2002 MERCEDES-BENZ E WAGON alternator belt

243 Contents – Instrument cluster display
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Instrument cluster displayMalfunction and indicator lamps
in the instrument cluster .........244
On-board diagnostic system .....244
Check engine malfunction
indicator lamp .............................244
Brake warning lamp ..................245
Supplemental restraint system
(SRS) indicator lamp ..................246
Fuel reserve and fuel cap
placement warning ....................246
Electronic stability program
(ESP) — warning lamp ...............247
BAS / ESP malfunction
indicator lamp .............................247ABS malfunction
indicator lamp ............................ 248
Seat belt warning lamp ............. 248
Malfunction and indicator lamp in
the center console .................... 249
AIRBAG OFF indicator lamp .... 249
Malfunction and warning
messages in the
multifunction display .............. 250
DISPLAY DEFECTIVE ................ 251
BATTERY / ALTERNATOR ........ 252
ABS-SYSTEM .............................. 253
BRAKE ASSIST ........................... 253
BRAKE LINING WEAR .............. 254BRAKE FLUID .............................254
PARKING BRAKE .......................255
ENGINE FAN ...............................255
COOLANT (coolant level) ..........256
COOLANT TEMP. ........................257
LIGHTING SYSTEM ....................258
LIGHT SENSOR ...........................259
REMOVE KEY .............................259
STEERING GEAR OIL .................260
ENGINE OIL LEVEL ................... 261
WASHER FLUID .........................262
ELEC. STABIL. PROG.
(Electronic stability program) ..263
TELE AID .....................................263

252 Malfunction and warning messages
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
BATTERY / ALTERNATORThis message indicates a malfunction which must be
repaired immediately.
It may indicate that the poly-V-belt has broken. Should
this condition occur, the poly-V-belt must be replaced
before continuing to operate the vehicle. Otherwise, the
engine will overheat due to an inoperative water pump
which may result in damage to the engine.
Do not continue to drive the vehicle with this message
displayed.
Doing so could result in serious engine damage that is
not covered by the Mercedes-Benz Limited Warranty.
Line 1 Line 2
BATTERY / ALTERNATOR VISIT WORKSHOP!
OVERVOLTAGE VISIT WORKSHOP!
UNDERVOLTAGE CONSUMER DEFECTIVE!

324 Technical data
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
3VIN, visible (lower edge of windshield)
4Engine number
5Body number and paintwork number
6Emission control label
7Information label, California version
Vacuum line routing for emission control system
When ordering spare parts, please specify vehicle
identification and engine number.Layout of poly-V-belt drive
1Automatic belt tensioner
2Crankshaft
3Air conditioner compressor
4Generator (alternator)
5Idler pulley
6Power steering pump
7Coolant pump
6
7
4
3
5
6
5
1
2
3
7
4

342 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Replacing bulbs ......................................................... 297
Side marker lamp, front ................................... 119, 303
Standing lamps ......................................... 119, 300, 301
Taillamps ........................................... 119, 258, 301, 316
Layout of poly-V-belt drive ............................................ 324
LIGHT SENSOR -
malfunction and warning messages ......................259
Lighter ............................................................................. 168
LIGHTING SYSTEM -
malfunction and warning messages ......................258
Limp home mode ........................................................... 211
Loading instructions ..................................................... 177
Locking and unlocking ................................................... 29
Low beams
Exterior lamps ...........................................................297
MMaintenance ................................................................... 187
Malfunction and indicator lamp
in the center console ................................................249
Malfunction and indicator lamps
in the instrument cluster .........................................244
Malfunction and warning messages ...........................250
ABS-SYSTEM ............................................................. 253
BATTERY / ALTERNATOR .......................................252BRAKE ASSIST ......................................................... 253
BRAKE FLUID ........................................................... 254
BRAKE LINING WEAR ............................................ 254
COOLANT (coolant level) ........................................ 256
COOLANT TEMP. ...................................................... 257
DISPLAY DEFECTIVE (engine control unit) .........251
DISPLAY DEFECTIVE (several systems) ................251
ELEC. STABIL. PROG. .............................................. 263
ENGINE FAN ............................................................. 255
ENGINE OIL LEVEL .................................................. 261
LIGHT SENSOR ......................................................... 259
LIGHTING SYSTEM .................................................. 258
PARKING BRAKE ..................................................... 255
REMOVE KEY ........................................................... 259
STEERING GEAR OIL ............................................... 260
TELE AID ................................................................... 263
WASHER FLUID ........................................................ 262
Malfunction message memory .................................... 108
Manual release for fuel filler flap .............................. 308
Mechanical keys ............................................................... 31
Memory ................................................................ 45, 81, 84
Recalling ....................................................................... 46
Storing ...........................................................................45
Mirror, exterior, adjusting .............................................. 83
Mirror, exterior, rear view .............................................. 83
Mirror, inside, rear view .................................................82