2002 HONDA INSIGHT maintenance schedule

µµ
µµ
The belts should have the f ollowing
‘‘play’’ or def lection.
With Air Conditioning System
Without Air Conditioning System
If you see signs of wear or looseness,
have your dealer adjust or replace
the belts.
Check the tension of each belt by
pushingonitwithyourthumb
midway between the pulleys. Check the condition of the drive belt.
Examine the edges of each belt for
cracks or fraying.
The dust and pollen f ilter removes
pollen and dust f rom the outside air
the heating and cooling system
brings into the interior. It should be
replaced according to the time and
distance recommendations in the
maintenance schedule.
This f ilter should be replaced every
30,000 miles (48,000 km) under
normal conditions. It should be
replaced every 15,000 miles (24,000
km) if you drive primarily in urban
areas that have high concentrations
of soot in the air f rom industry and
diesel-powered vehicles. Replace it
more of ten if air f low f rom the
climate control system becomes less
than usual. Have the dust and pollen
f ilter replaced by your Honda dealer.
Maint enance
Drive Belt
Dust and Pollen Filter
Dust and Pollen Filter, Drive Belt
189
C CO OM M P
PR
RE ES
SS SOOR R B
BEEL
LTT
0.30 0.41 in (7.5 10.5 mm)
0.33 0.43 in (8.5 11.0 mm)

Block the rear wheels.
Fill the f uel tank.
Change the engine oil and f ilter
(see page ).
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc. are
completely dry.
If you need to park your car f or an
extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your car back on the road. If
possible, store your car indoors.
If the car is to be stored for a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the car is being stored indoors).Coverthecarwitha‘‘breathable’’
cover, one made f rom a porous
material such as cotton.
Nonporous materials, such as
plastic sheeting, trap moisture,
which can damage the paint.
Disconnect the battery.
Support the f ront and rear wiper
blade arms with a f olded towel or
ragsotheydonottouchthe
windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and hatch seals. Also, apply a body
wax to the painted surf aces that
mate with the door and hatch seals. Drive your car every month f or
about 30 minutes. This will keep
the IMA battery charged and in
good condition.
If you store your car f or 12 months
or longer, have your Honda dealer
perf orm the inspections called f or in
the 24 months/30,000 miles (48,000
km) maintenance schedule (Normal
Conditions) as soon as you take it
out of storage (see page ). The
replacements called f or in the
maintenance schedule are not
needed unless the car has actually
reached that time or mileage.
Leave the parking brake off. Put
the transmission in Reverse (5-
speed manual) or Park (CVT). 167
156
Maint enance
St oring Your Car
204

Î
ÎThe United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page .
In Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured.
The burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase
Ventilation valve routes them fromthe crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
156
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
T echnical Inf ormation248

CONT INUED
.....................................
Load Limit .129
......
LOCK (Ignition Key Position) . 69
Locks ............................
Fuel Fill Door .119
............................................
Hatch .71
........................
Low Coolant Level .123
.........................
Low Fuel Indicator .58
...
Lower Gear, Downshif ting to a . 137
...
Lubricant Specif ications Chart . 243
.........................................
Luggage .128
..................................
Maintenance .151
...
Owner Maintenance Checks . 163
........................................
Record .161
......................
Required Indicator .59
..........................................
Saf ety .152
....................................
Schedule .154
.
Malf unction Indicator Lamp . 48,228
...................
Manual Transmission . 134
........
Manual Transmission Fluid . 178
...............................
Meters, Gauges .50
...................
Methanol in Gasoline . 246
..........................
Mirrors, Adjusting .78 ..................
New Vehicle Break-in . 118
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 240
...
Octane Requirement, Gasoline . 118
.........................................
Odometer .50
...............................
Odometer, Trip .51
Oil ........................
Change, How to .167
......................
Change, When to .156
......................
Checking Engine .122
Selecting Proper Viscosity ......................................
Chart .166
...........
ON (Ignition Key Position) . 70
Onboard Ref ueling Vapor ....................................
Recovery .248
.........................
Opening the Hatch .71
..
Operation in Foreign Countries . 247
..............................
Outside Mirrors .78
....................
Overheating, Engine .224
.......
Owner Maintenance Checks . 163
.........................
Oxygenated Fuels .246 ..............................
Paint Touch-up .208
..............
Panel Brightness Control . 62
...........................................
Parking .145
.................................
Parking Brake .79
Parking Brake and Brake .................
System Indicator . 46,230
..
Parking Over Things that Burn . 250
.............................
PGM-FI System .249
..................
Polishing and Waxing . 208
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 17
............................
Protecting Adults .12
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 17
........................
Protecting Children .19
.......
Protecting Larger Children . 29
.........
Protecting Small Children . 26
Using Child Seats with .....................................
Tethers .33
Index
M N
O
P
V

Î
Î...................
Radiator Overheating . 225
......
Radio/Cassette Sound System . 98
..
Rear Lights, Bulb Replacement . 201
............................
Rear View Mirror .79
.................
Rear Window Def ogger . 65
....................
Rear Window Washer .65
.......................
Rear Window Wiper .65
...............
Reclining the Seat Backs . 76
Replacement Inf ormation .................
Air Cleaner Element . 181
..........................
Engine Coolant .171
................
Engine Oil and Filter . 167
..........................................
Fuses .231
................................
Light Bulbs .198
....................................
Schedule .154
...................................
Drive Belt .189
...........................................
Tires .193
.............................
Wiper Blades .185
Replacing Seat Belts Af ter a ............................................
Crash .35
Reserve Tank, Engine ...............................
Coolant .123, 171
...............................
Restraint, Child .19
................................
Rotation, Tire .193 ..................................
Saf ety Belts .8, 34
.........
Safety Defects, Reporting . 256
.................................
Saf ety Features .7
...........................................
Airbags .9
..................................
Door Locks .10
..........................
Head Restraints .10
.......................................
Seat Belts .8
.....................
Seats & Seat-Backs .10
.............
Saf ety Labels, Location of . 41
...............................
Saf ety Messages . ii
.....................................
Seat Belts .8, 34
...............
Additional Information . 34
.....................................
Cleaning .209
......................
Lap/Shoulder Belt .34
................................
Maintenance .35
Reminder Light and ................................
Beeper .34, 46
...................
System Components . 34
...............
Use During Pregnancy . 17
...
Wearing a Lap/Shoulder Belt . 15
........................
Seats, Adjusting the .76
...............................
Serial Number .240
...........................
Service Intervals .154
...........................
Service Manual .257 .........
Service Station Procedures . 119
..........................
Setting the Clock .103
.....
Shif t Lever Position Indicator . 138
........................
Shif t Lock Release .142
...............................
Signaling Turns .63
.....................................
Snow Tires .195
...................
Solvent-type Cleaners . 207
..................................
Sound System .98
Spare Tire ......................................
Inf lating .214
............................
Specif ications .243
....................
Specif ications Charts . 242
...................................
Speedometer .50
..........
SRS, Additional Inf ormation . 36
...
Additional Safety Precautions . 39
How the SRS Indicator .......................................
Works .38
...........
How Your Airbags Work . 36
........................
SRS Components .36
..................................
SRS Service .39
.............................
SRS Indicator .34 ,46
....
START (Ignition Key Position) . 70
.......................
Starting the Engine .133
In Cold Weather at High ..................................
Altitude .133
................
With a Dead Battery . 222
Index
RS
VI