2002 CHEVROLET AVEO oil level

So, it is not a good idea to top off your brake fluid.
Adding brake fluid will not correct a leak. If you add fluid
when your linings are worn, then you will have too
much fluid when you get new brake linings. You should
add or remove brake fluid, as necessary, only when
work is done on the brake hydraulic system.
{CAUTION:
If you have too much brake uid, it can spill on
the engine. The uid will burn if the engine is
hot enough. You or others could be burned,
and your vehicle could be damaged. Add brake
uid only when work is done on the brake
and/or clutch hydraulic system.
When your brake fluid falls to a low level, your brake
warning light will come on. SeeBrake System Warning
Light on page 3-27.
What to Add
When you do need brake fluid, use only DOT-3 brake
fluid. Use new brake fluid from a sealed container
only. SeePart D: Recommended Fluids and Lubricants
on page 6-25.Always clean the brake fluid reservoir cap and the area
around the cap before removing it. This will help
keep dirt from entering the reservoir.
{CAUTION:
With the wrong kind of uid in your brake
system, your brakes may not work well, or they
may not even work at all. This could cause a
crash. Always use the proper brake uid.
Notice:
Using the wrong uid can badly damage brake
system parts. For example, just a few drops of
mineral-based oil, such as engine oil, in your
brake system can damage brake system parts so
badly that they will have to be replaced. Do not
let someone put in the wrong kind of uid.
If you spill brake uid on your vehicle’s painted
surfaces, the paint nish can be damaged. Be
careful not to spill brake uid on your vehicle. If
you do, wash it off immediately. SeeWashing
Your Vehicle on page 5-69.
5-33

Capacities and Specications
The following approximate capacities are given in English and metric conversions. SeePart D: Recommended Fluids
and Lubricants on page 6-25for more information.
ApplicationCapacities
English Metric
Air Conditioning Refrigerant R134a 1.48 lbs 0.67 kg
Cooling System 6.3 qt 6.0 L
Engine Oil with Filter 3.96 qt 3.75 L
Fuel Tank 11.9 gal 45.0 L
Transaxle, Automatic 6.2 qt 5.87 L
Transaxle, Manual 1.9 qt 1.8 L
Wheel Nut Torque 81 lb ft 110Y
All capacities are approximate. When adding, be sure to fill to the appropriate level, as recommended in this
manual. Recheck fluid level after filling.
Engine Specications
Engine VIN Code Transaxle Spark Plug Gap
1.6L L4 (L91) 6Automatic and
Manual0.039-0.043 inch (1.0-1.1 mm)
5-80

Maintenance Schedule
Introduction
Important: Keep engine oil at the proper level and
change as recommended.
Have you purchased the GM Protection Plan? The Plan
supplements your new vehicle warranties. See your
Warranty and Owner Assistance booklet or your dealer
for details.
Maintenance Requirements
Maintenance intervals, checks, inspections and
recommended fluids and lubricants as prescribed in this
manual are necessary to keep your vehicle in good
working condition. Any damage caused by failure
to follow scheduled maintenance may not be covered by
warranty.
Your Vehicle and the Environment
Proper vehicle maintenance not only helps to keep your
vehicle in good working condition, but also helps the
environment. Improper vehicle maintenance can
even affect the quality of the air we breathe. Improper
fluid levels or the wrong tire inflation can increase
the level of emissions from your vehicle. To help protect
our environment, and to keep your vehicle in good
condition, be sure to maintain your vehicle properly.
6-2

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals specified to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-13for further
details.
Engine Coolant Level Check
Check the engine coolant level and add the proper
coolant mixture if necessary. SeeEngine Coolant on
page 5-22for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the windshield
washer fluid reservoir and add the proper fluid if
necessary. SeeWindshield Washer Fluid on page 5-31
for further details.
At Least Once a Month
Tire Ination Check
Visually inspect your tires and make sure tires are
inflated to the correct pressures. Do not forget to check
your spare tire. SeeTires on page 5-45for further
details.
6-18

2005 ACCESSORIES & EQUIPMENT
Instrument Panel, Gages, & Console - Aveo
SPECIFICATIONS
FASTENER TIGHTENING SPECIFICATIONS
Fastener Tightening Specifications
BULB USAGE SPECIFICATIONS
Bulb Usage Specifications
Application
Specification
MetricEnglish
Chime Module Screws3.5 N.m31 lb in
Clock Screws2.5 N.m22 lb in
Cupholder Screws2.5 N.m22 lb in
Floor Console Screws4 N.m35 lb in
HVAC Controls Screws4 N.m35 lb in
Instrument Cluster Screws4 N.m35 lb in
Instrument Cluster Trim Panel Screws4 N.m35 lb in
Instrument Panel Bolts Behind the HVAC Controls4 N.m35 lb in
Instrument Panel End Bolts4 N.m35 lb in
Instrument Panel Bolts20 N.m15 lb ft
Indicator LampColorBulb
ABS WiringAmber14 V 1.4 W
Air Bag WarningRed14 V 1.4 W
Battery Charge IndicatorRed14 V 1.4 W
Check EngineAmber14 V 1.4 W
Door Open WarningRed14 V 1.4 W
Engine OverheatRed14 V 1.4 W
Fasten Seat Belt WarningRed14 V 1.4 W
High Beam IndicatorBlue14 V 1.4 W
Low Fuel Level WarningAmber14 V 1.4 W
Oil Pressure WarningRed14 V 1.4 W
Parking Brake Indicator and Brake
Fluid WarningRed14 V 1.4 W
Service Engine Soon WarningAmber14 V 1.4 W
Transaxle Power Mode IndicatorAmber14 V 1.4 W
Turn Signal IndictorsGreen14 V 1.4 W

2005 Chevrolet Aveo
2005 ACCESSORIES & EQUIPMENT Instrument Panel, Gages, & Console - Aveo

2005 Chevrolet Aveo
2005 ACCESSORIES & EQUIPMENT Instrument Panel, Gages, & Console - Aveo
Microsoft
Friday, July 31, 2009 1:07:02 PMPage 1 © 2005 Mitchell Repair Information Company, LLC.
Microsoft
Friday, July 31, 2009 1:07:07 PMPage 1 © 2005 Mitchell Repair Information Company, LLC.

Multifunction Alarm Module
Connector Part InformationKET MG 611336
26-Way F PCB Connector (WH)
PinWire ColorCircuit No.Function
1WH30Fuel Level Sensor Signal
2D-GN/WH817Vehicle Speed Signal
3WH121Engine Speed Signal
4WH135Engine Coolant Temperature (ECT) Sensor
Gauge Signal
5PU172Low Fuel Indicator Control
6BN33Brake Warning Indicator Control
7WH15Right Turn Signal Lamps Supply Voltage
8GY/D-GN11Headlamp High Beam Supply Voltage
9D-BU14Left Turn Signal Lamps Supply Voltage
10OG640Battery Positive Voltage
11PK239Ignition 1 Voltage
12BN/WH309Right Park Lamp Supply Voltage
13
BK450Ground (w/o Dimming)
L-GN/RD230Instrument Panel Lamps Dimming Control
(w/Dimming)
14BK450Ground
15-16--Not Used
17D-BU25Charge Indicator Control/Charge Indicator
Signal (w/o Tach)
18BN/BK419Malfunction Indicator Lamp (MIL) Control
(w/o Tach)
19D-G31Oil Pressure Indicator Control (w/o Tach)
20BK/WH238Seat Belt Switch - Driver (w/o Tach)
21WH629Daytime Running Lamp (DRL) On Indicator
Control (w/o Tach)
22L-BU122Rear Fog Lamp Supply Voltage (w/o Tach)
23D-GN/WH358Air Bag Indicator Control (w/o Tach)
24OG640Battery Positive Voltage (w/o Tach)
25D-GN/WH157Courtesy Lamp Control (w/o Tach)
26BK450Ground

2005 Chevrolet Aveo
2005 ACCESSORIES & EQUIPMENT Instrument Panel, Gages, & Console - Aveo
Microsoft
Friday, July 31, 2009 1:07:02 PMPage 11 © 2005 Mitchell Repair Information Company, LLC.