2002 Peugeot 607 Dag oil change

The extension of the service intervals means that the engine oil level must be checked regularly: topping up of the
oil between two oil changes is normal.
It is for this reason that your Peugeot dealer will invite you to an intermediate visit between services. The date o f
this visit is not shown by the service indicator.
It is to be carried out between two services.
A Peugeot professional will carry out a quick check and will top up the levels if necessary (oil, coolant, screen wash up to
2 litres).
If the oil level is too low, there is a risk of significa nt damage to the engine: check the engine oil level at le ast every
3,000 miles (5 000 km).
This maintenance frequency is the result of developments to our vehicles and to the lubricants:
THUS IT IS ESSENTIAL THAT YOU ONLY USE ENGINE LUBRICANTS THAT ARE APPROVED AND RECOMMENDED
BY THE MANUFACTURER (see pages on 'Lubricants').
PEUGEOT SERVICING 19

INSTRUMENTS AND CONTROLS31
Coolant temperature warning light
This symbol is accompanied by an audible signal and the message
'Engine temperature too high'
on the multifunction display.
It is linked to the STOPwarning light. Stop immediately.
Warning: wait for the engine to cool.
If necessary, top up the level.
With the engine running and the vehicle moving
The instrument panel display temporarily shows:
– lights indicating warnings, when these occur,
– vehicle function status indicator lights, when a change occu rs.
Certain warning lights may be accompanied by an audib le signal and a
message on the multifunction display.
List of warning symbols MANUAL CHECK
(vehicle autotest)
 Press the "CHECK"button on
the instrument panel.
With the ignition key in the acces
sories position, with the ignition
switched on, with the engine running
or when the vehicle is moving, this
function informs you at all times of
the following: – any current warnings,
– the status of functions which it is possible to switch on or off (wind
screen wipers, automatic switch
ing on of lights, cruise control, dis
arming of passenger air bag, etc.).
The corresponding warning lights
are displayed in succession on the
instrument panel screen.
If a warning or a change of status
occurs during the CHECKmode, the
corresponding indicator lights will be
displayed at the end of this mode.
CHECK mode entry indi
cator light (vehicle
autotest)
This comes on when you
press the 'CHECK' button.
CHECK mode exit indica
tor light (vehicle autotest)
This comes on at the end of
the CHECK mode.
Engine oil pressure warning light
This symbol is accompanied by an audible signal and the message
'Insufficient engine oil pressure' or 'Engine oil pressure too low' on
the multifunction display.
It is linked to the STOPwarning light.
Stop immediately if this comes on when the engine is running.
If there is a lack of oil in the lubrication circuit, top up the level.
Contact a PEUGEOT dealer as soon as possible.
Puncture warning light
This symbol comes on accompanied by an audible signal and the me s
sage 'Punctured tyre(s) detected' on the multifunction display.
It is linked to the STOPwarning light. Stop immediately.
Change the damaged wheel.
Have it repaired by a PEUGEOT dealer.

CHECKING THE LEVELS
Oil level
Check the level regularly and top
up between changes. Maximum
consumption is 0.5 l per 600 miles
(1000 km).
Carry out this check with the
vehicle level, engine cold, using
the oil level gauge on the instru
ment panel or the dipstick.
Dipstick There are two marks
on the dipstick:
A= maximum
Never fill past this
mark.
B = minimum
To maintain the reliabi
lity of engines and
emission control sys
tems, the use of addi
tives in engine oil is
prohibited.
Oil change
According to the information given in
'PEUGEOT SERVICING'.
PRACTICAL INFORMATION 137
Viscosity selection
In all cases, the oil selected must
meet the manufacturer's require
ments.
Brake and clutch fluid level:
– The level must always be between
the DANGER and MAXIMUM
marks in the reservoir.
– If the level drops substantially, contact a PEUGEOT dealer imme
diately.
Fluid change:
– must be carried out according to the manufacturer's servicing schedule,
– use fluids approved by the manu facturer, which fulfil DOT4 stan
dards.
WARNING: brake and clutch fluid is
harmful to health and very corrosive.
Used oil
Prevent used oil from coming into
prolonged contact with the skin.
Do not dispose of used oil, brake and
clutch fluid or coolant into drains or
onto the ground. Power steering reservoir
Open the reservoir, with the engi
ne cold. The level should always
be above the MINI mark and close
to the MAXI mark.
Windscreen and headlamp
wash reservoir
For best quality cleaning and for your
safety, we recommend that you use
products approved by PEUGEOT
(reservoir capacity 4 litres or 6.5
litres with headlamp wash).

PRACTICAL INFORMATION
138
CHECK
...
Battery
At the start of winter, have your bat
tery checked by a PEUGEOT dealer.
Air filter and pollen filter
Have the filter elements replaced
regularly. If you drive in dusty con
ditions, change them twice as
often.
Particulate emission filter
Additive reservoir (Diesel
models)
It is essential the particulate emis
sion filter be maintained and the
additive reservoir be filled by a PEU
GEOT dealer, according to the man
ufacturer's servicing schedule.
Brake pads
Brake pad wear depends on the
style of driving, in particular for vehi
cles which are used in town, over
short distances . It may be neces
sary to check the thickness of the
pads, even between services. Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services. Have the system
checked by a PEUGEOT dealer.
Manual gearbox
This does not need an oil change.
Check the level, according to the
manufacturer's servicing schedule.
Automatic gearbox
This does not need an oil change.
Have the level checked by a
PEUGEOT dealer, according to the
manufacturer's servicing schedule.
Oil filter
Change the filter regularly, in accor
dance with the servicing schedule.
Fuel supply cutoff
In a serious collision, a mechanism
prevents fuel from reaching the
engine.
To reestablish the fuel supply:
 press the red button on the angle
of the front righthand suspension
assembly, under the bonnet..
Only use products
approved by Automobiles
PEUGEOT.
To ensure best perfor
mance from components as
important as the power steering
and the braking system,
PEUGEOT selects and offers
quite specific products.

PRACTICAL INFORMATION155
ACCESSORIES FOR YOUR 607
For your PEUGEOTonly use accessories and original parts approved by the
manufacturer.
These accessories and parts are all adapted to your PEUGEOT, after being tested and approved for reliability and safe
ty, which PEUGEOTcannot guarantee for other products.
A wide choice of original accessories, approved by PEUGEOT, is availa ble through the dealer network. T hey all carry the
PEUGEOTguarantee:
– Security : Antitheft alarms (prewired function), window engraving, wheel antitheft devices, first aid kit
etc.
– Protection : Covers compatible with side air bags, mats, boot tray, styling mu d flaps.
– Communication : Telephone, navigation equipment with monochrome (prewired fu nction) or colour screen , CD
changer, speakers.
– Customising : Alloy wheels, wheel trims, spoiler.
– Comfort : Portable refrigerator, telephone console.
– Leisure pursuits : Trailer tow bar (maximum towable load: 1800 kg), roof bars (maximum l oad: 75 kg), transpor
tation accessories (bicycle carrier, ski carrier), roof box, snow chains etc.
– Children : Booster seats and child seats, rear blind.
– Maintenance products:Windscreen wash fluid, interior and exterior cleaning and main tenance products.
Before fitting any electrical accessory to your vehicle, consult a PEUG EOT dealer.