2002 TOYOTA RAV4 charging

’02 Rav4_U (L/O 0108)
922002 MY RAV4_U (OM42503U)
(b) Driver’s Seat Belt Reminder Lightand Buzzer
This light and buzzer remind you to
buckle up the driver’s seat belt.
Once the ignition key is turned to “ON” or
“START”, the reminder light flashes and
buzzer sounds if the driver ’s seat belt is
not fastened. Unless the driver fastens the
belt, the light keeps flashing and the
buzzer stops after about 4 to 8 seconds.
(c) Front Passenger ’s Seat Belt Re- minder Light
This light reminds you to buckle up the
front passenger ’s seat belt.
Once the ignition key is turned to “ON” or
“START”, the reminder light flashes if a
passenger sits in the front passenger seat
and does not fasten the seat belt. Howev-
er, if a front passenger uses an additional
seat cushion, the light may not flash even
when the seat belt is not buckled up.
If luggage load is placed on the front
passenger seat, depending on its weight
and how it is placed on the seat, builtin
sensors in the seat cushion may detect
the pressure, causing the reminder light to
keep flashing. (d) Discharge Warning Light
This light warns that the battery is being
discharged.
If it comes on while you are driving, there
is a problem somewhere in the charging
system.
The engine ignition will continue to oper-
ate, however, until the battery is dis-
charged. Turn off the air conditioning,
blower, radio,etc., and drive directly to the
nearest Toyota dealer or repair shop.
NOTICE
Do not continue driving if the engine
drive belt is broken or loose.
(e) Low Engine Oil Pressure Warning
Light
This light warns that the engine oil pres-
sure is too low.
If it flickers or stays on while you are
driving, pull off the road to a safe place
and stop the engine immediately. Call a
Toyota dealer or qualified repair shop for
assistance. The light may occasionally flicker when
the engine is idling or it may come on
briefly after a hard stop. There is no
cause for concern if it then goes out when
the engine is accelerated slightly.
The light may come on when the oil level
is extremely low. It is not designed to
indicate low oil level, and the oil level
must be checked using the level dipstick.
NOTICE
Do not drive the vehicle with the
warning light on—even for one block.
It may ruin the engine.
(f) Malfunction Indicator Lamp
This lamp comes on when the ignition
key is turned to the “ON” position and
goes off after the engine starts. This
means that the warning light system is
operating properly.
If the lamp remains on, or the lamp
comes on while driving, first check the
followings.
Empty fuel tank
If the fuel tank is empty, refuel immedi-
ately.

’02 Rav4_U (L/O 0108)
1872002 MY RAV4_U (OM42503U)
Connecting point
Do not connect it to or near any part
that moves when the engine is
cranked.
CAUTION
When making the connections, to
avoid serious injury, do not lean over
the battery or accidentally let the
jumper cables or clamps touch any-
thing except the correct battery termi-
nals or the ground.
5. Start your engine in the normal way.After starting, run it at about 2000 rpm
for several minutes with the accelerator
pedal lightly depressed.
6. Carefully disconnect the cables in the exact reverse order: the negative cable
and then the positive cable.
7. Carefully dispose of the battery cover cloths—they may now contain sulfuric
acid.
8. If removed, replace all the battery vent plugs.
If the cause of your battery discharging is
not apparent (for example, lights left on),
you should have it checked.
AFTER JUMP STARTING
Insert the 6 removed clips and press
down their heads to fix the battery cover.
NOTICE
After installed the battery cover, make
sure the battery cover is securely in
its original position. If it is not se-
cured, it may be damaged to your
vehicle.

’02 Rav4_U (L/O 0108)
2392002 MY RAV4_U (OM42503U)
DOITYOURSELF MAINTENANCE
Electrical components
Checking battery condition240
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 241
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 242
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 243
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . .
Replacing light bulbs 244
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
SECTION 7 3

’02 Rav4_U (L/O 0108)
2412002 MY RAV4_U (OM42503U)
c. Tighten the holddown clamp onlyenough to keep the battery firmly in
place. Overtightening may damage the
battery case.
After checking the battery, reinstall the
battery cover.
NOTICE
 Be sure the engine and all accesso-
ries are off before performing main-
tenance.
 When checking the battery, remove
the ground cable from the negative
terminal (“” mark) first and rein-
stall it last.
 Be careful not to cause a short cir-
cuit with tools.
 Take care no solution gets into the
battery when washing it.
Ty p e A
Green Dark Clear or
light yellow
Ty p e B Blue White Red
CHECKING BY INDICATOR
Check the battery condition by the indi-
cator color.
Indicator color
ConditionTy p e ATy p e B
GreenBlueGood
DarkWhite
Charging necessary.
Have battery
checked by your
Toyota dealer.
Clear orlight
yellow
RedHave battery
checked by your
Toyota dealer.
During recharging, the battery is pro-
ducing hydrogen gas.
Therefore, before recharging:
1. If recharging with the battery installed on the vehicle, be sure to disconnect
the ground cable.
2. Be sure the power switch on the re- charger is off when connecting the
charger cables to the battery and when
disconnecting them.
CAUTION
Always charge the battery in an un-
confined area. Do not charge the
battery in a garage or closed room
where there is not sufficient ventila-
tion.
Only do a slow charge (5 A or
less). Charging at a quicker rate is
dangerous. The battery may ex-
plode, causing personal injuries.
NOTICE
Never recharge the battery while the
engine is running. Also, be sure all
accessories are turned off.
—Checking battery c ondition Battery recharging pr ecautions

’02 Rav4_U (L/O 0108)
2562002 MY RAV4_U (OM42503U)
BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights
turned off
Charging rates: 5 A max.
CLUTCH
Pedal free play, mm (in.): 5—15 (0.2—0.6)
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.): Twowheel drive models2.5 (2.6, 2.2)
Fourwheel drive models
3.4 (3.6, 3.0)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90 AUTOMATIC TRANSAXLE
Fluid capacity (drain and ref
ill), L (qt.,
Imp. qt.):
Twowheel drive modelsUp to 3.3 (3.5, 2.9)
Fourwheel drive models Up to 3.9 (4.1, 3.4)
Fluid type: Automatic transmission fluid Type TIV
Change automatic transmission fluid only
as necessary.
Generally, it is necessary to change
automatic transmission fluid only if your
vehicle is driven under one of the Special
Operating Conditions listed in your
“Scheduled Maintenance Guide” or
“Owner ’s Manual Supplement”. When
changing the automatic transmission fluid,
use only Toyota Genuine ATF Type TIV
(ATF JWS3309 or NWS6500) to aid in
assuring optimum transaxle performance.
Notice: Using automatic transmission
fluid other than Toyota Genuine ATF
Type TIV may cause deterioration in
shift quality, locking up of your trans-
mission accompanied by vibration, and
ultimately damage the automatic trans-
mission of your vehicle. TRANSFER
(fourwheel drive models)
Oil capacity, L (qt., Imp. qt.):
0.9 (1.0, 0.8)
Oil type: Hypoid gear oil API GL5
Recommended oil viscosity: Above 18 C (0 F)
SAE 90 or 85W90
Below 18 C (0 F)
SAE 80W or 80W90
REAR DIFFERENTIAL
(fourwheel drive models)
Oil capacity, L (qt., Imp. qt.): 0.9 (1.0, 0.8)
Oil type: Hypoid gear oil API GL5
Recommended oil viscosity: Above 18 C (0 F)
SAE 90
Below 18 C (0 F)
SAE 80W or 80W90

’02 Rav4_U (L/O 0108)
2582002 MY RAV4_U (OM42503U)
Engine compartment
Instrument panel
Fuses (type A)1. RADIO 15 A: Car audio system
2. DOME 10 A: Clock, personal light, in-
terior lights, air conditioning system,
wireless remote control system, head-
light high beam indicator light, gauges
and meters
3. CUT 30 A: “RADIO” and “DOME” fuses
4. A/C 5 A: Air conditioning system
5. MAIN 30 A: “HLP RH” and “HLP LH”
fuses
6. HAZ 10 A: Emergency flashers 7. ALTS 5 A:
Charging system
8. IGN 15 A: Starting system, multiport
fuel injection system/sequential multi-
port fuel injection system
9. EFI3 10 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, emission control system
10. EFI2 5 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system
11. A/F 20 A: A/F sensor
12. ABS2 30 A: Antilock brake system
13. EFI1 20 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, “EFI2” and “EFI3” fuses
14. HLP RH 10 A: Righthand headlight
15. HLP LH 10 A: Lefthand headlight
16. ST 5 A: Starting system
17. STOP 10 A: Stop lights, highmounted
stoplight, antilock brake system, shift
lock control system, multiport fuel in-
jection system/sequential multiport fuel
injection system, cruise control system
18. CIG 15 A: Cigarette lighter
19. POWER OUTLET 15 A: Power outlets
20. SHTR 10 A: No circuit
Fuses

’02 Rav4_U (L/O 0108)
2592002 MY RAV4_U (OM42503U)
21. PANEL 7.5 A: Instrument panel light,
gauges and meters, front fog lights,
instrument panel light control, outside
rear view mirror defoggers, air condi-
tioning system
22. FR FOG 15 A: Front fog lights
23. HORN 10 A: Horn
24. TAIL 7.5 A: Tail lights, license plate
lights, instrument cluster lights
25. TAIL&PANEL 15 A: “PANEL” and
“TAIL” fuses
26. ACC 7.5 A: Car audio system, shift
lock control system, clock, power rear
view mirrors
27. DEF 20 A: Rear window defogger
28. GAUGE 10 A: Backup lights, electric
cooling fans, air conditioning system,
automatic transmission indicator lights,
charging system
29. OBD 7.5 A: Onboard diagnosis sys-
tem
30. IG2 10 A: Discharge warning light,
multiport fuel injection system/sequen-
tial multiport fuel injection system,
starting system, SRS airbag system
31. DOOR 20 A: Power door lock system 32. MIR HTR 10 A:
Outside rear view mir-
ror defoggers
33. RR WIP 15 A: Rear window wiper and
washer
34. WIP 25 A: Windshield wipers and
washer
35. ECU IG 10 A: Emergency flashers,
gauges and meters, antilock brake
system, SRS airbag system, shift lock
control system, cruise control system
Fuses (type B)
36. RDI 30 A: Electric cooling fan
37. CDS 30 A: Electric cooling fan
38. AM2 30 A: Discharge warning light,
multiport fuel injection system/sequen-
tial multiport fuel injection system,
starting system, SRS airbag system
and “IG2” fuse
39. ABS 1 40 A: Antilock brake system
40. HTR 40 A: Air conditioning system
41. PWR 30 A: Electric moon roof, power
windows
42. AM1 40 A: Power outlets, rear window
defogger, “ACC”, “CIG”, “ECU IG”,
“GAUGE”, “RR WIP”, “SHTR” and
“WIP” fuses

’02 Rav4_U (L/O 0108)
2662002 MY RAV4_U (OM42503U)
A
Adding washer fluid243
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 29
. . . . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 40
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air cleaner 230
. . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 128
. . . . . . . . . . . . . . .
Airbags 50
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 237
. . . . . . . . . .
Antiglare inside rear view mirror 76 . . . . . . .
Antilock brake system warning light 90 . . . .
Antitheft steering column lock 98
. . . . . . . . .
Appearance care
Cleaning the interior 209
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 206
. . . . . . . . . . . . . . . . . . .
Washing and waxing 207
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 99
. . . . . . . . .
Shift lock override button 202
. . . . . . . . . . . .
Shift pattern 99
. . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 99
. . . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 90
. . . . . . . . . . . .
Auxiliary boxes 141
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 22
. . . . . . . . . . .
B
Back door 21
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 21
. . . . . . . . . . . . . . . . . . . . . . . . Battery
Checking battery condition 240
. . . . . . . . . .
Gas caution 240
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 240
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 241
. . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Before starting the engine 170
. . . . . . . . . . . . .
Brake pad wear limit indicators 164 . . . . . . . .
Brake system 161
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 90
. . . . . . . . . . . . .
Brakes
Fluid level 229
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 164
. . . . . . . . . . . .
Parking 104
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 155
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 82
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 110
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 159
. . . . . . . . . . . . .
Cassette player 110
. . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 242
. . . . . . . . .
Checking brake fluid 229
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 226
. . . . . . . . . .
Checking the radiator and condenser 228
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 58
. . . . . . . . . . . . . . .
Installation 60
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with ISOFIX rigid anchor 72
. . . . . . . . . . . . . . . . . . . . . .
Precautions 57
. . . . . . . . . . . . . . . . . . . . . . . . Types of child restraint system 59
. . . . . . . .
Using a top strap 69
. . . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136
. . . . . . . . .
Cleaning the interior 209
. . . . . . . . . . . . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 173
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc auto changer controller 110
. . . . . . . . . . . . . . . . . .
Compact disc player 110
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 228
. . . . . . . . . . . .
Controls, Instrument panel 2,4
. . . . . . . . . . . .
Cooling system
Coolant level 227
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 188
. . . . . . . . . . . . . . . . .
Radiator and reservoir 227
. . . . . . . . . . . . . .
Radiator cap 188
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Corrosion prevention 206
. . . . . . . . . . . . . . . . .
Cruise control 105
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Out side rear view mirror 85 . . . . . . . . . . . . .
Rear window 85
. . . . . . . . . . . . . . . . . . . . . . . .
Differential, Limited slip 165
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 80
. . . . . . . . . . . . . .
Dinghy towing 174,175
. . . . . . . . . . . . . . . . . . .
Directional signals 80
. . . . . . . . . . . . . . . . . . . .