2003 BMW MOTORRAD F 650 CS engine oil

2
Introduction
12
i
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Odometer/clock .................. 10
Hazard warning flashers ...... 11
Left handlebar fitting ........... 12
Right handlebar fitting ......... 13
Seat .................................... 14
Softbag .......................... 15-18
Topcase .........................19-20 Safety check
Checklist ........................ 21-22
Engine oil ....................... 23-25
Fuel ................................ 26-27
Handlebar levers ............ 28-29
Brake system
– general ........................ 30-31
Brake system ................. 32-33
Brakes ................................ 34
Drive belt ............................ 35
Spring preload .................... 36
Shock-absorber
adjustment .......................... 37
Wheels ........................... 38-39
Accessories and tyres......... 40
Loading............................... 41
Coolant .......................... 42-43
Lights ............................. 44-46
Contents
10K14bkg2.book Seite 2 Montag, 15. September 2003 5:30 17

11
4
General information and controls
1Clutch lever (b28)
2 Stowage compartment
3 Stowage-compartment rail
4 Seat lock (
b14)
5 Wheel nut, rear wheel 6
Toolkit
Funnel for engine oil
Adapter
from w/f 27 mm (1.06 in) to
w/f 55 mm (2.17 in) for rear
wheel
7 Coolant reservoir
(
b42)
8 Cover insert, left (
b42)
( ) Figure in bracketsbpage number for
description
General view, left side
1234
8765
10K14bkg2.book Seite 4 Montag, 15. September 2003 5:30 17

111
5
General information and controls
9Fuel tank/fuel-tank cap
(
b 26, 27)
10 Fuse box
11 Engine oil filler neck/dip-
stick (
b25)
12 Brake-fluid reservoir for
front brake (
b33)
( ) Figure in bracketsbpage number for
description
13 Type plate
14 Headlight adjuster screw,
up/down
15 Vehicle identification
number
16 Drive belt
17 Brake-fluid reservoir for rear
brake (
b34)
General view, right side
9101213
14
1516
11
17
10K14bkg2.book Seite 5 Montag, 15. September 2003 5:30 17

111
7
General information and controls1Telltale light,
flashing turn indicators left/
right green
Z
2Warning light, ABS checkOE
red
D (b65)
3 Telltale light,
high-beam headlight blue
q
4Warning light, engine oil
pressure red
p (b59)
OEOptional extra
5Warning light, coolant tem-
perature red
j (b58)
6 Telltale light, neutral
green
k
7Warning light,
fuel level when approx.
4 litres left in tank yellow
m
( ) Figure in bracketsbpage number for
description
Telltale and warning lights
13542
76
10K14bkg2.book Seite 7 Montag, 15. September 2003 5:30 17

22
Safety check
2
Checklist
For this reason, check the
details in the following sections
before you start the journey:
–Fuel level
–Clutch-lever play
– Brake pressure
– Brake fluid levels (front and rear)
–Drive belt
– Warning lights and telltale lights
– Wheel rim and tyre condition, tread depth and tyre pres-
sures – Load and gross weight
–Coolant level
– Lights
– Check regularly (every time
you stop for fuel), on the basis
of the following section:
– Engine oil level (every second stop for fuel)
– Brake pads
If you encounter any problems
or difficulties, it is always best
to contact your authorised
BMW motorcycle dealer. He will
provide the necessary advice
and assistance.
10K14bkg2.book Seite 22 Montag, 15. September 2003 5:30 17

1
23
Safety check
2
Engine oil
Checking oil level
e Attention:
The red warning light
p (b7)
for engine oil pressure indicates
that the oil pump is delivering
very little oil or none at all: do
not regard this light as an oil
level indicator. Oil pressure
builds up after 1 – 2 seconds
and the warning light goes out –
the red engine oil pressure
warning light
p should remain
off when the engine is running.
Check the oil level regularly,
each time you stop for fuel (or
every second time at the latest).
e Attention:
The dipstick might show a low
oil level if the motorcycle has
been out of use for a lengthy
period. Under these circum-
stances top up the oil level only
after measuring the oil level in
accordance with the instruc-
tions.
Check the oil level only when
the engine is at operating tem-
perature.
Checking the oil level when the
engine is cold, just after the en-
gine has been run briefly or
when it is not properly warm will
falsify the reading, and could
lead to the engine being operat-
ed with the wrong quantity of oil
in the system.
10K14bkg2.book Seite 23 Montag, 15. September 2003 5:30 17

24
Safety check
2
Engine oil
L Note:
The oil level varies with the tem-
perature of the oil. The higher
the temperature, the higher the
level of oil in the tank.
In order to avoid overfilling, it is
advisable to check the oil level
after the motorcycle has been
ridden.  Hold the motorcycle upright
– Make sure the ground is level and firm.
– Check the oil when the engine is at operating temperature
(after the motorcycle has
been ridden, or else allow the
engine to idle until the fan
switches on)
 Allow the engine to idle for at least 1 minute
 Switch off the ignition
 Remove plug 2
e Attention:
To avoid damage to the engine:
– Never exceed the maximum oil level.
– Always keep the level above
the minimum mark.
10K14bkg2.book Seite 24 Montag, 15. September 2003 5:30 17

1
25
Safety check
2
MAX
MIN
1
34
2
A
 Wipe off oil dipstick 4, using a
clean, lint-free cloth
 To check the oil level, reinsert
plug 2 with oil dipstick 4 into
its bore, but do not engage
the threads
 Check the oil level at the marks:
MAX Maximum level
MIN Minimum level
The difference between
the two marks corresponds
to approx. 0.4 litre
(0.70 imp. pint)  If necessary, use funnel
1 to
add oil through filler neck 3
until the level reaches middle
mark A
 Reinstall plug 2
 Repeat the warm-up proce- dure and re-check the oil level
as described above
Engine oil
BMW recommends Castrol
10K14bkg2.book Seite 25 Montag, 15. September 2003 5:30 17