2002 TOYOTA RAV4 fuel pump

’02 Rav4_U (L/O 0108)
1532002 MY RAV4_U (OM42503U)
INFORMATION BEFORE DRIVING YOUR
TOYOTA
Offroad vehicle precautions154
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin period 155
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . .
Fuel 155
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 157
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 157
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Threeway catalytic converter 158
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine exhaust cautions 159
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Facts about engine oil consumption 159
. . . . . . . . . . . . . . . . . . . . . . . . . .
Iridiumtipped spark plugs 160
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake system 161
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . .
Brake pad wear limit indicators 164
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 164
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Limitedslip differential 165
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Your Toyota’s identification 165
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 167
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Suspension and chassis 167
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Types of tires 167
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
SECTION 2

’02 Rav4_U (L/O 0108)
1552002 MY RAV4_U (OM42503U)
Always slow down in gusty cross-
winds. Because of its profile and
higher center of gravity, your ve-
hicle is more sensitive to side
winds than an ordinary passenger
car. Slowing down will allow you to
have better control.
When driving offroad or in rugged
terrain, do not drive at excessive
speeds, jump, make sharp turns,
strike objects, etc. This may cause
loss of control or vehicle rollover
causing death or serious injury. You
are also risking expensive damage
to your vehicle’s suspension and
chassis.
Do not drive horizontally across
steep slopes. Driving straight up or
straight down is preferred. Your ve-
hicle (or any similar offroad ve-
hicle) can tip over sideways much
more easily than forward or back-
ward.
Drive gently and avoid high speeds.
Your vehicle does not need an elaborate
breakin. But following a few simple tips
for the first 1600 km (1000 miles) can add
to the future economy and long life of
your vehicle:
Do not drive over 88 km/h (55 mph).
Run the engine at moderate speed be-
tween 2000 and 4000 rpm.
Avoid fullthrottle starts.
Try to avoid hard stops during the first
300 km (200 miles).
Do not drive slowly with the manual
transmission in a high gear.
Do not drive for a long time at any
single speed, either fast or slow.
Do not tow a trailer during the first 800
km (500 miles).FUEL TYPE
Your new vehicle must use only un-
leaded gasoline.
To help prevent gas station mixups, your
Toyota has a smaller fuel tank opening.
The special nozzle on pumps with un-
leaded fuel will fit it, but the larger stan-
dard nozzle on pumps with leaded gas will
not.
At a minimum, the gasoline you use
should meet the specifications of ASTM
D4814 in the U.S.A. and CGSB 3.5M93
in Canada.
NOTICE
Do not use leaded gasoline. Use of
leaded gasoline will cause the three
way catalytic converter to lose its ef-
fectiveness and the emission control
system to function improperly. Also,
this can increase maintenance costs.
Breakin period
Fuel

’02 Rav4_U (L/O 0108)
1572002 MY RAV4_U (OM42503U)
GASOLINE QUALITY
In a very few cases, you may experience
driveability problems caused by the partic-
ular gasoline that you are using. If you
continue to have unacceptable driveability,
try changing gasoline brands. If this does
not rectify your problem, then consult your
Toyota dealer.
NOTICE
Do not use gasohol other than
stated above. It will cause fuel sys-
tem damage or vehicle performance
problems.
 If driveab ility problems occur (poor
hot starting, vaporizing, engine
knock, etc.), discontinue the use.
 Take care not to spill gasohol dur-
ing refueling. Gasohol may cause
paint damage.
FUEL TANK CAPACITY
56 L (14.8 gal., 12.3 Imp. gal.) The fuel pump shut off system stops sup-
plying fuel to the engine to minimize the
risk of fuel leakage when the engine stalls
or an airbag inflates upon collision. To
restart the engine after the fuel pump shut
off system activates, turn the ignition
switch to “ACC” or “LOCK” once and start
it.
CAUTION
Inspect the ground under the vehicle
before restarting the engine. If you
find that liquid has leaked onto the
ground, it is the fuel system has
been damaged and it is in need of
repair. In this case, do not restart the
engine.
If you plan to drive your Toyota in
another country...
First,
comply with the vehicle registration
laws.
Second, confirm the availability of the cor-
rect fuel (unleaded and minimum octane
number).
Fuel pump shut off system Operation in foreign countries

’02 Rav4_U (L/O 0108)
2272002 MY RAV4_U (OM42503U)
API service symbol
ILSAC certification mark
Oil identification marks
Either or both API registered marks are
added to some oil containers to help
you select the oil you should use.
The API Service Symbol is located any-
where on the outside of the container.
The top portion of the label shows the oil
quality by API (American Petroleum Insti-
tute) designations such as SL. The center
portion of the label shows the SAE viscos-
ity grade such as SAE 5W30. “Energy
Conserving” shown in the lower portion,
indicates that the oil has fuelsaving ca-
pabilities.
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is displayed on the front of
the container.Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “FULL” and “LOW” lines on the
reservoir. If the level is low, add ethyl-
eneglycol type coolant for a proper
corrosion protection of aluminum com-
ponents.
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “LOW” line, add
coolant. Bring the level up to the “FULL”
line.
Always use ethyleneglycol type coolant
for a proper corrosion protection of alumi-
num components. See information in the
next column.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, radiator cap and drain
cock and water pump.
If you can find no leak, have your Toyota
dealer test the cap pressure and check
for leaks in the cooling system.
Checking the engine coolant
level

’02 Rav4_U (L/O 0108)
2682002 MY RAV4_U (OM42503U)
Front cup holder143
. . . . . . . . . . . . . . . . . . . . .
Front fog light switch 82
. . . . . . . . . . . . . . . . . .
Front passenger ’s seat belt reminder light 90
. . . . . . . . . . . . . . . . . . . . . . .
Front seat
Seatback flattening 38
. . . . . . . . . . . . . . . . . .
Front seats 28,29
. . . . . . . . . . . . . . . . . . . . . . . .
Fuel
Filler door o pener 24
. . . . . . . . . . . . . . . . . . .
Fuel economy 181
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 157
. . . . . . . . . .
Gauge 88
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 157 . . . . . . .
Tank cap 24
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 155
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 157
. . . . . . . . . . . .
Fuse
Fuse box 242
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 219
. . . . . . . . . . . . . . . . . . . . . . .
G
Garage door opener box 138
. . . . . . . . . . . . . .
Gauge
Engine coolant temperature 88
. . . . . . . . . .
Fuel 88
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 138
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice 99,103
. . . . . . . . . . . . . .
Grocery bag hooks 145
. . . . . . . . . . . . . . . . . . .
H
Hazard switch 81
. . . . . . . . . . . . . . . . . . . . . . . .
Head restraints 39
. . . . . . . . . . . . . . . . . . . . . . .
Headlight switch 80
. . . . . . . . . . . . . . . . . . . . . .
High speed operation
During breakin 155
. . . . . . . . . . . . . . . . . . . .
Hood release, Engine 22
. . . . . . . . . . . . . . . . . .
How to start the engine 170
. . . . . . . . . . . . . . .
I
I/M test 216
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification
Engine 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 165
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 98
. . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . . . .
Instrument panel
Brightness control 82
. . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136 . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel gauge 88
. . . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . .
Odometer 89
. . . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 89
. . . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 89
. . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 82
. . . . . . . . . . .
Instrument panel overview 2,4
. . . . . . . . . . . .
Interior light 82
. . . . . . . . . . . . . . . . . . . . . . . . . .
J
Jack
Location 190 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 185 . . . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 90
. . . . . . . . . . . . . . . . . .
Keys 8,203
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Backup lights 249 . . . . . . . . . . . . . . . . . . . . .
Front fog lights 246 . . . . . . . . . . . . . . . . . . . . .
Front side marker lights 248 . . . . . . . . . . . . .
Front turn signal lights 248,249 . . . . . . . . . .
Headlights 245 . . . . . . . . . . . . . . . . . . . . . . . .
High mounted stoplight 250 . . . . . . . . . . . . .
License plate lights 251 . . . . . . . . . . . . . . . . .
Parking lights 248 . . . . . . . . . . . . . . . . . . . . . .
Rear side marker lights 249 . . . . . . . . . . . . .
Rear turn signal lights 249 . . . . . . . . . . . . . .
Stop/tail lights 249 . . . . . . . . . . . . . . . . . . . . .
Light bulbs, Replacing 244 . . . . . . . . . . . . . . . .
Light reminder buzzer 90 . . . . . . . . . . . . . . . . .
Limited slip differential 165 . . . . . . . . . . . . . . . .
Lock
Back door 21 . . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 12 . . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 98 . . . . . . . . . . . . . . . . . . . .
Low engine oil pressure warning light 90 . . . .
Low fuel level warning light 90 . . . . . . . . . . . . .