PERIODIC MAINTENANCE AND MINOR REPAIR
6-21
6
EAU00680
WARNING
_
It is dangerous to ride with a
worn-out tire. When a tire tread
begins to show crosswise lines,
have a Yamaha dealer replace
the tire immediately.
The replacement of all wheel-
and brake-related parts, includ-
ing the tires, should be left to a
Yamaha dealer, who has the
necessary professional knowl-
edge and experience.
It is not recommended to patch
a punctured tube. If unavoid-
able, however, patch the tube
very carefully and replace it as
soon as possible with a high-
quality product.
_
EAU00685
Spoke wheels To maximize the performance, durabil-
ity, and safe operation of your motor-
cycle, note the following points
regarding the specified wheels.
The wheel rims should be checked
for cracks, bends or warpage, and
the spokes for looseness or dam-
age before each ride. If any dam-
age is found, have a Yamaha
dealer replace the wheel. Do not
attempt even the smallest repair to
the wheel. A deformed or cracked
wheel must be replaced.
The wheel should be balanced
whenever either the tire or wheel
has been changed or replaced. An
unbalanced wheel can result in
poor performance, adverse han-
dling characteristics, and a short-
ened tire life.
Ride at moderate speeds after
changing a tire since the tire sur-
face must first be “broken in” for it
to develop its optimal characteris-
tics.
EAU03851*
Checking the front brake lever
free playSince this model is equipped with a hy-
draulic front brake, adjusting the brake
lever free play is not needed.
However, it is necessary to check the
brake fluid level and check the hydrau-
lic system for leakage.1. Front brake lever
U5MXE0.book Page 21 Thursday, December 20, 2001 2:08 PM
SPECIFICATIONS
8-2
8
Transmission
Primary reduction system Helical gear
Primary reduction ratio 3.133
Secondary reduction system Spur gear
Secondary reduction ratio 3.583
Number of drive chain
sprocket teeth (rear/front) 43/12
Transmission type V-belt automatic
Operation Centrifugal automatic type
Chassis
Frame type Steel tube underbone
Caster angle 25°
Trail 112 mm
Tires
Fro nt
Ty p e Tu b e t i r e
Size 70/90-16 36P
Manufacturer/
model Dunlop/D110
Rear
Ty p e Tu b e t i r e
Size 80/90-16 43P
Manufacturer/
model Dunlop/D110Tire air pressure
(measured on cold tires)
Front 200 kPa (2.00 kgf/cm
2)
Rear 225 kPa (2.25 kgf/cm2)
Wheels
Fr on t
Type Spoke wheel
Size 16 × 1.40
Rear
Type Spoke wheel
Size 16 × 1.60
Brakes
Fr on t
Type Single disc brake
Operation Right hand
Fluid DOT 3 or 4
Rear
Ty p e
Drum brake
Operation Left hand
Suspension
Fr on t
Ty p e
Telescopic fork
Rear
Ty p e
Unit swing
U5MXE0.book Page 2 Thursday, December 20, 2001 2:08 PM