2002 TOYOTA MR2 SPYDER warning

02 MY MR2 SMT(U) L/O 0108
147
01 06 12
2002 MR2 (OM17493U)
(c) Jump starting
To avoid serious personal injury and
damage to your vehicle which might re-
sult from battery explosion, acid burns,
electrical burns, or damaged electronic
components, these instructions must be
followed precisely.
If you are unsure about how to follow this
procedure, we strongly recommend that
you seek the help of a competent me-
chanic or towing service.
CAUTION
Batteries contain sulfuric acid
which is poisonous and corrosive.
Wear protective safety glasses when
jump starting, and avoid spilling
acid on your skin, clothing, or ve-
hicle.
If you should accidentally get acid
on yourself or in your eyes, remove
any contaminated clothing and flush
the affected area with water imme-
diately. Then get immediate medical
attention. If possible, continue to
apply water with a sponge or cloth
while en route to the medical office.
The gas normally produced by a
battery will explode if a flame or
spark is brought near. Use only
standardized jumper cables and do
not smoke or light a match while
jump starting.
Warning: Battery posts, terminals and
related accessories contain lead and
lead compounds, chemicals known to
the State of California to cause can-
cer and reproductive harm. Wash
hands after handling.
NOTICE
The battery used for boosting must
be 12 V. Do not jump start unless you
are sure that the booster battery is
correct.
JUMP STARTING PROCEDURE 1. If the booster battery is installed in another vehicle, make sure the vehicles
are not touching. Turn off all unneces-
sary lights and accessories.
2. If required, remove all the vent plugs from the booster and discharged batter-
ies. Lay a cloth over the open vents
on the batteries. (This helps reduce the
explosion hazard, personal injuries and
burns.)
3. If the engine in the vehicle with the booster battery is not running, start it
and let it run for a few minutes. During
jump starting, run the engine at about
2000 rpm with the accelerator pedal
lightly depressed.

02 MY MR2 SMT(U) L/O 0108
176
01 06 12
2002 MR2 (OM17493U)
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working. Check headlight aim.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Be alert for changes in steering condition,
such as hard steering or strange noise.
Seats
Check that all seat controls such as seat
adjusters, seatback recliner, etc. operate
smoothly and that all latches lock securely
in any position. Check that the latches
lock securely.
Seat belts
Check that the seat belt system such as
buckles and retractors operate properly
and smoothly. Make sure the belt webbing
is not cut, frayed, worn or damaged.Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Clutch pedal
Check the pedal for smooth operation.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the lever has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 203 in Section 73 for
additional information.
Engine coolant level
Make sure the coolant level is between
the “FULL” and “LOW” lines on the see
through reservoir when the engine is cold.
See page 189 in Section 72 for addition-
al information.
Radiator, condenser and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt, or insects. See page 190 in
Section 72 for additional information.
Battery electrolyte level
Make sure the electrolyte level of all bat-
tery cells is between upper and lower lev-
el lines on the case. Add only distilled
water when replenishing. See pgae 200 in
Section 73 for additional information.
Brake fluid level
Make sure the brake fluid level is correct.
See page 191 in Section 72 for addition-
al information.

02 MY MR2 SMT(U) L/O 0108
183
01 06 12
2002 MR2 (OM17493U)
If you perform maintenance by yourself,
be sure to follow the correct procedure
given in this section.
You should be aware that improper or in-
complete servicing may result in operating
problems.
Performing doityourself maintenance
during the warranty period may affect your
warranty coverage. Read the separate
Toyota Warranty statement for details and
suggestions.
This section gives instructions only for
those items that are relatively easy for an
owner to perform. As explained in Section
6, there are still a number of items that
must be done by a qualified technician
with special tools.
For information on tools and parts for do
ityourself maintenance, see “Parts and
tools” on page 184.
Utmost care should be taken when work-
ing on your vehicle to prevent accidental
injury. Here are a few precautions that
you should be especially careful to ob-
serve:CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment and trunk room—the
engine, radiator, exhaust manifold,
power steering fluid reservoir and
spark plug boots, etc.—will be hot.
So be careful not to touch them.
Oil, fluids and spark plugs may also
be hot.
If the engine is hot, do not remove
the coolant reservoir cap or air re-
lease valve or loosen the drain
plugs to prevent burning yourself.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Be sure that the ignition is off if
you work near the electric cooling
fans or radiator grille. With the
ignition on, the electric cooling fans
will automatically start to run if the
engine coolant temperature is high
and/or the air conditioning is on.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Warning: Battery posts, terminals
and related accessories contain lead
and lead compounds, chemicals
known to the State of California to
cause cancer and reproductive
harm. Wash hands after handling
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
Doityourself service
precautions

02 MY MR2 SMT(U) L/O 0108
197
01 06 12
2002 MR2 (OM17493U)
Replacement with used wheels is not rec-
ommended as they may have been sub-
jected to rough treatment or high mileage
and could fail without warning. Also, bent
wheels which have been straightened may
have structural damage and therefore
should not be used. Never use an inner
tube in a leaking wheel which is designed
for a tubeless tire.
Aluminum wheel precautions
When installing aluminum wheels,
check that the wheel nuts are tight
after driving your vehicle the first
1600km (1000 miles).
If you have repaired or changed your
tires, check that the wheel nuts are
still tight after driving 1600 km (1000
miles).
When using tire chains, be careful not
to damage the aluminum wheels.
Use only the Toyota wheel nuts and
wrench designed for your aluminum
wheels.
When balancing your wheels, use only
Toyota balance weights or equivalent
and a plastic or rubber hammer.
As with any wheel, periodically check
your aluminum wheels for damage. If
damaged, replace immediately.

02 MY MR2 SMT(U) L/O 0108
200
01 06 12
2002 MR2 (OM17493U)
CAUTION
BATTERY PRECAUTIONS
The battery produces flammable and
explosive hydrogen gas.
Do not cause a spark from the bat-
tery with tools.
Do not smoke or light a match near
the battery.
The electrolyte contains poisonous
and corrosive sulfuric acid.
Avoid contact with eyes, skin or
clothes.
Never ingest electrolyte.
Wear protective safety glasses when
working near the battery.
Keep children away from the bat-
tery.
EMERGENCY MEASURES
If electrolyte gets in your eyes,
flush your eyes with clean water
immediately and get immediate
medical attention. If possible, con-
tinue to apply water with a sponge
or cloth while en route to the medi-
cal office.
If electrolyte gets on your skin,
thoroughly wash the contact area. If
you feel pain or burning, get medi-
cal attention immediately.
If electrolyte gets on your clothes,
there is a possibility of its soaking
through to your skin, so immediate-
ly take off the exposed clothing and
follow the procedure above, if nec-
essary.
If you accidentally swallow electro-
lyte, drink a large quantity of water
or milk. Follow with milk of magne-
sia, beaten raw egg or vegetable
oil. Then go immediately for emer-
gency help.
Warning: Battery posts, terminals and
related accessories contain lead and
lead compounds, chemicals known to
the State of California to cause can-
cer and reproductive harm. Wash
hands after handling.
—Checking battery exterior
SB73076
TerminalsGround
cable Holddown clamp
Check the battery for corroded or loose
terminal connections, cracks, or loose
holddown clamp.
a. If the battery is corroded, wash it off with a solution of warm water and bak-
ing soda. Coat the outside of the termi-
nals with grease to prevent further cor-
rosion.
b. If the terminal connections are loose, tighten their clamp nuts—but do not
overtighten.
c. Tighten the holddown clamp only enough to keep the battery firmly in
place. Overtightening may damage the
battery case.
Checking battery c ondition—
—Precautions

02 MY MR2 SMT(U) L/O 0108
225
01 06 12
2002 MR2 (OM17493U)
Uniform tire quality grading
This information has been prepared in ac-
cordance with regulations issued by the
National Highway Traffic Safety Adminis-
tration of the U.S. Department of Trans-
portation. It provides the purchasers and/
or prospective purchasers of Toyota
vehicles with information on uniform tire
quality grading.
Your Toyota dealer will help answer any
questions you may have as you read this
information.
DOT quality grades—All passenger car
tires must conform to Federal Safety
Requirements in addition to these
grades. Quality grades can be found
where applicable on the tire sidewall
between tread shoulder and maximum
section width. For example: Treadwear
200 Traction AA Temperature ATreadwear—
The treadwear grade is a
comparative rating based on the wear rate
of the tire when tested under controlled
conditions on a specified government test
course. For example, a tire graded 150
would wear one and a half (1 1/2) times
as well on the government course as a
tire graded 100. The relative performance
of tires depends upon the actual condi-
tions of their use, however, and may de-
part significantly from the norm due to
variations in driving habits, service prac-
tices and differences in road characteris-
tics and climate.
Traction AA, A, B, C— The traction
grades, from highest to lowest, are AA, A,
B, and C, and they represent the tire’s
ability to stop on wet pavement as mea-
sured under controlled conditions on spe-
cified government test surfaces of asphalt
and concrete. A tire marked C may have
poor traction performance.
Warning: The traction grade assigned to
this tire is based on braking (straighta-
head) traction tests and does not include
cornering (turning) traction. Temperature A, B, C—
The temperature
grades are A (the highest), B, and C,
representing the tire’s resistance to the
generation of heat and its ability to dissi-
pate heat when tested under controlled
conditions on a specified indoor laboratory
test wheel. Sustained high temperature
can cause the material of the tire to de-
generate and reduce tire life, and exces-
sive temperature can lead to sudden tire
failure. The grade C corresponds to a lev-
el of performance which all passenger car
tires must meet under the Federal Motor
Vehicle Safety Standard No.109. Grades B
and A represent higher levels of perfor-
mance on the laboratory test wheel than
the minimum required by law.
Warning: The temperature grades for this
tire are established for a tire that is prop-
erly inflated and not overloaded. Exces-
sive speed, underinflation, or excessive
loading, either separately or in combina-
tion, can cause heat buildup and possible
tire failure.

02 MY MR2 SMT(U) L/O 0108
228
01 06 12
2002 MR2 (OM17493U)
A
Adding washer fluid203
. . . . . . . . . . . . . . . .
Adjustment
Seats 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 107
. . . . . . . . . . . . .
Airbags 36
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 197 . . . . . . . .
Antiglare inside rear view mirror 59 . . . . .
Antilock brake system warning light 70
. . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 76 . . . . . . .
Appearance care Cleaning the interior 170
. . . . . . . . . . . . . .
Protecting your Toyota from
corrosion 166
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 167
. . . . . . . . . . . . . .
Auxiliary box 118
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Trunk lid 14
. . . . . . . . . . . . .
B
Battery
Checking battery condition 200 . . . . . . . .
Gas caution 200 . . . . . . . . . . . . . . . . . . . . .
Handling safety 200 . . . . . . . . . . . . . . . . . .
Recharging precautions 201 . . . . . . . . . . .
Winter driving tips 140 . . . . . . . . . . . . . . . .
Before starting the engine 138 . . . . . . . . . . .
Brake pad wear limit indicators 132 . . . . . .
Brake system 129 . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 70 . . . . . . . . . . Brakes
Fluid level 191 . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 132 . . . . . . . . . .
Parking 89 . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 124 . . . . . . . . . . . . . . . . . . . . . .
Brightness control 64 . . . . . . . . . . . . . . . . . . .
C
Car audio system 93
. . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 127
. . . . . . . . . . .
Cassette player 94
. . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 202 . . . . . . . .
Checking brake fluid 191
. . . . . . . . . . . . . . . .
Checking the engine oil level 188 . . . . . . . .
Checking power steering fluid 191 . . . . . . .
Child restraint Child restraint system 46
. . . . . . . . . . . . .
Installation with seat belt 48
. . . . . . . . . . .
Precautions 46
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 47 . . . . . .
Cigarette lighter and ashtray 116
. . . . . . . . .
Cleaning the interior 170
. . . . . . . . . . . . . . . .
Clock 116
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather operation 140
. . . . . . . . . . . . .
Compact disc player 94
. . . . . . . . . . . . . . . . .
Cooling system
Coolant level 189
. . . . . . . . . . . . . . . . . . . .
Engine overheating 150
. . . . . . . . . . . . . . .
Radiator and condenser 190
. . . . . . . . . . .
Radiator and reservoir 189
. . . . . . . . . . . .
Radiator cap 150
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . . Corrosion prevention
166
. . . . . . . . . . . . . . .
Cruise control 90
. . . . . . . . . . . . . . . . . . . . . .
Cup holders 121
. . . . . . . . . . . . . . . . . . . . . . .
D
Defogger, Rear window 65
. . . . . . . . . . . . . .
Dimensions and weight 214
. . . . . . . . . . . . .
Dimmer switch, Headlight 62
. . . . . . . . . . . .
Dinghy towing 141
. . . . . . . . . . . . . . . . . . . . .
Directional signals 62
. . . . . . . . . . . . . . . . . .
Discharge warning light 70
. . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 184
. . . . . . . . . . . . . . . . . . .
Service precautions 183
. . . . . . . . . . . . . .
Does your vehicle need repairing? 177
. . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt light 70
. . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 70 . . . . .
Driving Driving tips 139,140
. . . . . . . . . . . . . . . . . .
Manual transmission 88
. . . . . . . . . . . . . .
Sequential manual transmission 77 . . . .
Driving tips
Driving tips in various conditions 139
. . . . . . . . . . . . . . . . . . . . .
Driving with a manual
transmission 88
. . . . . . . . . . . . . . . . . . . .
Economical driving 142
. . . . . . . . . . . . . . .
Good driving practice 88
. . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . .
During Breakin 124
. . . . . . . . . . . . . . . . . . . . . . . .


02 MY MR2 SMT(U) L/O 0108
230
01 06 12
2002 MR2 (OM17493U)
H
Hazard switch63
. . . . . . . . . . . . . . . . . . . . . .
Headlight switch 62
. . . . . . . . . . . . . . . . . . . .
High speed operation During breakin 124
. . . . . . . . . . . . . . . . . .
Hood release, Engine 16
. . . . . . . . . . . . . . . .
How to start the engine 138
. . . . . . . . . . . . .
I
Identification
Engine 133 . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 133 . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 76 . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5 . . . . . . . . . . . . . . . . . . . .
Instrument panel Cigarette lighter and ashtray 116 . . . . . . .
Clock 116 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5 . . . . . . . . . . . . . . . . . .
Odometer 69 . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 69 . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 69 . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 64 . . . . . . . . .
Instrument panel overview 2 . . . . . . . . . . . .
Iridiumtipped spark plugs 129 . . . . . . . . . .
J
Jack
Location 153 . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 186 . . . . . . . . . . . . . . .
Jump starting 147 . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 74
. . . . . . . . . . . . . . . .
Keys 8,164
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Backup lights 209 . . . . . . . . . . . . . . . . . . .
Front turn signal lights 208 . . . . . . . . . . . .
Front side marker lights 208 . . . . . . . . . . .
Headlights 206 . . . . . . . . . . . . . . . . . . . . . . .
License plate lights 210 . . . . . . . . . . . . . . .
Parking lights 207 . . . . . . . . . . . . . . . . . . . .
Rear turn signal lights 209 . . . . . . . . . . . .
Rear turn signal, stop/tail, stop and backup lights 209 . . . . . . . . .
Light bulbs, replacing 204 . . . . . . . . . . . . . . .
Light reminder buzzer 70 . . . . . . . . . . . . . . .
Limitedslip differential 133 . . . . . . . . . . . . .
Lock
Side doors 11 . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 76 . . . . . . . . . . . . . . . . . . .
Low fuel level warning light 70 . . . . . . . . . . .
Low engine oil pressure warning light 70 . . . . . . . . . . . . . . . . . . . . . .
Luggage space 119 . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 132 . . . . . . .
M
Maintenance
Doityourself maintenance 183 . . . . . . .
Does your vehicle need repairing? 177 . . . . . . . . . . . . . . . .
General maintenance 175 . . . . . . . . . . . . .
Maintenance requirements 174 . . . . . . . .
Parts and tools 184 . . . . . . . . . . . . . . . . . . .
Where to go for service 174 . . . . . . . . . . .
Malfunction indicator lamp 70 . . . . . . . . . . .
Manual transmission Driving with a
manual transmission 88 . . . . . . . . . . . . .
Shift pattern 88 . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 88 . . . . . . . . . . . . . . . . . . . .
Maximum allowable speed Manual transmission 88 . . . . . . . . . . . . . .
Sequential manual transmission 77 . . . .
Mirror Antiglare inside rear view 59 . . . . . . . . .
Mirrors
Folding rear view 58 . . . . . . . . . . . . . . . . . .
Outside rear view 58 . . . . . . . . . . . . . . . . .
Power rear view 58 . . . . . . . . . . . . . . . . . . .
N
New vehicle breakin 124
. . . . . . . . . . . . . . .