2002 HONDA PASSPORT 4WD

222Care and Maintenance
Front (4WD Only) and Rear
Propeller Shaft
Lubricate the sliding yoke with
EP chassis grease. Lubricate
universal joints with grease
containing MoS
2 (molybdenum
disulfide-type grease) at the
intervals shown in the
Maintenance Schedule. Also
check the propeller shaft
flange-to-pinion bolts for proper
torque of 64 N⋅ m (46.3 lb-ft).
Most lubrication recommendations
and procedures for four-wheel drive-
equipped vehicles are the same
for the corresponding components
in conventional drive vehicles.
Exhaust System
Check the complete exhaust
system and nearby body areas for
damaged, missing, or
mispositioned parts, open seams, holes, loose connections, or other
deterioration that could allow
exhaust fumes to seep into the
passenger compartment or cause
heat build-up in the floor pan. Any
necessary corrections should be
made immediately. For continued
safety, exhaust system pipes and
resonators rearward of the muffler
must be replaced whenever a new
muffler is installed.
Fuel Line and Fuel Tank/Cap
Inspect the fuel tank, cap and lines
for damage that could cause
leakage. Inspect the fuel cap and
gasket for correct sealing ability
and indications of physical
damage. Replace any damaged or
malfunctioning parts.
Drive Belt
Check the belt driving the
alternator, power steering pump,
and air conditioning compressor.
Look for cracks, fraying, and
wear. Replace as necessary.
Timing Belt
The timing belt should normally
be replaced at the intervals shown
in the Maintenance Schedule.
Valve Clearance
Incorrect valve clearance will
result in increased engine noise
and lower engine output, thereby
adversely affecting engine
performance.

Technical Data237
Manual Transmission and Transfer Case
2WD 4WD
Gear ratio Transmission
Rev.
1st
2nd
3rd
4th
5th
Transfer case High
Low
3.873
3.767
2.248
1.404
1.000
0.809
–
–3.873
3.767
2.248
1.404
1.000
0.809
1.000
2.051
Oil capacityTransmission
3.1 U.S. quarts
(2.95 liters)3.1 U.S. quarts
(2.95 liters)
Transfer case–1.5 U.S. quarts
(1.45 liters)
Automatic Transmission and Transfer Case
2WD 4WD
Gear ratio Transmission
Rev.
1st
2nd
3rd
Overdrive
Transfer case High
Low
2.000
2.856
1.618
1.000
0.723
–
–2.000
2.856
1.618
1.000
0.723
1.000
2.051
Gear control
operationFloor control
Fluid CapacityTransmission
Transfer case
9.1 U.S. quarts (8.6 liters)
–9.1 U.S. quarts(8.6 liters)
1.5 U.S. quarts (1.45 liters)
Fuel Tank Capacity
19.5 U.S. gallons (75 liters)

Technical Data239
Rear Axle
Models2WD4WDModels2WD4WD
Gear ratio4 3004 300Gear ratio4.3004.300
Lubricant capacity1.87 U.S. quarts(1.77 liters)
Front Axle (4WD Model)
Gear ratio4.300
Lubricant capacity1.6 U.S. quarts (1.5 liters)
Shift-on-the-Fly System
Lubricant capacity0.13 U.S. quarts (0.12 liters)
Wheels and Tires
Tire size225/75R16245/70R16
Wheel size16 x 7 JJ16 x 7 JJ
Tire pressure29 psi (200 kPa)26 psi (180 kPa)
Wheel nut
tightening torque87 lb.ft (118 N.m )

Technical Data241
Fuse Box: Instrument Panel
AmperageApplicability
120AAccessory power sockets
2––––
315ACigarette lighter
415ADash/parking lights
510AInterior lights
615ABrake lights, cruise control
720APower door locks
810AMirror defoggers
915ARear window defogger
1015ARear window defogger
1115AGauges, indicators
1215ACharging system, fuel injection
1315AIgnition system
1415ATurn signals, backup lights
1515AABS, 4WD, cruise control
1620AWindshield wiper/washer
1710ARear wiper/washer
1810ASecurity & keyless entry
1915AAudio system
2020AStarter
2130APower windows, moonroof
2210ASRS
23––––

Technical Data243
Light Bulbs
ApplicationBulb No.QuantityRating
Candlepower
Front Lights
Headlight – Halogen
Fog
Turn signal & Parking light
Sidemarker9004
10342
2
265/45 watts
55 watts 21/5
Rear LightsBack-up
License
Tail, Stop & Sidemarker
Turn signal
High-mounted stop light1156
–
1157
1156 –2
2
2
2
427 watts
5 watts
27/8 watts
27
5 watts
Interior Illumination A/C-heater cont.
Dome light
Instrument cluster
Stop light
Luggage light
Step light74
–
158/74 –
–
–1
1
3/6 or 2 2
1
41.4
7 watts 2/1.4
5 watts
5 watts
5 watts
Dimensions and Weights
Model2WD4WD
Wheelbase–106.4 in. (2,702 mm)
Overall
Spare tire:
under floor178.2 in. (4,525 mm)OverallLengthSpare tire: tailgate184.2 in. (4,678 mm)
OverallLX, EX70.4 in. (1,784 mm)OverallWidthEX-L71.1 in. (1, 805 mm)
OverallHeightP225/75R1668.6 in. (1,743 mm)Height
(At curb Wt.)P245/70R1668.8 in. (1,748 mm)
Tread Front59 6 in (1 515 mm)Tread Front59.6 in. (1,515 mm)
Tread Rear59 8 in (1 520 mm)Tread Rear59.8 in. (1,520 mm)
GVWR–4,950 lb
(2,250 kg)5,200 lb
(2,360 kg)
Note: GVWR—Gross Vehicle Weight Rating