2003 BMW MOTORRAD F 650 CS check engine light

2
Introduction
12
i
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Odometer/clock .................. 10
Hazard warning flashers ...... 11
Left handlebar fitting ........... 12
Right handlebar fitting ......... 13
Seat .................................... 14
Softbag .......................... 15-18
Topcase .........................19-20 Safety check
Checklist ........................ 21-22
Engine oil ....................... 23-25
Fuel ................................ 26-27
Handlebar levers ............ 28-29
Brake system
– general ........................ 30-31
Brake system ................. 32-33
Brakes ................................ 34
Drive belt ............................ 35
Spring preload .................... 36
Shock-absorber
adjustment .......................... 37
Wheels ........................... 38-39
Accessories and tyres......... 40
Loading............................... 41
Coolant .......................... 42-43
Lights ............................. 44-46
Contents
10K14bkg2.book Seite 2 Montag, 15. September 2003 5:30 17

111
7
General information and controls1Telltale light,
flashing turn indicators left/
right green
Z
2Warning light, ABS checkOE
red
D (b65)
3 Telltale light,
high-beam headlight blue
q
4Warning light, engine oil
pressure red
p (b59)
OEOptional extra
5Warning light, coolant tem-
perature red
j (b58)
6 Telltale light, neutral
green
k
7Warning light,
fuel level when approx.
4 litres left in tank yellow
m
( ) Figure in bracketsbpage number for
description
Telltale and warning lights
13542
76
10K14bkg2.book Seite 7 Montag, 15. September 2003 5:30 17

22
Safety check
2
Checklist
For this reason, check the
details in the following sections
before you start the journey:
–Fuel level
–Clutch-lever play
– Brake pressure
– Brake fluid levels (front and rear)
–Drive belt
– Warning lights and telltale lights
– Wheel rim and tyre condition, tread depth and tyre pres-
sures – Load and gross weight
–Coolant level
– Lights
– Check regularly (every time
you stop for fuel), on the basis
of the following section:
– Engine oil level (every second stop for fuel)
– Brake pads
If you encounter any problems
or difficulties, it is always best
to contact your authorised
BMW motorcycle dealer. He will
provide the necessary advice
and assistance.
10K14bkg2.book Seite 22 Montag, 15. September 2003 5:30 17

1
23
Safety check
2
Engine oil
Checking oil level
e Attention:
The red warning light
p (b7)
for engine oil pressure indicates
that the oil pump is delivering
very little oil or none at all: do
not regard this light as an oil
level indicator. Oil pressure
builds up after 1 – 2 seconds
and the warning light goes out –
the red engine oil pressure
warning light
p should remain
off when the engine is running.
Check the oil level regularly,
each time you stop for fuel (or
every second time at the latest).
e Attention:
The dipstick might show a low
oil level if the motorcycle has
been out of use for a lengthy
period. Under these circum-
stances top up the oil level only
after measuring the oil level in
accordance with the instruc-
tions.
Check the oil level only when
the engine is at operating tem-
perature.
Checking the oil level when the
engine is cold, just after the en-
gine has been run briefly or
when it is not properly warm will
falsify the reading, and could
lead to the engine being operat-
ed with the wrong quantity of oil
in the system.
10K14bkg2.book Seite 23 Montag, 15. September 2003 5:30 17

42
Safety check
2
Checking coolant level
e Attention:
Always keep the coolant level
above the minimum mark.
Check coolant level only when
the engine is cold.
 Hold the motorcycle upright
 Check the coolant level through slot 1 in cover insert 2
of the expansion tank:
MIN Minimum level
 Add coolant if necessaryL Note:
If the expansion tank is full and
the coolant temperature is high
(as indicated by red warning
light
j b 58) or coolant con-
sumption is excessive, consult
a specialist workshop, prefera-
bly an authorised BMW motor-
cycle dealer.
Coolant
1
2
MIN
10K14bkg2.book Seite 42 Montag, 15. September 2003 5:30 17

3
58
Starting – Riding – Parking
ABS check– ABS warning light 1
(
b 64-68)
Coolant temperatureWarning light 2 j (red) flashes
for approx. 3 seconds after you
switch on the ignition.
The electronic engine manage-
ment system initialises itself
during this period.
e Attention:
If the coolant temperature
warning light
j comes on, stop
the engine and allow it to cool
down.
Check coolant level in the
expansion tank (
b42).
If the expansion tank is full, but
the warning light remains on, or
if coolant consumption is exces-
sive, consult a specialist work-
shop, preferably an authorised
BMW motorcycle dealer.
Telltale and warning lights
12
10K14bkg2.book Seite 58 Montag, 15. September 2003 5:30 17

3
59
Starting – Riding – ParkingEngine oil pressureWarning light4 p (red) goes
out above idle speed.
e Attention:
If warning light 4 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
 Disengage the clutch
 Operate the kill switch (
b56)
 Bring the motorcycle safely to a halt
 Check engine oil level
(b25)
e Attention:
If the motorcycle is being ridden
and warning light 4 lights up
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised BMW motorcycle
dealer.
Low fuel levelWhen warning light 3 m (yellow)
lights up, the usable quantity of
fuel left in the tank is approxi-
mately 4 litres.
Telltale and warning lights
34
10K14bkg2.book Seite 59 Montag, 15. September 2003 5:30 17

3
65
Starting – Riding – Parking
d Warning:
Do not operate high-power
radio equipment on the mo-
torcycle. There is a slight risk
of it affecting operation of the
ABS.
ABS checkAutomatic activation when you
switch on the ignition.
Warning light 1 comes on.
ABS self-diagnosis
When you start the engine and
pull away:
– Warning light 1 goes out to
indicate that ABS is opera-
tional
OEOptional extra
Anti-lock braking system (ABS)OE
1
10K14bkg2.book Seite 65 Montag, 15. September 2003 5:30 17