2003 BMW MOTORRAD F 650 GS DAKAR check oil

2
Introduction
12
i
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and
steering lock ...................... 8-9
Odometer/clock .................. 10
Hazard warning flashers ...... 11
Handlebar fitting ............ 12-13
Seat .................................... 14
Topcase .........................15-16
System case .................. 17-21 Safety check
Checklist ........................ 22-23
Engine oil ....................... 24-25
Fuel ................................ 26-27
Handlebar levers ............ 28-29
Brakes ........................... 30-34
Shock-absorbers ................ 35
Spring preload .................... 36
Drive chain ......................... 37
Loads............................. 38-39
Wheels ........................... 40-42
Coolant .............................. 43
Lights ............................. 44-45
Contents
10R13bkg4.book Seite 2 Montag, 22. September 2003 4:26 16

11
4
General information and controls
1Oil filler check/dipstick,
engine oil (
b24)
2 Clutch lever (
b28)
3 Lifting handle (
b53)
( ) Figure in bracketsbpage number for
description
4 Seat lock (b14)
5 On-board socketOE
6Coolant tank (b43)
OEOptional extra
General view, left side
1342
65
10R13bkg4.book Seite 4 Montag, 22. September 2003 4:26 16

111
7
General information and controls
1Repeater,
flashing turn indicators left/
right green
J
2Warning light, ABS checkOE
red
D (b65)
3 Telltale light, high-beam
headlight, blue
q
4Warning light, engine oil
pressure, red
p (b59)
5 Warning light, coolant
temperature red
j (b58) 6
Telltale light,
neutral green
k
7Warning light, fuel
level down to approx.
4 litres (0.9 Imp. gal)
reserve, yellow
m
OEOptional extra
( ) Figure in brackets
bpage number for
description
Telltale and warning lights
13542
76
10r1301g4.fm Seite 7 Dienstag, 30. September 2003 1:36 13

1
23
Safety check
2
Checklist
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Clutch-lever play
–Brake pressure
– Brake fluid levels (front and rear)
– Operation of the ABS warning
light
–Drive chain
– Shock-absorber setting and
spring preload
– Wheel rim and tyre condition,
spokes, tread depth and tyre
pressures
–Loading
– Coolant level
–Lights – Check regularly (every time
you stop for fuel), on the basis
of the following section:
– Engine oil level
(every second stop for fuel)
– Brake pads
If you encounter any problems
or difficulties, please contact
your BMW motorcycle dealer.
He will provide the necessary
advice and assistance.
10R13bkg4.book Seite 23 Montag, 22. September 2003 4:26 16

24
Safety check
2
Engine oil
Checking oil level
e Attention:
The red warning light
p (b7)
for engine oil pressure indicates
that the oil pump is delivering
very little oil or none at all: do
not regard this light as an oil
level indicator. Oil pressure
builds up after1-2 seconds and
the warning light goes out – the
red engine oil pressure warning
light
p should remain off when
the engine is running. Check
the oil level regularly, each time
you stop for fuel (or every sec-
ond time at the latest).
The oil level might be low if the
motorcycle has not been in use
for an extended period of time.
Under these circumstances top
up the oil level only after meas-
uring the oil level in accordance
with the instructions.
Always check engine oil level
with the engine at its regular op-
erating temperature.
Checking the oil level when the
engine is cold, just after the en-
gine has been run briefly or
when it is not properly warm will
falsify the reading, and could
lead to the engine being operat-
ed with the wrong quantity of oil
in the system.
L Note:
The oil temperature affects the
reading. The warmer the oil, the
higher the oil level in the sump.
Check the oil after a run, in or-
der to avoid overfilling.
 Hold the motorcycle upright – Make sure the ground is level and firm.
– Check the oil when the engine is at operating temperature
(after the motorcycle has
been ridden, or else allow the
engine to idle until the fan
switches on)
 Allow the engine to idle for at least 1 minute
 Switch off the engine
 Use the spark plug wrench to remove plug 1
10R13bkg4.book Seite 24 Montag, 22. September 2003 4:26 16

1
25
Safety check
2
e Attention:
To avoid damage to the engine:
– never exceed the maximum oil level.
– However, always keep the oil
level above the minimum
mark.
 Wipe off oil dipstick 2, using a
clean, lint-free cloth
 To check the oil level, reinsert plug 1 with oil dipstick 2 into
its bore, but do not engage
the threads  Check oil level against marks
on dipstick:
MAX Maximum level
MIN Minimum level
The difference is equivalent to
approx. 0.4 litre (approx. 0.7 Imp. pint)
 If necessary, add oil through
filler neck 3 until the level
reaches middle mark A
 Reinstall plug 1
 Repeat the warm-up proce- dure and recheck the oil level
as described above
1
Engine oil
MAX
A
MIN
BMW recommends Castrol
2
3
10R13bkg4.book Seite 25 Montag, 22. September 2003 4:26 16

3
59
Starting – Riding – Parking
Engine oil pressureWarning light 3 p (red) goes
out above idle speed.
e Attention:
If warning light 3 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
 Disengage the clutch
 Operate the emergency off (kill) switch (
b56)
 Bring the motorcycle safely to a halt
 Check engine oil level
(b24)
e Attention:
If the motorcycle is being ridden
and warning light 3 lights up
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised BMW motorcycle
dealer.
Low fuel level
When warning light 4
m (yellow)
lights up, the usable quantity of
fuel left in the tank is approxi-
mately 4 litres (0.9 Imp. gal).
Telltale and warning lights
4
3
10R13bkg4.book Seite 59 Montag, 22. September 2003 4:26 16

ii
78
Indice alfabetico
AABS shutdown button, 6
Adjusting headlight beam throw, 44
Anti-lock brake system (ABS) Check, 65
Notes, 64
Self-diagnosis, 65
Troubleshooting, 65
Anti-lock braking system (ABS) Deactivation, 68
BBrake fluid levelChecking, 32
front brake, 33
Brake system, checking, 30
Brake-fluid level Checking
rear brake, 34
CCatalytic converter, 49Safety instructions, 49
Chain, 37
Checking brake pads, 31, 34
Clock, 6, 10
Clutch lever, 28
Clutch lever play, adjusting, 28
Cockpit, 6
Coolant, 43
Coolant level Check, 43
DDrive chain
Check, 37
EEmergency off (kill) switch for ignition, 13
Engine oil, 25
Engine oil pressure Telltale light, 59
Environmental protection, 73
FFront brake Brake fluid level, 33
Handbrake lever, 29
Fuel Octane number, 27
Fuel filler cap, 26
Fuel level Checking, 26
Fuel tank Capacity, 27
Fuel tank capacity, 59
Fuse box, 5
GGearbox in neutral Telltale light, 7
Gearshifts, 60, 61
General view Left side, 4
Right side, 5
A - G
10R13bkg4.book Seite 78 Montag, 22. September 2003 4:26 16