2002 TOYOTA MR2 SPYDER suspension

02 MY MR2 SMT(U) L/O 0108
35
01 06 12
2002 MR2 (OM17493U)
When the seat belt pretensioners are acti-
vated, an operating noise may be heard
and a small amount of smokelike gas
may be released. This gas is harmless
and does not indicate that a fire is occur-
ring.
Once the seat belt pretensioners have
been activated, the seat belt retractors
remain locked.
CAUTION
Do not modify, remove, strike or open
the seat belt pretensioner assemblies,
airbag sensor or surrounding area or
wiring. Doing any of these may cause
sudden operation of the seat belt pre-
tensioners or disable the system,
which could result in death or serious
injury.
Failure to follow these instructions
can result in death or serious inju-
ries.
NOTICE
Do not perform any of the following
changes without consulting your
Toyota dealer. Such changes can
interfere with proper operation of the
seat belt pretensioners in some
cases.
Installation of electronic devices
such as a mobile twoway radio,
cassette tape player or compact
disc player
 Repairs on or near the seat belt
retractor assemblies
 Modification of the suspension sys-
tem
 Modification of the front end struc-
ture
 Attachment of a grille guard (bull
bar, kangaroo bar, etc.), snowplow,
winches or any other equipment to
the front end
 Repair made on or near the front
fenders, front end structure or con-
sole
SB13102
This seat belt pretensioner system has a
service reminder indicator to inform the
driver of operating problems. If any of the
following conditions occurs, this indicates
a malfunction of the airbags or
pretensioners. Contact your Toyota dealer
as soon as possible to service the
vehicle.
The light does not come on when the
ignition key is turned to the “ON” posi-
tion, or the light remains on.
The light comes on or flashes while
driving.
If either seat belt does not retract or
cannot be pulled out due to a malfunc-
tion or activation of the relevant seat
belt pretensioner.

02 MY MR2 SMT(U) L/O 0108
44
01 06 12
2002 MR2 (OM17493U)
NOTICE
Do not perform any of the following
changes without consulting your
Toyota dealer. Such changes can in-
terfere with proper operation of the
SRS airbag system in some cases.
Installation of electronic devices
such as a mobile twoway radio,
cassette tape player or compact
disc player
 Modification of the suspension sys-
tem
 Modification of the front end struc-
ture
 Attachment of a grille guard (bull
bar, kangaroo bar, etc.), snowplow,
winches or any other equipment to
the front end
 Repairs made on or near the front
fenders, front end structure, con-
sole, steering column, steering
wheel or dashboard near the pas-
senger airbag
SB13102
This SRS airbag system has a service
reminder indicator to inform the driver of
operational problems. If either of the fol-
lowing conditions occurs, this indicates a
malfunction of the airbags. Contact your
Toyota dealer as soon as possible to
service the vehicle.
The light does not come on when the
ignition key is turned to the “ON” posi-
tion, or the light remains on.
The light comes on or flashes while
driving.
SB13067
In the following cases, contact your Toyota
dealer as soon as possible:
The SRS airbags have been inflated.
The front of the vehicle (shaded in the
illustration) was involved in an acci dent
that was not severe enough to cause
the SRS airbags to inflate.
The pad section of the steering wheel
or passenger airbag cover (shaded in
the illustration) is scratched, cracked,
or otherwise damaged.
NOTICE
Do not disconnect the battery cables
before contacting your Toyota dealer.

02 MY MR2 SMT(U) L/O 0108
123
01 06 12
2002 MR2 (OM17493U)
INFORMATION BEFORE DRIVING YOUR
TOYOTA
Breakin period124
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . .
Fuel 124
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 126
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 126
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Threeway catalytic converter 126
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine exhaust cautions 127
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Facts about engine oil consumption 128
. . . . . . . . . . . . . . . . . . . . . . . . . .
Iridiumtipped spark plugs 129
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake system 129
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . .
Brake pad wear limit indicators 132
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 132
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Limitedslip differential 133
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Your Toyota’s identification 133
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 134
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Suspension and chassis 135
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Types of tires 135
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
SECTION 2

02 MY MR2 SMT(U) L/O 0108
135
01 06 12
2002 MR2 (OM17493U)
Suspension and chassis
CAUTION
Do not modify the suspension/chassis
with lift kits, spacers, springs, etc. It
can cause dangerous handling charac-
teristics, resulting in loss of control.
Types of tires
Determine what kind of tires your ve-
hicle is originally equipped with.
Summer tires
Summer tires are highspeed capability
tires best suited to highway driving under
dry conditions.
Since summer tires do not have the same
traction performance as snow tires, sum-
mer tires are inadequate for driving on
snowcovered or icy roads. For driving on
snowcovered or icy roads, we recom-
mend using snow tires. If installing snow
tires, be sure to replace all four tires.
CAUTION
Do not mix summer and other tires
on your vehicle as this can cause
dangerous handling characteristics,
resulting in loss of control.
Do not use tires other than the
manufacture’s designated tires, and
never mix tires or wheels of the
sizes different from the originals.

02 MY MR2 SMT(U) L/O 0108
177
01 06 12
2002 MR2 (OM17493U)
Engine oil level
Check the level by the dipstick with the
engine turned off and the vehicle parked
on a level spot. See page 188 in Section
72 for additional information.
Power steering fluid level
Check the level through the reservoir. The
level should be in the “HOT” or “COLD”
range depending on the fluid temperature.
See page 191 in Section 72 for addition-
al information.
Exhaust system
If you notice any change in the sound of
the exhaust or smell exhaust fumes, have
the cause located and corrected immedi-
ately. (See “Engine exhaust cautions” on
page 127 in Section 2.)Be on the alert for changes in perfor-
mance, sounds, and visual tipoffs that
indicate service is needed. Some impor-
tant clues are as follows:
Engine missing, stumbling, or pinging
Appreciable loss of power
Strange engine noises
A leak under the vehicle (however, wa-
ter dripping from the air conditioning
after use is normal.)
Change in exhaust sound (This may
indicate a dangerous carbon monoxide
leak. Drive with the windows open and
have the exhaust system checked im-
mediately.)
Flatlooking tire; excessive tire squeal
when cornering; uneven tire wear
Vehicle pulls to one side when driving
straight on a level road
Strange noises related to suspension
movement
Loss of brake effectiveness; spongy
feeling brake or clutch pedal; pedal al-
most touches floor; vehicle pulls to one
side when braking
Engine coolant temperature continually
higher than normalIf you notice any of these clues, take your
vehicle to your Toyota dealer as soon as
possible. It probably needs adjustment or
repair.
CAUTION
Do not continue driving with the ve-
hicle unchecked. It could result in se-
rious vehicle damage and possibly
personal injury.
Does your vehicle need
repairing?

02 MY MR2 SMT(U) L/O 0108
231
01 06 12
2002 MR2 (OM17493U)
O
Odometer69
. . . . . . . . . . . . . . . . . . . . . . . . . .
Oil
Consumption 128
. . . . . . . . . . . . . . . . . . . .
Power steering 191
. . . . . . . . . . . . . . . . . . .
Viscosity and grade 188,215
. . . . . . . . . .
Oil power steering 191
. . . . . . . . . . . . . . . . . .
Open door warning light 70
. . . . . . . . . . . . . .
Operation in foreign countries 126 . . . . . . .
Overheating, Engine 150
. . . . . . . . . . . . . . . .
Overheating, Engine coolant 68
. . . . . . . . . .
Overview
Engine compartment 180
. . . . . . . . . . . . . .
Instrument cluster 4
. . . . . . . . . . . . . . . . . .
Instrument panel 2
. . . . . . . . . . . . . . . . . . .
P
Parking brake
Operation 89 . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 89 . . . . . . . . . . . . . . . . . . . .
Parking brake reminder light 70 . . . . . . . . . .
Parts and tools 184 . . . . . . . . . . . . . . . . . . . . .
Passenger airbag manual onoff switch 45 . . . . . . . . . . . . . . . . . . . . .
Passenger ’s seat belt
reminder light 70 . . . . . . . . . . . . . . . . . . . . .
Polishing 167 . . . . . . . . . . . . . . . . . . . . . . . . . .
Power door lock switch 12 . . . . . . . . . . . . . .
Power rear view mirror control 58 . . . . . . . .
Power steering fluied level 191 . . . . . . . . . .
Power window switches 13 . . . . . . . . . . . . . .
Power window lock switch 13 . . . . . . . . . . . . Pretensioners
(seat belt pretensioners) 34 . . . . . . . . . . .
Protecting your Toyota from corrosion 166 . . . . . . . . . . . . . . . . . . .
R
Radiator
Coolant, Engine 189 . . . . . . . . . . . . . . . . . .
Rear view mirror,
Antiglare inside 59 . . . . . . . . . . . . . . . . . .
Rear view mirror, Power controlled 58 . . . . . . . . . . . . . . . . . .
Rear view mirrors, Folding 58 . . . . . . . . . . .
Rear view mirrors, Outside 58 . . . . . . . . . . .
Rear window defogger switch 65 . . . . . . . . .
Reporting safety defects for U.S. owners 224 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 28 . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 32 . . . . . . . . . . . . . . . . . . .
Seat belts Cleaning 170 . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 30 . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 30 . . . . . . . . . . . . . .
Seat belt pretensioners 34 . . . . . . . . . . . .
Seats 28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Sequential manual transmission
Driving with a sequential manual transmission 77 . . . . . . . . . . .
Shift pattern 77 . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 77 . . . . . . . . . . . . . . . . . . . .
Service and maintenance 174 . . . . . . . . . . .
Service reminder indicators 70 . . . . . . . . . .
Side door locks 11 . . . . . . . . . . . . . . . . . . . . .
Side vents 113 . . . . . . . . . . . . . . . . . . . . . . . . .
Soft top 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare fuse 202 . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 153 . . . . . . . . . . . . . . . . . . . . . . . . .
Spark plugs
lrigiumtipped spark plugs 129 . . . . . . . .
Specifications 213 . . . . . . . . . . . . . . . . . . . . .
SRS driver and
passenger airbags 36 . . . . . . . . . . . . . . . .
SRS warning light 70 . . . . . . . . . . . . . . . . . . .
Starting
Cold weather 138 . . . . . . . . . . . . . . . . . . . .
Engine 138 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 147 . . . . . . . . . . . . . . . . . . . .
Steering Column lock 76 . . . . . . . . . . . . . . . . . . . . . .
Tilt steering wheel 57 . . . . . . . . . . . . . . . . .
Suspension and chassis 135 . . . . . . . . . . . .
Switch Emergency flasher 63
. . . . . . . . . . . . . . . .
Headlight, dimmer and turn signal 62
. . . . . . . . . . . . . . . . . . . . . .
Ignition 76
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear window defogger 65
. . . . . . . . . . . . .
Power door lock 12
. . . . . . . . . . . . . . . . . . .