2002 MAZDA MODEL PROTÉGÉ belt

8-5
Maintenance and Care
Scheduled Maintenance
Form No. 8Q36-EA-01F

Schedule 2
I
: Inspect and repair, clean, adjust, or replace if necessary.
(Oil-permeated air filter cannot be cleaned using the air-blow method.)
R
: Replace
L
: Lubricate
*1: According to state and federal regulations, failure to perform maintenance on these items will not void your
emissions warranties. However, Mazda recommends that all maintenance services be performed at the
recommended time or kilometrage (mileage) period to ensure long-term reliability.
*2: If the vehicle is operated in cold districts { below -18 degrees C (0 degrees F) }, replace the timing belt at
96,000 km (60,000 miles).
Maintenance
Interval
Maintenance
ItemNumber of months or kilometers (miles), whichever comes first
Months 4 8 12 16 20 24 28 32 36 40 44 48
×1000 Km 8 1624324048566472808896
(×1000 Miles) (5) (10) (15) (20) (25) (30) (35) (40) (45) (50) (55) (60)
Engine valve clearanceI
Engine timing belt
*2Inspect at 96,000 km (60,000 miles)
Replace every 168,000 km (105,000 miles)
Drive belts (tension) II
Engine oilExcept Puerto RicoRRRRRRRRRRRR
Puerto RicoReplace every 5,000 km (3,000 miles) (or 3 months)
Engine oil filterRRRRRRRRRRRR
Cooling systemII
Engine coolantReplace at first 72,000 km (45,000 miles) or 36 months ;
after that, every 48,000 km (30,000 miles) or 24 months
Engine coolant levelIIIIIIIIIIII
Idle speedII
Air filter
I
*1R
I *1R
Fuel lines & hoses*1II
Hoses & tubes for emission*1I
Spark plugsRR
Function of all lightsIIIIIIIIIIII
Brake lines, hoses & connectionsII
Brake & clutch fluid level IIIIIIIIIIII
Disc brakesIIII
Drum brakesII
Tire inflation pressure and tire wearIIIIIIIIIIII
Steering operation & linkagesII
Power steering fluid levelIIIIIIIIIIII
Front suspension ball jointsII
Driveshaft dust bootsII
Bolts & nuts on chassis & bodyIIII
Exhaust system heat shieldsII
All locks & hingesLLLLLLLLLLLL
Washer fluid levelIIIIIIIIIIII
Refrigerant amount (if installed) IIII
Compressor operation (if installed) IIII
J39L(02MY).book Page 5 Thursday, November 1, 2001 10:49 AM

8-6
Maintenance and Care
Scheduled Maintenance
Form No. 8Q36-EA-01F
Emission control and related systems
The ignition and fuel systems are highly important to the emission control system and to
efficient engine operation. Don’t tamper with them.
All inspections and adjustments must be made by a qualified technician. We strongly
recommend that all servicing related to these systems be done by an Authorized Mazda
Dealer.
I
: Inspect: Inspect and clean, repair, adjust, or replace if necessary . R: Replace
*1: Also inspect and adjust the power steering and air conditioner drive belts, if installed.
*2: Replacement of the timing belt is required at every 100,000 km (60,000 miles). Failure to replace the timing
belt may result in damage to the engine.
*3: If the vehicle is operated under any of the following conditions, change the engine oil and oil filter more often
than recommended intervals.
a) Driving in dusty conditions.
b) Extended periods of idling or low speed operation.
c) Driving for long period in cold temperatures or driving regularly at short distance only.
*4: If the vehicle is operated in very dusty or sandy areas, inspect and if necessary, clean or replace the air filter
more often than the recommended intervals.
Scheduled Maintenance (Chile)
NOTE
•After the described period, continue to follow the described maintenance at the
recommended intervals.
•As the result of visual examination or functional measurement of a system’s
operation (performance), correct, clean, or replace as required. (Inspect, and if
necessary replace the air filter)
Maintenance
Interval
Maintenance
ItemNumber of months or km (miles), whichever comes first
Months 6 121824303642485460667278849096
×1000 Km 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160
(×1000 Miles) (6) (12) (18) (24) (30) (36) (42) (48) (54) (60) (66) (72) (78) (84) (90) (96)
Engine valve clearance
Ins
pect every 100,000 km (60,000 miles) or 60 months
Idle speedIIIIIIII
Fuel filterRRRR
Spark plugsRRRRR
Evaporative system (if installed)
IIIIIIII
Drive belts*
1IIIIIIIIIIIIIIII
Engine timing belt*2Replace every 100,000 km (60,000 miles)
Engine oil*3RRRRRRRRRRRRRRRR
Oil filter*3RRRRRRRRRRRRRRRR
Cooling systemIIIIIIII
Engine coolant
Re
place every 2 years
Air filter*4IRIRIRIR
Fuel line and hosesIIIIIIII
J39L(02MY).book Page 6 Thursday, November 1, 2001 10:49 AM

8-26
Maintenance and Care
Owner Maintenance
Form No. 8Q36-EA-01F

Battery Maintenance
To get the best service from a battery:
•Keep it securely mounted.
•Keep the top clean and dry.
•Keep terminals and connections clean,
tight, and coated with petroleum jelly
or terminal grease.
•Rinse off spilled electrolyte
immediately with a solution of water
and baking soda.
•If the vehicle will not be used for an
extended time, disconnect the battery
cables.For reasons of proper performance, safety,
and better fuel economy, always maintain
recommended tire inflation pressures and
stay within the recommended load limits
and weight distribution.
Tires
Using Different Tire Types:
Driving your vehicle with different
types of tires is dangerous. It could
cause poor handling and poor
braking; leading to loss of control.
Except when using the temporary
spare tire, use only the same type tires
(radial, bias-belted, bias-type) on all
four wheels.
Using Wrong-Sized Tires:
Using any other tire size than what is
specified for your Mazda (page 10-7)
is dangerous. It could seriously affect
ride, handling, ground clearance, tire
clearance, and speedometer
calibration. This could cause you to
have an accident. Use only tires that
are the correct size specified for your
Mazda.
WARNING
J39L(02MY).book Page 26 Thursday, November 1, 2001 10:49 AM

8-48
Maintenance and Care
Appearance Care
Form No. 8Q36-EA-01F

Dashboard Precautions
Prevent caustic solutions such as perfume
and cosmetic oils from contacting the
dashboard. They’ll damage and discolor
it. If these solutions get on the dashboard,
wipe them off immediately.

Cleaning the Upholstery and
Interior Trim
Vinyl
Remove dust and loose dirt from vinyl
with a whisk broom or vacuum cleaner.
Clean vinyl with a leather-and-vinyl
cleaner.
Leather
Real leather isn’t uniform and may have
scars, scratches, and wrinkles. Clean it
with a leather cleaner or mild soap.
Wipe it with a damp
soft cloth; then dry
and buff it with a dry
soft cloth.
Fabric
Remove dust and loose dirt from fabric
with a whisk broom or vacuum cleaner.
Clean it with a mild soap solution good
for upholstery and carpets. Remove fresh
spots immediately with a fabric spot
cleaner.
To keep the fabric looking clean and
fresh, take care of it. Otherwise its color
will be affected, it can be stained easily,
and its fire-resistance may be reduced.

Cleaning the Lap/Shoulder Belt
We b b i n g
Clean the webbing with a mild soap
solution recommended for upholstery or
carpets. Follow instructions. Don’t bleach
or dye the webbing; this may weaken it.
After cleaning the belts, thoroughly dry
the belt webbing and make sure there is
no remaining moisture before retracting
them.

Cleaning the Window Interiors
If the windows become covered with an
oily, greasy, or waxy film, clean them
with glass cleaner. Follow the directions
on the container.
Interior Care
Use only recommended cleaners and
procedures. Others may affect
appearance and fire-resistance.
Damaged Seat Belt:
Using damaged seat belts is
dangerous. In a collision, damaged
belts cannot provide adequate
protection. Have your Authorized
Mazda Dealer replace damaged belts
immediately.
Don’t scrape or scratch the inside of
the rear window. You may damage the
rear window defroster grid.
CAUTION
WARNING
CAUTION
J39L(02MY).book Page 48 Thursday, November 1, 2001 10:49 AM

11-5
Index
Form No. 8Q36-EA-01F
R
Rear Window Washer ...................... 5-37
Rear Window Wiper
........................ 5-37
Rearview Mirror
............................... 3-25
Recreational Towing
........................ 7-20
Rocking the Vehicle
........................... 4-7
Roof Rack
........................................ 3-21
S
Safety Defects, Reporting ................ 9-14
Seat Belt System
Pretensioner and load limiting
.. 2-16
Seat belt precautions
................. 2-11
Seat Belt Systems
............................. 2-11
3-point type
............................... 2-14
Extender
.................................... 2-20
Pregnant women
....................... 2-12
Rear-center lap/shoulder
........... 2-18
Warning light/beep
................... 2-21
Seats
Front seats
................................... 2-2
Rear seat
...................................... 2-5
Service Publications
......................... 9-14
Spare Tire and Tool Storage
.............. 7-3
Specifications
................................... 10-4
Speedometer
..................................... 5-21
SRS Air Bags
Air bag system description
....... 2-40
Supplemental restraint systems
precautions
................................ 2-35
Warning light
............................ 2-45
Starting the Engine
............................. 5-3
Steering Wheel
................................. 3-24
Horn
.......................................... 5-38
Storage Compartments
..................... 6-39
Sunroof
............................................. 3-19
Sunshade
.......................................... 3-20
Sunvisors
.......................................... 6-35
T
Tachometer .......................................5-22
Temporary Spare Tire
......................8-29
Tiedown
Hook
..........................................7-19
Tires
Flat tire
........................................7-3
Inflation pressure
.......................8-27
Replacement
..............................8-28
Rotation
.....................................8-28
Snow tires
....................................4-8
Spare tire and tool storage
...........7-3
Specifications
............................10-7
Tire chains
...................................4-9
Uniform tire quality grading
system (UTQGS)
.......................9-12
Tool
....................................................7-3
Towing
Description
................................7-18
Emergency towing
....................7-18
Hook
..........................................7-19
Recreational towing
..................7-20
Trailer towing
............................4-11
Trailer Towing
..................................4-11
Trip Meter
........................................5-21
Trunk Lid
..........................................3-11
Trunk Light
......................................3-12
Trunk Release Handle
......................3-13
Turn and Lane-Change Signals
........5-34
V
Vanity Mirrors ..................................6-35
Vehicle Information Labels
..............10-2
J39L(02MY).book Page 5 Thursday, November 1, 2001 10:49 AM

11-6
Index
Form No. 8Q36-EA-01F
W
Warning Lights ................................ 5-24
Air bag system
.......................... 5-29
Anti-lock brake system
(ABS)
........................................ 5-29
Brake system
............................ 5-26
Charging system
....................... 5-27
Check engine
............................ 5-28
Door-ajar
................................... 5-30
Engine oil pressure
................... 5-28
Front seat belt pretensioner
system
....................................... 5-29
Low fuel
.................................... 5-30
Low washer fluid level
............. 5-30
Seat belt
.................................... 5-30
Warranty
............................................ 9-8
Washer Fluid
.................................... 8-20
Weights
............................................ 10-6
Wheel Replacement
......................... 8-29
Windows
Power windows
........................ 3-15
Windshield Washer
.......................... 5-36
Windshield Wipers
.......................... 5-36
Blades replacement
................... 8-22
Winter Driving
................................... 4-8
J39L(02MY).book Page 6 Thursday, November 1, 2001 10:49 AM