2002 HONDA INSIGHT low oil pressure

The condition of your car and your
driving habits are the two most
important things that affect the fuel
mileage you get.
Always maintain your car according
to the maintenance schedule. This
will keep it in top operating condition.
An important part of that mainte-
nance is the(see page ). For
example, an underinf lated tire
causes more ‘‘rolling resistance,’’
which uses f uel. It also wears out
f aster, so check the tire pressure at
least monthly. Engine oil also af f ects f uel economy.
The f uel ef f icient, low-viscosity
0W-20 oil recommended f or your
Insightisformulatedtohelpthe
engine use less f uel. This oil is
available at your Honda dealer.
In winter, the build-up of snow on
your car’s underside adds weight and
rolling resistance. Frequent cleaning
helps your f uel mileage and reduces
thechanceof corrosion.
You can improve f uel economy by
driving moderately. Rapid acceler-
ation, abrupt cornering, and hard
braking use more f uel.
To get the best f uel mileage, drive in
the highest gear that is practical for
the speed you are driving, and
always accelerate slowly.You may f ind that your Insight’s
unique combination of an engine and
an electric motor has driving
characteristics that are somewhat
dif f erent f rom what you are used to.
Shif t Up and Shif t Down indicators
(5-speed manual transmission only)
on the instrument panel show when
to shif t to a higher or lower gear. By
shifting as soon as the indicator
comes on, you will keep the engine
operating in its most economical
range.
Wind resistance causes vehicles to
usemorefuelathigherspeeds.
Driving at moderate speeds on the
highway reduces wind resistance
and conserves f uel. Depending on traf f ic conditions, try
to maintain a constant speed. Every
time you slow down and speed up,
your car uses extra f uel.
163
Fuel Economy
Bef ore Driving
Vehicle Condition
Owner Maintenance
Checks Driving Habits
124

µ
µ Being able to see
clearly in all directions and being
visible to other drivers are important
in all weather conditions. This is
more difficult in bad weather. To be
seen more clearly during daylight
hours, turn on your headlights.
Inspect your windshield wipers and
washers f requently. Keep the wind-
shield washer reservoir f ull of the
proper f luid. Have the windshield
wiper blades replaced if they start to
streak the windshield or leave parts
unwiped. Use the def rosters and air
conditioning to keep the windows
f rom f ogging up on the inside (see
page ).
Exercise extra caution when driving
in rain af ter a long dry spell. Af ter
months of dry weather, the f irst
rains bring oil to the surf ace of the
roadway, making it slippery.
Rain, f og, and snow conditions re-
quire a dif f erent driving technique
because of reduced traction and
visibility. Keep your car well-
maintained and exercise greater
caution when you need to drive in
bad weather. Always drive
slower than you would in dry
weather. It takes your car longer to
react, even in conditions that may
seem just barely damp. Apply
smooth, even pressure to all the
controls. Abrupt steering wheel
movements or sudden, hard appli-
cation of the brakes can cause loss of
control in wet weather. Be extra
cautious f or the f irst f ew miles
(kilometers) of driving while you
adjust to the change in driving
conditions. This is especially true in
snow. A person can f orget some
snow-driving techniques during the
summer months. Practice is needed
to relearn those skills. 88
CONT INUED
Visibility
Driving T echnique
Driving in Bad Weather
Driving149

This section also includes
Maintenance Schedules f or normal
driving and severe driving conditions,
a Maintenance Record, and instruc-
tions f or simple maintenance tasks
you may want to take care of
yourself .
If you have the skills and tools to per-
f orm more complex maintenance
tasks on your Honda, you may want
to purchase the Service Manual. See
page f or inf ormation on how to
obtain a copy, or see your Honda
dealer. This section explains why it is
important to keep your car well
maintained and to f ollow basic
maintenance saf ety precautions.......................
Maintenance Saf ety .152
.
Important Safety Precautions . 153
.................
Maintenance Schedule . 154
...
Required Maintenance Record . 161
.......
Owner Maintenance Checks . 163
..............................
Fluid Locations .164
......................................
Engine Oil .165
..................................
Adding Oil .165
....................
Recommended Oil .165
..............................
Synthetic Oil .166
....................................
Additives .166
.....
Changing the Oil and Filter . 167
.............................
Cooling System .169
............
Adding Engine Coolant . 169
.......
Replacing Engine Coolant . 171
....................
Windshield Washers .175
.......................
Transmission Fluid .176
Automatic Transmission .....................................
(CVT) .176
5-speed Manual .........................
Transmission .178
................
Brake and Clutch Fluid . 179
............................
Brake System .179
...........................
Clutch System .180
.....................
Air Cleaner Element .181
....................................
Hood Latch .182 ...........................................
Battery .183
.................................
Wiper Blades .185
..............
Air Conditioning System . 188
..................
DustandPollenFilter . 189
.....................................
Drive Belts .189
...............................................
Tires .190
......................................
Inf lation .190
Recommended Tire Pressures f or Normal ...............................
Driving .191
..................................
Inspection .192
..............................
Maintenance .192
.............................
Tire Rotation .193
...
Replacing Tires and Wheels . 193
......................
Wheels and Tires .194
..........................
Winter Driving .194
.............................
Snow Tires .195
............................
Tire Chains .195
.............................................
Lights .196
........................
Replacing Bulbs .198
...........................
Storing Your Car .204
259
Maintenance
Maint enance151

µµ µ
µ µ
µ µ
Youshouldcheckthefollowing
items at the specif ied intervals. If
you are unsure of how to perf orm
any check, turn to the page given.
Engine oil level Check every
time you fill the fuel tank. See
page .
Engine coolant level Check the
radiator reserve tank every time
youfillthefueltank.Seepage .Tires Check the tire pressure
monthly. Examine the tread f or
wear and foreign objects. See page
.
Windshield washer f luid Check
the level in the reservoir monthly.
If weather conditions cause you to
use the washers f requently, check
the reservoir each time you stop
f or f uel. See page . Lights Check the operation of
the headlights, parking lights,
taillights, high-mount brake light,
turn signals, brake lights, and
license plate lights monthly. See
page .
Brakes Check the f luid level
monthly. See page . Automatic transmission (CVT)
Check the f luid level monthly. See
page . 122
123
175
176 179 191
196
Owner Maintenance Checks
Maint enance163

Periodically check the engine’s
radiator and air conditioning
condenser f or leaves, insects, and
dirt stuck to the f ront surf ace. These
block the air f low and reduce cooling
ef f iciency. Use a light spray f rom a
hose or a sof t brush to remove them.If the air conditioning does not get as
cold as before, have your dealer
check the system. Recharge the
system with Ref rigerant HFC-134a
(R-134a). (See Specif ications on page
.)
Run the air conditioning at least once
a week during the cold weather
months. Run it f or at least ten
minutes while you are driving at a
steady speed with the engine at
normal operating temperature. This
circulates the lubricating oil con-
tained in the ref rigerant.
Your car’s air conditioning is a sealed
system. Any major maintenance,
such as recharging, should be done
by a qualif ied mechanic. You can do
a couple of things to make sure the
air conditioning works ef f iciently.
243
Maint enance
Air Conditioning System (Optional)
188
A AI
IRR C
COON NDDI
ITT I
IOON NIINNG G C
COON NDDE
EN
NS SEER
R
Whenever you have the air conditioning
system serviced, make sure the service
f acility uses a ref rigerant recycling
system. This system captures the
ref rigerant f or reuse. Releasing
ref rigerant into the atmosphere can
damage the environment.
The condenser and radiator f ins bend
easily. Only use a low-pressure spray
or sof t-bristle brush to clean them.

This section covers the more-
common problems that motorists
experience with their vehicles. It
gives you inf ormation about how to
safely evaluate the problem and what
to do to correct it. If the problem has
stranded you on the side of the road,
you may be able to get going again.
If not, you will also f ind instructions
on getting your car towed.......................
Compact Spare Tire .214
....................
Changing a Flat Tire .215
..........
If Your Engine Won’t Start . 221
Nothing Happens or the Starter Motor Operates ............................
Very Slowly .221
The Starter Operates ................................
Normally .222
................................
Jump Starting .222
............
If Your Engine Overheats . 224
.........
Low Oil Pressure Indicator . 226
..........
Charging System Indicator . 227
.......
Malf unction Indicator Lamp . 228
...............
Brake System Indicator . 230
..............................................
Fuses .231
..........
Checking and Replacing . 232
......................
Emergency Towing .237
Taking Care of the Unexpected
T aking Care of t he Unexpect ed213

This indicator should light when the
ignition switch is ON (II), and go out
af ter the engine starts. It should
never come on when the engine is
running. If it starts f lashing, it
indicates that the oil pressure
dropped very low f or a moment, then
recovered. If the indicator stays on
with the engine running, it shows
that the engine has lost oil pressure
and serious engine damage is
possible. In either case, you should
take immediate action.Saf ely pull of f the road and shut
of f the engine. Turn on the hazard
warning indicators.
If necessary, add oil to bring the
level back to the full mark on the
dipstick (see page ). Letthecarsitforaminute.Open
the hood and check the oil level
(see page ). Although oil level
and oil pressure are not directly
connected, an engine that is very
low on oil can lose pressure during
cornering and other driving
maneuvers.Start the engine and watch the oil
pressure indicator. If the light
does not go out within ten seconds,
turn of f the engine. There is a
mechanical problem that needs to
be repaired bef ore you can
continue driving. (See
on page .)
The engine running generates the
oil pressure.
When the auto idle stop is
activated, the engine is stopped.
But the low oil pressure indicator
does not light.
1.
2.
3. 4.
122 165 237
Emergency
Towing
L ow Oil Pressure Indicator
T aking Care of t he Unexpect ed226
L LO OW W O
OIILL P
PR
RE ES
SS SUUR REE I
INND DI
ICCA A T
TO
OR R
Running the engine with low oil
pressure can cause serious mechanical
damage almost immediately. Turn of f
the engine as soon as you can saf ely get
the car stopped.

CONT INUED
.....
Charging System Indicator . 227
..................
Checking the Fuses . 232
.....
Low Oil Pressure Indicator . 226
...
Malf unction Indicator Lamp . 228
..................
Overheated Engine . 224
...........................
Emergency Brake .79
......................
Emergency Flashers .65
......................
Emergency Towing .237
.......................
Emissions Controls .248
Engine ............................................
Belts .189
....
Coolant Temperature Gauge . 58
Malf unction Indicator ................................
Lamp .48, 228
..............
Oil, What Kind to Use . 165
...............................
Overheating .224
............................
Specif ications .242
.......................................
Starting .133
..........
Engine Speed Limiter . 137,141
......................
Ethanol in Gasoline .246
.
Evaporative Emissions Controls . 248
...............................
Exhaust Fumes .40
Expectant Mothers, Use of Seat ........................................
Belts by .17
..................
Exterior, Cleaning the . 206 ...............
Gas Mileage, Improving . 124
..........................................
Gasohol .246
.........................................
Gasoline .118
...............
Fuel Reserve Indicator . 48
...........................................
Gauge .50
................
Octane Requirement . 118
........................
Tank, Filling the .119
................
Gas Station Procedures . 119
............................
Fabric, Cleaning .209
.....................................
Fan, Interior .84
Features, Comfort and ................................
Convenience .83
....................
Filling the Fuel Tank . 119
Filter .........................
Dust and Pollen .189
...............................................
Oil .165
5-speed Manual Transmission ...............
Checking Fluid Level . 178
................................
Shif ting the .134
.............
Flashers, Hazard Warning . 65
...................
Flat Tire, Changing a . 215
Fluids Automatic Transmission .....................................
(CVT) .176
..........................................
Brake .179
.........................................
Clutch .180
..............
Manual Transmission . 178
..................
Windshield Washer . 175
FM Stereo Radio ...................................
Reception .112
.....
Foreign Countries, Driving in . 247
..........................
Four-way Flashers .65 .................................................
Fuel .124
......................
Fill Door and Cap .119
...........................................
Gauge .58
................
Octane Requirement . 118
...............................
Oxygenated .246
........................
Reserve Indicator .58
........................
Tank, Filling the .119
.....................
Fuses, Checking the .232
Index
F
G
III