2003 BMW MOTORRAD F 650 GS ignition

2
Introduction
12
i
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and
steering lock ...................... 8-9
Odometer/clock .................. 10
Hazard warning flashers ...... 11
Handlebar fitting ............ 12-13
Seat .................................... 14
Topcase .........................15-16
System case .................. 17-21 Safety check
Checklist ........................ 22-23
Engine oil ....................... 24-25
Fuel ................................ 26-27
Handlebar levers ............ 28-29
Brakes ........................... 30-34
Shock-absorbers ................ 35
Spring preload .................... 36
Drive chain ......................... 37
Loads............................. 38-39
Wheels ........................... 40-42
Coolant .............................. 43
Lights ............................. 44-45
Contents
10R13bkg4.book Seite 2 Montag, 22. September 2003 4:26 16

11
6
General information and controls
1Speedometer
2 Odometer/trip meter
3 Reset knob for trip meter
4 Telltale and warning lights
5 Clock
6 Rev. counter (
b54)
7 Button for setting clock,
minutes 8
Button for setting clock,
hours
9 Ignition switch and steering
lock (
b8)
10 ABS buttonOE
11Rocker switch, hazard
warning flashersOE
OEOptional extra
( ) Figure in brackets
bpage number for
description
Cockpit
163542
8791011
10R13bkg4.book Seite 6 Montag, 22. September 2003 4:26 16

11
8
General information and controls
KeysYou will receive two master
keys and one spare key.
The key number is on the
accompanying plastic tag.
OAOptional accessory
L Note:
Ignition switch and steering
lock, tank filler cap lock and
seat lock are all operated
with the same key. On re-
quest, System cases
OA can
be arranged to lock with the
same key.
Ignition switch and steering lock
10R13bkg4.book Seite 8 Montag, 22. September 2003 4:26 16

111
9
General information and controls
Ignition switch and steering lock
Key positions
d Warning:
Never turn the key to OFF or
I while riding the motorcy-
cle
ON Operating position,
ignition, lights and all
electrical circuits
switched on
R * Ignition and lights off,
steering not locked
(handlebars can be turned
freely to left or right)
* The key can be removed in these
positions
 Turn the handlebars to full left lock.
e Attention:
Engage the steering lock with
the handlebars in this position
only.
OFF* Ignition and lights off,
steering locked
I * Parking light on,
steering locked
L Note:
Switch the parking light on
for limited periods only. Note
state of battery charge.
10R13bkg4.book Seite 9 Montag, 22. September 2003 4:26 16

11
10
General information and controls
Odometer/trip meterDisplay 1 functions as odome-
ter and trip meter.
 Briefly press button 2 once to
switch from odometer to trip
meter or vice versa
 To reset the trip meter, select
the trip-meter display mode
and press and hold down
button 2 until the reading
resets to zero.
ClockNote that when you set clock 3
the numbers can only incre-
ment; you can set the hours
and minutes separately.  Switch on the ignition
Setting the hours:
 Briefly press button
4; the
clock advances one hour
 Press and hold down button 4; the clock continues to
advance through the hours.
Setting the minutes:
 Briefly press button 5 ; the
clock advances one minute
 Press and hold down button 5;
the clock continues to
advance through the minutes.L Note:
The longer you hold down but-
ton 4 or 5, the faster the clock
advances.
Odometer/clock
12345
10R13bkg4.book Seite 10 Montag, 22. September 2003 4:26 16

111
11
General information and controls
Hazard warning flashersOE
Hazard warning flashers
L Note:
You cannot activate the hazard
warning flashers if the ignition is
switched off.
Do not use the hazard warning
flashers for longer than abso-
lutely necessary.
Note state of battery charge.
To switch on the hazard
warning flashers:
 Switch on the ignition
 Operate hazard warning flasher switch 1
– Hazard warning flashers in
operation
– The telltale light in the switch
flashes  Switch off the ignition
– The hazard warning flashers
continue to operate
To switch off the hazard
warning flashers:
 Operate hazard warning flasher switch 1
– Hazard warning flashers
cease to operate
– The telltale light in the switch
is off
OEOptional extra
1
10R13bkg4.book Seite 11 Montag, 22. September 2003 4:26 16

111
13
General information and controls
5
7
6
5Emergency off (kill) switch
for ignition (
b56)
VIgnition circuit inter-
rupted
UIgnition circuit closed
6 Switch for heated handlebar
grips
OE
οHandlebar-grip heat-
ing OFF
50%
 100%
7 Starter switch
y
(b57)
( ) Figure in bracketsbpage number for
description
OEOptional extra
d Warning:
To prevent air from entering
the brake circuit:
 Do not turn the fitting on the handlebar.
 Do not turn the handlebars
in the clamping blocks.
Right handlebar fitting
10R13bkg4.book Seite 13 Montag, 22. September 2003 4:26 16

3
48
Starting – Riding – Parking
Important notes
Risk of fireHigh temperatures occur at the
exhaust system, particularly at
the catalytic converter.
d Warning:
Make sure that whether riding
or standing still or when the
motorcycle is parked, no eas-
ily flammable material
(for example hay, grass,
leaves, clothing or luggage
etc.) can come into contact
with the hot exhaust system.
Do not allow the engine to
idle unnecessarily or for pro-
longed periods of time
– risk of overheating or fire.
Ride away immediately after
starting the engine.
Risk of poisoningThe exhaust fumes contain car-
bon monoxide, which is colour-
less and odourless but highly
toxic.
d Warning:
Inhaling exhaust fumes there-
fore represents a health haz-
ard and can even cause loss
of consciousness with fatal
consequences.
Do not run the engine in an
enclosed space.
Risk of fatal accidentYour motorcycle is equipped
with a digital electronic engine
management system and a
high-power ignition system.
d Warning:
When the engine is running or
the ignition switched on, nev-
er touch electrically live parts
of the ignition system or the
digital engine electronics.
10R13bkg4.book Seite 48 Montag, 22. September 2003 4:26 16