2002 MERCEDES-BENZ E WAGON coolant

332 Fuels, coolants, lubricants etc. - capacities
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Gasoline additives
A major concern among engine manufacturers is carbon
build up caused by gasoline. Mercedes-Benz
recommends the use of only quality gasoline containing
additives that prevent the build up of carbon deposits.
After an extended period of using fuels without such
additives, carbon deposits can build up especially on the
intake valves and in the combustion area, leading to
engine performance problems such as:
•warm-up hesitation,
•unstable idle,
•knocking / pinging,
•misfire,
•power loss.
Do not blend other specific fuel additives with fuel.
They only result in unnecessary cost, and may be
harmful to the engine operation.
Damage or malfunctions resulting from poor fuel
quality or from blending specific fuel additives are not
covered by the Mercedes-Benz Limited Warranty.Coolants
The engine coolant is a mixture of water and
anticorrosion / antifreeze, which provides:
•corrosion protection,
•freeze protection,
•boiling protection (by increasing the boiling point).
The cooling system was filled at the factory with a
coolant providing freeze protection to approximately
-22
°F (-30
°C) and corrosion protection.
If the antifreeze mixture is effective to -22
°F (-30
°C), the
boiling point of the coolant in the pressurized cooling
system is reached at approximately 266
°F (130
°C).
The coolant solution must be used year round to provide
the necessary corrosion protection and increase in the
boil-over protection. You should have it replaced every
3years.
To provide the important corrosion protection, the
solution must be at least 45% anticorrosion / antifreeze
(equals a freeze protection to approx. - 22
°F [- 30
°C]). If
you use a solution that is more than 55% anticorrosion /
antifreeze (freeze protection to approx. - 49
°F [- 45
°C]),

333 Fuels, coolants, lubricants etc. - capacities
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index the engine temperature will increase due to the lower
heat transfer capability of the solution. Therefore, do not
use more than this amount of anticorrosion / antifreeze.
If the coolant level is low, water and MB anticorrosion /
antifreeze should be used to bring it up to the proper
level (have cooling system checked for signs of leakage).
The water in the cooling system must meet minimum
requirements, which are usually satisfied by normal
drinking water. If your are not sure about the water
quality, consult your authorized Mercedes-Benz Center.
Anticorrosion / antifreeze
Your vehicle contains a number of aluminum parts. The
use of aluminum components in motor vehicle engines
necessitates that anticorrosion / antifreeze coolant used
in such engines be specifically formulated to protect the
aluminum parts. (Failure to use such anticorrosion /
antifreeze coolant will result in a significantly
shortened service life.)
Therefore the following product is strongly
recommended for use in your car: Mercedes-Benz
Anticorrosion / Antifreeze Agent.Before the start of the winter season (or once a year in
the hot southern regions), you should have the
anticorrosion / antifreeze concentration checked. The
coolant is also regularly checked each time you bring
your vehicle to your authorized Mercedes-Benz Center
for service.
Anticorrosion / antifreeze quantity
Approx. freeze protection
– 35
°F
(– 37 °C)– 49
°F
(– 45 °C)
5.6 US qt
(5.3 l)5.8 US qt
(5.5 l)

337 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex Economy ..................................................................... 129
Front center console
compartment ventilation .................................... 133
Rear passenger compartment
adjustable air outlet ............................................. 134
Rear window defroster ............................................. 130
Residual engine heat utilization (REST) ............... 132
Special settings ......................................................... 129
Automatic transmission ...............................................203
Emergency operation ............................................... 211
Fluid level ................................................................... 274
Program mode selector switch ............................... 210
Selector lever position ..............................................206
Transmission selector lever,
manually unlocking ............................................. 296
BBabySmart
TM airbag deactivation system ..................... 65
Self-test ......................................................................... 65
BAS (Brake assist system) ............................................ 225
Malfunction indicator lamp ..................................... 247
Battery .............................................................................289
Battery recycling ....................................................... 290
BATTERY / ALTERNATOR -
malfunction and warning messages ......................252Block heater ....................................................................221
BRAKE ASSIST -
malfunction and warning messages ..................... 253
Brake assist system (BAS) ........................................... 225
Malfunction indicator lamp .................................... 247
Brake fluid ..................................................................... 330
BRAKE FLUID -
malfunction and warning messages ..................... 254
BRAKE LINING WEAR -
malfunction and warning messages ..................... 254
Brake pad wear .............................................................. 254
Brake warning lamp ..................................................... 245
Brake fluid low ......................................................... 245
Brakes .................................................... 214, 225, 227, 230
Bulbs
Replacing bulbs ........................................................ 297
CCapacities
Fuels, coolants, lubricants etc. .............................. 328
Cargo tie-down rings ..................................................... 178
Catalytic converter ......................................................... 198
CD changer ...................................................................... 148
Audio systems ..............................................................97
Cellular telephone .......................................................... 179

338 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Center console .................................................................. 20
Central locking switch .................................................... 34
Central locking system ................................................... 27
Automatic central locking ......................................... 35
Choosing global or selective mode ........................... 30
Electronic key .............................................................. 25
Locking and unlocking .............................................. 29
Mechanical keys .......................................................... 31
Remote control ............................................................ 25
Summer opening/convenience feature ................... 30
CHECK ENGINE
malfunction indicator lamp ..................................... 244
Check regularly and before a long trip ...................... 241
Checking engine oil level
Via engine oil level indicator ...................................117
Via oil dipstick ...........................................................273
Child restraint ..................................................... 57, 65, 77
Child seat
Infant and child restraint systems ........................... 77
Cleaning and care of the vehicle ................................. 314
Clock, setting ...................................................................110
Coin holder in glove box lid ......................................... 163
COMAND, radio, telephone and two-way radio ........ 186
Combination switch ...................................................... 122
Consumer information .................................................. 334
Control and operation of radio transmitters ............. 186COOLANT (coolant level) -
malfunction and warning messages ..................... 256
Coolant level ................................................................... 274
Adding coolant .......................................................... 275
Checking ..................................................................... 274
COOLANT TEMP. -
malfunction and warning messages ..................... 257
Coolant temperature gauge ............................................90
Coolants .......................................................................... 332
Anticorrosion/antifreeze quantity ........................ 333
Cruise control ................................................................ 222
Cup holder
In center console ....................................................... 165
In glove box lid .......................................................... 163
In rear bench armrest ............................................... 162
DDaytime running lamps ................................................120
Deep water
Driving instructions .................................................221
DISPLAY DEFECTIVE (engine control unit) -
malfunction and warning messages ......................251
DISPLAY DEFECTIVE (several systems) -
malfunction and warning messages ......................251
Display illumination ........................................................89

340 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Express opening and closing
Power windows .......................................................... 154
Exterior lamp switch ......................................................119
Exterior lamps ................................................................ 297
Additional turn signals
on the exterior mirror .........................................303
Headlamp assembly ................................................. 298
High mounted stop lamp .........................................303
License plate lamps .................................................. 302
Low and high beam .................................................. 299
Parking lamps .................................................. 300, 301
Replacing bulbs ......................................................... 297
Side marker lamp, front ........................................... 303
Standing lamps ................................................. 300, 301
Taillamp assemblies ................................................. 301
Turn signal lamps ............................................ 300, 301
FFirst aid kit ..................................................................... 266
Flat tire
Changing wheels ......................................................282
Flexible service system (FSS) .......................................114
Four wheel
electronic traction system (4MATIC)
with electronic stability program (ESP) ................229Fuel .................................................................................. 239
Gasoline additives .................................................... 332
Premium unleaded gasoline .................. 239, 329, 331
Fuel cap placement warning ....................................... 246
Fuel requirements ......................................................... 331
Fuel reserve warning .................................................... 246
Fuels, coolants, lubricants etc. - capacities .............. 328
Fuse box
Fuses .......................................................................... 267
Fuses, electrical ............................................................. 267
GGarage door opener ....................................................... 180
Gasoline
Additives .................................................................... 332
Fuel requirements .................................................... 331
Premium unleaded ................................................... 331
General notes on the
central locking system ............................................... 26
Global locking
Central locking ............................................................ 27
Glove box ......................................................................... 163

342 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Replacing bulbs ......................................................... 297
Side marker lamp, front ................................... 119, 303
Standing lamps ......................................... 119, 300, 301
Taillamps ........................................... 119, 258, 301, 316
Layout of poly-V-belt drive ............................................ 324
LIGHT SENSOR -
malfunction and warning messages ......................259
Lighter ............................................................................. 168
LIGHTING SYSTEM -
malfunction and warning messages ......................258
Limp home mode ........................................................... 211
Loading instructions ..................................................... 177
Locking and unlocking ................................................... 29
Low beams
Exterior lamps ...........................................................297
MMaintenance ................................................................... 187
Malfunction and indicator lamp
in the center console ................................................249
Malfunction and indicator lamps
in the instrument cluster .........................................244
Malfunction and warning messages ...........................250
ABS-SYSTEM ............................................................. 253
BATTERY / ALTERNATOR .......................................252BRAKE ASSIST ......................................................... 253
BRAKE FLUID ........................................................... 254
BRAKE LINING WEAR ............................................ 254
COOLANT (coolant level) ........................................ 256
COOLANT TEMP. ...................................................... 257
DISPLAY DEFECTIVE (engine control unit) .........251
DISPLAY DEFECTIVE (several systems) ................251
ELEC. STABIL. PROG. .............................................. 263
ENGINE FAN ............................................................. 255
ENGINE OIL LEVEL .................................................. 261
LIGHT SENSOR ......................................................... 259
LIGHTING SYSTEM .................................................. 258
PARKING BRAKE ..................................................... 255
REMOVE KEY ........................................................... 259
STEERING GEAR OIL ............................................... 260
TELE AID ................................................................... 263
WASHER FLUID ........................................................ 262
Malfunction message memory .................................... 108
Manual release for fuel filler flap .............................. 308
Mechanical keys ............................................................... 31
Memory ................................................................ 45, 81, 84
Recalling ....................................................................... 46
Storing ...........................................................................45
Mirror, exterior, adjusting .............................................. 83
Mirror, exterior, rear view .............................................. 83
Mirror, inside, rear view .................................................82