, shift to PARK (P).
Then release the parking brake followed by the
regular brake.
Underbody Flushing Service
At least every spring, use plain water to ¯ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-29

Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts
as needed. Replace any components that have high
effort or excessive wear. Do not lubricate accelerator
and cruise control cables.
Transfer Case and Front Axle
(All-Wheel Drive) Inspection
Every 12 months, or at engine oil change intervals,
check front axle and transfer case and add lubricant
when necessary. A ¯uid loss could indicate a problem.
Check and have it repaired, if needed. Check vent
hose at transfer case for kinks and proper installation.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
cha®ng, etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake parts,
including calipers, parking brake, etc. Check parking
brake adjustment. You may need to have your brakes
inspected more often if your driving habits or
conditions result in frequent braking.
6-31

Part D: Recommended Fluids
and Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certi®ed for
Gasoline Engines starburst symbol
of the proper viscosity. To
determine the preferred viscosity for
your vehicle's engine, see
Engine
Oil on page 5-15.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
žCoolant. SeeEngine
Coolant on page 5-28.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent or
equivalent.
Parking Brake
Cable GuidesChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or
lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Usage Fluid/Lubricant
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Automatic
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Chassis
LubricationChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or
lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Front Wheel
BearingsWheel bearing lubricant meeting
requirements of NLGI #2, Category
GC or GC-LB (GM Part No. U.S.
1051344, in Canada 993037, or
equivalent).
6-32

Audio System(s) (cont.)
Automatic Headlamp System............................3-13
Automatic Transmission Check..........................6-27
Automatic Transmission Shift Lock Control
System Check.............................................6-28
Automatic Transmission...................................5-25
Fluid..........................................................5-25
Operation...................................................2-23
B
Backing Up....................................................4-38
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-16
Battery..........................................................5-46
Before Leaving on a Long Trip.........................4-21
Bench Seat............................................1-11, 1-57
Body Lubrication Service..................................6-27
Brake Adjustment............................................5-45
Brake Fluid....................................................5-42
Brake Pedal Travel.........................................5-45
Brake Wear...................................................5-45
Brake............................................................2-26
Parking......................................................2-26
System Inspection.......................................6-31
System Warning Light..................................3-28
Brakes..........................................................5-42
Braking in Emergencies..................................... 4-9Braking........................................................... 4-6
Break-In, New Vehicle.....................................2-19
Bucket Seats, Rear.........................................1-12
Bulb Replacement...........................................5-55
Front Turn Signal Lamps..............................5-59
Halogen Bulbs............................................5-55
Headlamps.................................................5-55
Replacement Bulbs......................................5-61
Taillamps....................................................5-60
Buying New Tires...........................................5-66C
California Fuel.................................................. 5-6
Canada ± Customer Assistance.......................... 7-5
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Canceling the Sliding Door Security Lock...........2-12
Capacities and Speci®cations............................5-99
Carbon Monoxide...........................4-24, 4-31, 2-30
Care of.........................................................5-86
Safety Belts................................................5-86
Your CD Player...........................................3-50
Your CDs ...................................................3-50
Cargo Vans...........................................1-41, 1-48
Center Passenger Position, Safety Belts.............1-27
Chains, Tires..................................................5-70
Charging System Light....................................3-27
2

Operation Tips................................................3-22
Other Warning Devices...................................... 3-5
Outlet Adjustment............................................3-22
Outside.........................................................2-33
Convex Mirror.............................................2-33
Manual Mirror.............................................2-32
Power Mirrors.............................................2-32
Overhead Console..........................................2-39
Overseas ± Customer Assistance........................ 7-5
Owners, Canadian............................................... ii
Owner's Information........................................7-12
P
Park (P)........................................................2-29
Shifting Out of............................................2-29
Parking Brake and Automatic Transmission Park
(P)
Mechanism Check.......................................6-29
Parking on Hills..............................................4-39
Parking.........................................................2-26
Brake........................................................2-26
Over Things That Burn.................................2-30
Park(P).........................................................2-27
Shifting Into................................................2-27
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-26Part C - Periodic MaintenanceInspections..........6-30
Part D - Recommended Fluids and Lubricants....6-32
Part E - Maintenance Record...........................6-34
Passing.................................................4-12, 4-38
Passlock
ž......................................................2-18
Payload.........................................................4-31 .
Plan Ahead When Possible................................ 7-8
Playing a Compact Disc...................................3-43
Playing the Radio...................................3-39, 3-41
Power Steering................................................ 4-9
Power...........................................................3-16
Accessory Outlets........................................3-16
Door Locks.................................................. 2-8
Electrical System.........................................5-92
Seat............................................................ 1-3
Steering Fluid.............................................5-40
Windows....................................................2-17
Programmable Automatic Door Locks.................. 2-9
Programming the HomeLink Transmitter.............2-35
Q
Questions and Answers About Safety Belts.........1-17
10