2002 TOYOTA SEQUOIA engine oil

02_SEQUOIA_U (L/O 0108)
2832002 MY SEQUOIA_U (OM34418U)
DOITYOURSELF MAINTENANCE
Engine and Chassis
Checking the engine oil level284
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine coolant level 285
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the radiator and condenser 286
. . . . . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 287
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
Checking power steering fluid 287
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking tire pressure 288
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Checking and replacing tires 289
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotating tires 290
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
Installing snow tires and chains 291
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing wheels 292
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . .
Aluminum wheel precautions 293
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SECTION 7 2

02_SEQUOIA_U (L/O 0108)
2842002 MY SEQUOIA_U (OM34418U)
Full level
Add oil O.K. Too full Low level
With the engine at operating tempera-
ture and turned off, check the oil level
on the dipstick.
1. To get a true reading, the vehicle should be on a level spot. After turning
off the engine, wait a few minutes for
the oil to drain back into the bottom of
the engine.
2. Pull out the dipstick, and wipe it clean with a rag.
3. Reinsert the dipstick—push it in as far as it will go, or the reading will not be
correct.
4. Pull the dipstick out and look at the oil level on the end.
CAUTION
Be careful not to touch the hot ex-
haust manifold.
If the oil level is below or only slightly
above the low level, add engine oil of
the same type as already in the engine.
Remove the oil filler cap and add engine
oil in small quantities at a time, checking
the dipstick.
The approximate quantity of oil needed to
fill between the low level and the full level
on the dipstick is indicated below for ref-
erence.
When the level reaches within the correct
range, install the f iller cap handtight.
Oil quantity, L (qt., lmp. qt.): 1.5 (1.6, 1.3)
NOTICE
 Avoid overfilling, or the engine
could be damaged.
 Check the oil level on the dipstick
once again after adding the oil.
ENGINE OIL SELECTION
Use API grade SJ or SL,
“EnergyConserving” or ILSAC multigrade
engine oil.
Recommended viscosity (SAE):
5W-30 Preferred
Temperature range anticipated before
next oil change
SAE 5W30 is the best choice for your
vehicle, for good fuel economy and
good starting in cold weather.
If you use SAE 10W30 engine oil in
extremely low temperatures, the engine
may become difficult to start, so SAE
5W30 engine oil is recommended.
Checking the engine oil level

02_SEQUOIA_U (L/O 0108)
2852002 MY SEQUOIA_U (OM34418U)
API service symbol
ILSAC certification mark
Oil identification marks
Either or both API registered marks are
added to some oil containers to help
you select the oil you should use.
The API Service Symbol is located any-
where on the outside of the container.
The top portion of the label shows the oil
quality by API (American Petroleum Insti-
tute) designations such as SL. The center
portion of the label shows the SAE viscos-
ity grade such as SAE 5W30. “Energy
Conserving” shown in the lower portion,
indicates that the oil has fuelsaving ca-
pabilities.
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is displayed on the front of
the container.Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “F” and “L” lines on the reservoir.
If the level is low, add ethyleneglycol
type coolant for a proper corrosion
protection of aluminum components.
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “L” line, add
coolant. Bring the level up to the “F” line.
Always use ethyleneglycol type coolant
for a proper corrosion protection of alumi-
num components. See information in the
next column.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, radiator cap and drain
cock and water pump.
If you can find no leak, have your Toyota
dealer test the cap pressure and check
for leaks in the cooling system.
Checking the engine coolant
level

02_SEQUOIA_U (L/O 0108)
3092002 MY SEQUOIA_U (OM34418U)
Fuel type:Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher
Fuel tank capacity, L (gal., Imp. gal.): 98.5 (26, 21.6) ENGINE
Valve clearance (engine cold), mm (in.):
Intake 0.15—0.25 (0.006—0.010)
Exhaust 0.25—0.35 (0.010—0.014)
Spark plug type: DENSO K20RU
NGK BKR6EYA
Spark plug gap, mm (in.): 0.8 (0.031)
ENGINE LUBRICATION
Oil capacity (drain and ref ill),
L (qt., Imp. qt.): With filter 6.2 (6.5, 5.5)
Without filter 5.7 (6.0, 5.0) Oil grade:
API grade SJ or SL,
“EnergyConserving” or ILSAC
multigrade engine oil is recommended.
Recommended oil viscosity (SAE):
5W-30 Preferred
Temperature range anticipated before
next oil change
Fuel Service specifications

02_SEQUOIA_U (L/O 0108)
3102002 MY SEQUOIA_U (OM34418U)
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):With rear heater 13.4 (14.1, 11.8)
Without rear heater 11.7 (12.4, 10.2)
Coolant type:
“TOYOTA Long Life Coolant” or equiva-
lent
With ethyleneglycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af- ter the key is removed with all the
lights turned off
Charging rates: 5 A max. AUTOMATIC TRANSMISSION
Fluid capacity (drain and ref
ill),
L (qt., Imp. qt.):
Up to 2.0 (2.1, 1.8)
Fluid type: Automatic transmission fluid DII or
DEXRON III (DEXRON II)
TRANSFER
Oil capacity, L (qt., Imp. qt.): 1.2 (1.3, 1.1)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90
DIFFERENTIAL
Oil capacity, L (qt., Imp. qt.): Front
1.15 (1.2, 1.0)
Rear 3.65 (3.9, 3.3)
Oil type: Hypoid gear oil API GL5 Recommended oil viscosity:
FrontSAE 75W90
Rear Above 18 C (0 F)
SAE 90
Below 18 C (0 F)
SAE 80W or 80W90
CHASSIS LUBRICATION
Propeller shafts: Spiders and slide yokesLithium base chassis grease, NLGI
No.2
BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine stopping and after de-
pressing the brake pedal several times,
mm (in.): 113 (4.5)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)

02_SEQUOIA_U (L/O 0108)
3222002 MY SEQUOIA_U (OM34418U)
A
Active traction control system warning light 125 . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 299 . . . . . . . . . . . . . . . . . .
Adjustment
Front seats 37,38 . . . . . . . . . . . . . . . . . . . . . .
Seat belt 55 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Second seat 40 . . . . . . . . . . . . . . . . . . . . . . . .
Third seats 45 . . . . . . . . . . . . . . . . . . . . . . . . .
Airbags 68,75 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 293 . . . . . . . . . .
Antiglare inside rear view mirror 106 . . . . . .
Antilock brake system
warning light 125 . . . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 132 . . . . . . . .
Appearance care
Cleaning the interior 267 . . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 264 . . . . . . . . . . . . . . . . . . .
Washing and waxing 265 . . . . . . . . . . . . . . . .
Armrests 53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic door locking and unlocking functions 14 . . . . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 133 . . . . . . . .
Shift pattern 133 . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 133 . . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 125 . . . . . . . . . . .
Auxiliary box 200 . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 29 . . . . . . . . . . .
B
Back door 27
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 27
. . . . . . . . . . . . . . . . . . . . . . . .
Back window 25
. . . . . . . . . . . . . . . . . . . . . . . . .
Back window and outside rear view mirror defogger switch 119
. . . . . . . . .
Back window wiper and washer switch 118
. . . . . . . . . . . . . . . . . . . . .
Battery
Checking battery condition 296
. . . . . . . . . .
Gas caution 296
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 296
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 297
. . . . . . . . . . . . .
Winter driving tips 232
. . . . . . . . . . . . . . . . . .
Before starting the engine 228
. . . . . . . . . . . . .
Brake pad wear limit indicators 222 . . . . . . . .
Brake system 218
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 125
. . . . . . . . . . . .
Brakes
Fluid level 287
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 222
. . . . . . . . . . . .
Parking 147
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 213
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 114
. . . . . . . . . . . . . . . . . . . .
C
Car audio system 152
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 217
. . . . . . . . . . . . .
Cargo net hooks 207
. . . . . . . . . . . . . . . . . . . . .
Cassette player 152
. . . . . . . . . . . . . . . . . . . . . .
Center interior and personal lights 115 . . . . . . Checking and replacing fuses
298
. . . . . . . . .
Checking brake fluid 287
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 284
. . . . . . . . . .
Checking the radiator and condenser 286
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 83
. . . . . . . . . . . . . . .
Installation 85
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 99,101
. . . . . . . . . . . . .
Precautions 82
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 84 . . . . . . . .
Using a top strap 95,97
. . . . . . . . . . . . . . . . .
Cigarette lighter and ashtray 195
. . . . . . . . . .
Cleaning the interior 267
. . . . . . . . . . . . . . . . . .
Clock 195
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coin holder 203
. . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 232
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc and cassette tape holder
Cassette tape holder 205
. . . . . . . . . . . . . . .
Compact disc holder 205
. . . . . . . . . . . . . . . .
Compact disc auto changer 152
. . . . . . . . . . .
Compact disc auto changer controller 152
. . . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc player 152
. . . . . . . . . . . . . . . . . .
Compass 191
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 286
. . . . . . . . . . . .
Console box
Rear 202
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,4
. . . . . . . . . . . .

02_SEQUOIA_U (L/O 0108)
3232002 MY SEQUOIA_U (OM34418U)
Cooling systemCoolant level 285 . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 248 . . . . . . . . . . . . . . . . .
Radiator and reservoir 285 . . . . . . . . . . . . . .
Radiator cap 248 . . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Corrosion prevention 264 . . . . . . . . . . . . . . . . .
Cruise control 148 . . . . . . . . . . . . . . . . . . . . . . .
Cup holders 205 . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Back window 119 . . . . . . . . . . . . . . . . . . . . . .
Outside rear view mirror 119 . . . . . . . . . . . .
Dimmer switch, Headlight 110,112 . . . . . . . . .
Dinghy towing 233 . . . . . . . . . . . . . . . . . . . . . . .
Directional signals 110,112 . . . . . . . . . . . . . . .
Discharge warning light 125 . . . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 281 . . . . . . . . . . . . . . . . . . . . .
Service precautions 280 . . . . . . . . . . . . . . . .
Does your vehicle need repairing? 275 . . . . .
Doors
Side doors 12 . . . . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 125 . . . . . .
Driver ’s seat belt reminder light 125 . . . . . . . .
Driving
Automatic transmission 133 . . . . . . . . . . . . .
Driving tips 228 . . . . . . . . . . . . . . . . . . . . . . . .
Driving tips
Driving tips in various conditions 229 . . . . .
Driving with an automatic transmission 133 . . . . . . . .
Economical driving 240 . . . . . . . . . . . . . . . . . Good driving practice 133
. . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
During
Breakin 213 . . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 240 . . . . . . . . . . . . . . . . . . . . . .
Electric moon roof 32 . . . . . . . . . . . . . . . . . . . . .
Electrical system,
Battery 296,297 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 279 . . . . . . . . . . . . . . . . . . . . .
Fuses 298 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 113 . . . . . . . . . . . . .
Emergency, In case of8
Blown fuse 298 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 113 . . . . . . . . . . .
Flat tire 249 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the engine speed 247 . . . . . . . . . . . . . . . . .
If you lose your keys 261 . . . . . . . . . . . . . . . .
If you lose your wireless remote control transmitter 261 . . . . . . . . . . . . . . . .
If your engine stalls while driving 247 . . . . .
If your vehicle needs to be towed 257 . . . . .
If your vehicle will not start 244 . . . . . . . . . .
Jump starting 245 . . . . . . . . . . . . . . . . . . . . . .
Overheating 248 . . . . . . . . . . . . . . . . . . . . . . .
Towing 257 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and
Maintenance (I/M) programs 276 . . . . . . . . . Engine
Before starting the engine 228 . . . . . . . . . . .
Checking the coolant level 285 . . . . . . . . . .
Emission control device 216 . . . . . . . . . . . . .
Engine compartment 278 . . . . . . . . . . . . . . .
Exhaust gas caution 217 . . . . . . . . . . . . . . . .
Hood release 29 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 217 . . . . . . . . . . . . . . . . . . . .
Oil level 284 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil pressure gauge 123 . . . . . . . . . . . . . . . . .
Overheating 248 . . . . . . . . . . . . . . . . . . . . . . .
Starting procedure 228 . . . . . . . . . . . . . . . . .
Threeway catalytic converter 216 . . . . . . .
Engine coolant
Temperature gauge 122 . . . . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 122 . . . . .
Engine immobiliser system 10 . . . . . . . . . . . . .
Engine oil
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 123 . . . . . . . . . . . . .
Exhaust gas caution 217 . . . . . . . . . . . . . . . . . .
F
Facts about engine oil consumption 217 . . . .
Flasher, Headlight 110,112 . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 256 . . . . . . . . . . . . . .
Changing tire 254 . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 249 . . . . . . . . . . . . . . . .
Jack point 252 . . . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 249 . . . . . . . . . . . . . . . .
Jacking up 253 . . . . . . . . . . . . . . . . . . . . . . . .

02_SEQUOIA_U (L/O 0108)
3242002 MY SEQUOIA_U (OM34418U)
Loosening wheel nuts252
. . . . . . . . . . . . . . .
Lowering vehicle 255
. . . . . . . . . . . . . . . . . . .
Reinstalling w heel ornament 255
. . . . . . . . .
Removing wheel ornament 251
. . . . . . . . . .
Wheel block 251
. . . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 254
. . . . . . . . . . . . . . . . . . . . . . . .
Floor mat 208
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level
Brake 287
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 287
. . . . . . . . . . . . . . . . . . . . .
Washer fluid 299
. . . . . . . . . . . . . . . . . . . . . . .
Fog light switch, Front 114
. . . . . . . . . . . . . . . .
Foreign countries, Operation in 215 . . . . . . . .
Fourwheel drive
Operating the fourwheel drive system 137
. . . . . . . . . . . . . . . . . . . . .
Front air conditioning system
Instrument panel 172
. . . . . . . . . . . . . . . . . . .
Front fog light switch 114
. . . . . . . . . . . . . . . . .
Front passenger ’s seat belt reminder light 125
. . . . . . . . . . . . . . . . . . . . . .
Front seats 36,37,38
. . . . . . . . . . . . . . . . . . . . .
Fuel
Filler door o pener 31
. . . . . . . . . . . . . . . . . . .
Fuel economy 240
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 215
. . . . . . . . . .
Gauge 122
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 215 . . . . . . .
Tank cap 31
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 213
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 215
. . . . . . . . . . . .
Fuse
Fuse box 298
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 279
. . . . . . . . . . . . . . . . . . . . . . . G
Garage door opener 186
. . . . . . . . . . . . . . . . . .
Garage door opener box 197
. . . . . . . . . . . . . .
Gauge
Engine coolant temperature 122
. . . . . . . . .
Engine oil pressure 123
. . . . . . . . . . . . . . . . .
Fuel 122
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 197
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice 133
. . . . . . . . . . . . . . . . .
Grocery bag hooks 207
. . . . . . . . . . . . . . . . . . .
H
Hazard switch 113
. . . . . . . . . . . . . . . . . . . . . . .
Head restraints 52
. . . . . . . . . . . . . . . . . . . . . . .
Headlight switch 110,112
. . . . . . . . . . . . . . . . .
High speed operation
During breakin 213
. . . . . . . . . . . . . . . . . . . .
Hood release, Engine 29
. . . . . . . . . . . . . . . . . .
How to start the engine 228
. . . . . . . . . . . . . . .
I
I/M test 276
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification
Vehicle 223
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 132
. . . . . . . . . . . . . . . . . . . . . . .
Ignition switch light 117
. . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . . . .
Instrument panel
Brightness control 114
. . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtray 195
. . . . . . . . .
Clock 195
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 123
. . . . . . . . . . . Fuel gauge
122
. . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . .
Odometer 124
. . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 124
. . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 124
. . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 114
. . . . . . . . . .
Instrument panel overview 2,4
. . . . . . . . . . . .
J
Jack
Location 250 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 245 . . . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 125
. . . . . . . . . . . . . . . . .
Keys 8,261
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Backup light 303 . . . . . . . . . . . . . . . . . . . . . .
Front fog lights 302 . . . . . . . . . . . . . . . . . . . . .
Front side marker lights 302 . . . . . . . . . . . . .
Front turn signal lights 302 . . . . . . . . . . . . . .
Headlights 301 . . . . . . . . . . . . . . . . . . . . . . . .
High mounted stoplight 305 . . . . . . . . . . . . .
Licence plate lights 305 . . . . . . . . . . . . . . . . .
Parking lights 302 . . . . . . . . . . . . . . . . . . . . . .
Rear turn signal light 303 . . . . . . . . . . . . . . .
Stop/tail/rear side marker light 303 . . . . . . .
Tail lights 304 . . . . . . . . . . . . . . . . . . . . . . . . . .