2002 TOYOTA TUNDRA engine

’02 TUNDRA_U (L/O 0108)
2632002 MY TUNDRA_U (OM 34417U)
NOTICE
Be sure the engine and all accesso-
ries are off before performing main-
tenance.
 When checking the battery, remove
the ground cable from the negative
terminal (“” mark) first and rein-
stall it last.
 Be careful not to cause a short cir-
cuit with tools.
 Take care no solution gets into the
battery when washing it.
Ty p e A
Green Dark Clear or
light yellow
Ty p e B Blue White Red
CHECKING BY INDICATOR
Check the battery condition by the indi-
cator color.
Indicator color
ConditionTy p e ATy p e B
GreenBlueGood
DarkWhite
Charging necessary.
Have battery checked
by your Toyota deal-
er.
Clear orLight
Yellow
Red
Have battery
checked by your
Toyota dealer.
During recharging, the battery is pro-
ducing hydrogen gas.
Therefore, before recharging:
1. If recharging with the battery installed on the vehicle, be sure to disconnect
the ground cable.
2. Be sure the power switch on the re- charger is off when connecting the
charger cables to the battery and when
disconnecting them.
CAUTION
Always charge the battery in an un-
confined area. Do not charge the
battery in a garage or closed room
where there is not sufficient ventila-
tion.
Only do a slow charge (5 A or
less). Charging at a quicker rate is
dangerous. The battery may ex-
plode, causing personal injuries.
NOTICE
Never recharge the battery while the
engine is running. Also, be sure all
accessories are turned off.
—Checking battery c ondition Battery recharging pr ecautions

’02 TUNDRA_U (L/O 0108)
2652002 MY TUNDRA_U (OM 34417U)
If the new fuse immediately blows out,
there is a problem with the electrical sys-
tem. Have your Toyota dealer correct it as
soon as possible.
CAUTION
Never use a fuse with a higher am-
perage rating, or any other object, in
place of a fuse. This may cause ex-
tensive damage and possibly a fire.
If any washer does not work or low
windshield washer fluid level warning
light comes on, the washer tank may be
empty. Add washer fluid.
You may use plain water as washer fluid.
However, in cold areas where tempera-
tures range below freezing point, use
washer fluid containing antifreeze. This
product is available at your Toyota dealer
and most auto parts stores. Follow the
manufacturer ’s directions for how much to
mix with water.
NOTICE
Do not use engine antifreeze or any
other substitute because it may dam-
age your vehicle’s paint.
The following illustrations show how to
gain access to the bulbs. When replacing
a bulb, make sure the ignition switch and
light switch are off. Use bulbs with the
wattage ratings given in the table.
CAUTION
To prevent yourself from burning,
do not replace the light bulbs while
they are hot.
Halogen bulbs have pressurized gas
inside and require special handling.
They can burst or shatter if
scratched or dropped. Hold a bulb
only by its plastic or metal case.
Do not touch the glass part of a
bulb with bare hands.
NOTICE
Only use a bulb of the listed type.
Adding washer fluid Replacing light bulbs—

’02 TUNDRA_U (L/O 0108)
2732002 MY TUNDRA_U (OM 34417U)
SPECIFICATIONS
Dimensions 274
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . .
Payload 275
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . .
Engine 277
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . .
Fuel 277
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Service specifications 277
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . .
Tires 280
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . .
Fuses 280
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . .
SECTION 8

’02 TUNDRA_U (L/O 0108)
2742002 MY TUNDRA_U (OM 34417U)
Dimensions
TWOWHEEL DRIVE MODELSFOURWHEEL DRIVE MODELS
Standard cab modelsAccess cab modelsStandard cab modelsAccess cab models
Overall length mm (in.)5525 (217.5)5525 (217.5)5525 (217.5)5525 (217.5)
Overall width mm (in.)1910 (75.2)1910 (75.2)
1940 (76.4)∗
1
2015 (79.3)∗2
1910 (75.2)
1940 (76.4)∗2
1910 (75.2)
1940 (76.4)∗1
2015 (79.3)∗2
Overall height∗3mm (in.)1800 (70.9)
1800 (70.9)∗4
1805 (71.1)∗5
1810 (71.3)∗6
1815 (71.5)∗7
1830 (72.0)∗8
1815 (71.5)
1820 (71.7)∗4
1825 (71.9)∗5
1830 (72.0)∗6
1835 (72.2)∗7
Wheelbase mm (in.)3260 (128.3)3260 (128.3)3260 (128.3)3260 (128.3)
Front treadmm (in.)1680 (66.1)1675 (65.9)∗
8
1680 (66.1)1675 (65.9)1675 (65.9)
Rear tread mm (in.)1648 (64.9)1648 (64.9)1648 (64.9)1648 (64.9)
∗
1: With wheel arch moulding∗2: With over fender∗3: Unladen vehicle∗4: With 2UZFE engine and with P245/70R16 tires∗5: With 5VZFE engine and with P245/70R16 tires∗6: With 2UZFE engine and with P265/70R16 tires∗7: With 5VZFE engine and with P265/70R16 tires∗8: Offroad package

’02 TUNDRA_U (L/O 0108)
2752002 MY TUNDRA_U (OM 34417U)
Payload∗
U.S.A. kg (lb.)
Standard cab
5VZFE engine
Twowheel drive modelsManual transmissionStandard grade773 (1705)
Automatic transmissionStandard grade753 (1661)
Fourwheel drive modelsManual transmissionSR5 grade651 (1436)
Automatic transmissionSR5 grade631 (1392)
2UZFE engineFourwheel drive modelsAutomatic transmissionSR5 grade879 (1938)
Access cab
5VZFE engine
Twowheel drive models
Manual transmissionSR5 grade731 (1612)
Automatic transmissionSR5 grade710 (1567)
Limited grade653 (1441)
Fourwheel drive models
Manual transmissionSR5 grade762 (1680)
Automatic transmissionSR5 grade736 (1624)
Limited grade679 (1499)
2UZFE engine
Twowheel drive modelsAutomatic transmissionSR5 grade872 (1924)
Limited grade815 (1798)
Fourwheel drive modelsAutomatic transmissionSR5 grade685 (1512)
Limited grade619 (1366)
∗: Occupants + luggage

’02 TUNDRA_U (L/O 0108)
2762002 MY TUNDRA_U (OM 34417U)
Canada kg (lb.)
Standard cab
5VZFE engineTwowheel drive modelsManual transmissionStandard grade763 (1683)
Automatic transmissionStandard grade743 (1639)
Fourwheel drive modelsAutomatic transmissionStandard grade633 (1396)
2UZFE engineFourwheel drive modelsAutomatic transmissionStandard grade893 (1969)
Access cab
5VZFE engineFourwheel drive modelsAutomatic transmissionSR5 grade726 (1602)
2UZFE engine
Twowheel drive modelsAutomatic transmissionSR5 grade862 (1902)
Limited grade814 (1795)
Fourwheel drive modelsAutomatic transmissionSR5 grade684 (1509)
Limited grade635 (1402)

’02 TUNDRA_U (L/O 0108)
2772002 MY TUNDRA_U (OM 34417U)
Model:
5VZFE and 2UZFE
Type: 5VZFE engine6 cylinder V type, 4 cycle, gasoline
2UZFE engine
8 cylinder V type, 4 cycle, gasoline
Bore and stroke, mm (in.): 5VZFE engine93.5 82.0 (3.68 3.23)
2UZFE engine
94.0 84.0 (3.70 3.31)
Displacement, cm
3 (cu. in.):
5VZFE engine 3378 (206.1)
2UZFE engine 4664 (284.6) Fuel type:
Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher
Fuel tank capacity, L (gal., Imp. gal.): 100 (26.4, 22.0) ENGINE
Valve clearance (engine cold), mm (in.):
5VZFE engineIntake 0.13—0.23 (0.006—0.009)
Exhaust 0.27—0.37 (0.011—0.014)
2UZFE engine Intake 0.15—0.25 (0.006—0.010)
Exhaust 0.25—0.35 (0.010—0.014)
Spark plug type: 5VZFE engineDENSO K16TR11
NGK BKR5EKB11
2UZFE engine DENSO K20RU
NGK BKR6EYA
Spark plug gap, mm (in.): 5VZFE engine 1.1 (0.043)
2UZFE engine 0.8 (0.031)
Drive belt tension measured with Bor-
roughs drive belt tension gauge
No.BT3373F (used belt), lbf: 5VZFE engineGenerator belt 100  20
Air conditioning compressor belt
100
+20
10
Power steering pump belt100+20
15
Engine FuelService specifications

’02 TUNDRA_U (L/O 0108)
2782002 MY TUNDRA_U (OM 34417U)
ENGINE LUBRICATION
Oil capacity (drain and ref ill), L (qt., Imp.
qt.):
5VZFE engineWith filter 5.2 (5.5, 4.6)
Without filter 4.9 (5.2, 4.3)
2UZFE engine With filter 6.2 (6.5, 5.5)
Without filter 5.7 (6.0, 5.0)
Oil grade: API grade SJ “EnergyConserving”, SL
“EnergyConserving” or ILSAC
multigrade engine oil is recommended.
Recommended oil viscosity (SAE):
5W-30 Preferred
Temperature range anticipated before
next oil change
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.): With manual transmission 10.0 (10.6, 8.8)
With automatic transmission 5VZFE engine 9.9 (10.5, 8.7)
2UZFE engine 11.6 (12.3, 10.2)
Coolant type: “TOYOTA Long Life Coolant” or equiva-
lent
With ethyleneglycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af- ter the key is removed with all the
lights turned off
Charging rates: 5 A max. CLUTCH
Pedal free play, mm (in.):
5—15 (0.2—0.6)
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSMISSION
Oil capacity, L (qt., Imp. qt.): Twowheel drive models 2.6 (2.7, 2.3)
Fourwheel drive models
2.2 (2.3, 1.9)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90
AUTOMATIC TRANSMISSION
Fluid capacity (drain and ref ill), L (qt.,
Imp. qt.): Up to 2.0 (2.1, 1.8)
Fluid type: Automatic transmission fluid DII or
DEXRON III (DEXRON II)