2002 BMW MOTORRAD R 1150 RS brake fluid

3
79
3
Starting – Riding – Parking
OEOptional extra
General
warning
lighte ABS warning
light
l/
brake failure Malfunctions
OFF ON Only RESIDUAL BRAKING FUNCTION available in both circuits (
b 75)
OFF Flashes at 1 Hz ABS not available Pull-away test not completed (
b 76)
OFF Flashes at 4 Hz Only RESIDUAL BRAKING FUNCTION available in both circuits (
b 75)
Self-diagnosis not completed (b 76)
ON OFF Tail light/brake light defective (
b Maintenance Instructions, Chapter 2)
ON Flashes at 1 Hz At least one brake circuit without ABS (
b 74)
ON Flashes at 4 Hz At least one brake circuit in RESIDUAL BRAKING FUNCTION mode (
b 75)
Alternate
flashing at
1Hz Alternate flash-
ing at 1 Hz
Fluid level in BMW Integral ABS too low.
Check the motorcycle as follows:
– Ignition OFF: is brake pressure OK at
the brake levers?
– Are the brakes acting on both wheels?
– Is the brake system leaktight, no signs of brake fluid escaping?
The brake system is defective if the test
outcome is negative.
Alternate
flashing at 4
Hz Alternate flas-
hing at 4 Hz
Fluid level in the BMW Integral ABS is too
low, perform the checks listed above.
Only RESIDUAL BRAKING FUNCTION
available in at least one circuit (
b 75)

d Warning:
Do not ride the motorcycle if you
have any doubts about the
dependability of the brake system.
BMW Integral ABSOE - Troubleshooting chart
10rsbkg2.book Seite 79 Dienstag, 19. November 2002 4:56 16

88
Index
i
AABS - anti-lock brake system, 74
Activating fast idle, 63
Adjusting headlight beam throw, 41
Adjusting knob for windshield, 6
Adjusting reach A/B, 15
Adjusting windshield, 10
Air filter, 5
Anti-lock brake system Notes, 72, 74, 75, 76, 77, 78,
79
Arrive safely, 80, 81
BBefore you start, 60, 61
BMW Integral ABS, 52 Brake fluid level, checking, 33
Changing brake fluid, 33
Troubleshooting chart, 79
BMW Service Card, 82
Brake booster, 74
Brake fluid
Changing, 30
Brake fluid level Checking, 30
Front brake, 31, 35
Rear brake, 32, 36
Brake pads, checking, 29
Brake pads, checking wear, 29 Brake system
General, 28, 29, 71
With BMW Integral ABS, 33,
34, 35, 36
Without BMW Integral ABS, 30,
31, 32
Brake system general, 29, 70
Brake system, checking, 28
Brake system, warnings, 70
CCapacity, 25
Catalytic converter, 53 Safety instructions, 53
Changing gear, 68, 69
Checking brake fluid level, 30
Checklist, 20, 21
Choke Cold start, 63
Cold-start lever, 12
Clock, 10
Clock (FID), 67
Closing the System case, 18
Clutch
Fluid level, 37
Clutch lever, 26
Cockpit Overview, 6
Cockpit instruments, 6
Cold-start lever (choke) How to use, 63
Position, 12
A - C
10rsbkg2.book Seite 88 Dienstag, 19. November 2002 4:56 16

89
Index
i
Concluding thoughts, 87
Cornering and braking need to be practised, 86
Correct loading, 48
DDipped beam headlight switch,
12
Dirt on brakes, 71
Downshifts, 69
EEmergency off (kill) switch for
ignition, 13
Engine oil, 22, 23 Filler neck, 4
Oil filler, 23
Temperature display (FID), 66
Engine oil pressure Indicator light, 64
Engine speed, 68
Environmental protection, 83
F
FID (Rider Information Display), 66, 67
First time out, 50, 51
Front brake Brake fluid level, 31, 35
Brake fluid reservoir, 5
Handbrake lever, 27
Front suspension, shock- absorber setting, 4
Fuel, 24, 25 Octane number, 25
Refuelling, 24
Fuel filler cap, 5
Fuel gauge (FID), 67
Fuel gauge 2, 67
Fuse box, 5
GGear indicator (FID), 67
General, 7
General view Left side, 4
Right side, 5
HHandlebar fittingLeft, 12
Right, 13
Handlebar levers, 26, 27 Clutch lever, 26
Handbrake lever, 27
Handlebars, adjusting, 14, 15
Handling your motorcycle safely, 50
Hazard warning flashers, 11
Headlight basic setting, 42
Headlight beam throw, adjusting, 40
Headlight, masking off, 39
Heated handlebar grips, 11, 13
Helmet holder, 4
Helmet holder, right, 5
High/low (dipped) beam headlight switch, 12
C - H
10rsbkg2.book Seite 89 Dienstag, 19. November 2002 4:56 16

90
Index
i
Horn button, 12
Hydraulic fluidClutch, 37
IIgnition key, 8
Ignition switch and steering lock, 6
Function, 8, 9
Ignition, switching on, 60, 61
Indicator lights Battery charge current, 65
Engine oil pressure, 64
Low fuel level, 64
Installing System case, 19
KKey positions, 9
Know how, 80
LLifting handle, 4
Lifting the motorcycle off the side stand, 55
Light switch, 13
Lights Adjusting headlight beam
throw, 40
H e a d l i g h t b e a m t h r o w , 3 8 , 3 9 ,
41
Notes, 38, 39
Lights, checking, 38
Load changes, 68
Loading, 47, 48, 49
MMain (centre) stand, 56, 57
Motorcycle equipment, 85
Moving away/upshifts, 69
NNeutral, 61
Neutral, selecting, 61
New brake pads, bedding in, 59
OOctane number (fuel), 25
Odometer, 6
Oil filler neck, 4, 23
Oil level Engine oil pressure, 7, 64
Warning light, 23
Oil level sight glass, 4
Oil level, checking, 22
Oil-free and grease-free brakes, 71
Opening the System case, 18
Overheating, risk of, 62
PPartially integral brakes, 74
Placing motorcycle on main (centre) stand, 56
Placing motorcycle on side stand, 54
Power socket, 12 V, 4
Pushing the motorcycle off the main (centre) stand, 57
H - P
10rsbkg2.book Seite 90 Dienstag, 19. November 2002 4:56 16

91
Index
i
QQuantity, 25
RRear brakesBrake fluid reservoir, 5
Rear suspension, shock-absorber setting, 4
Refuelling, 24
Removing System case, 19
Reservoir for clutch fluid, 4
Reset knob for trip meter, 6
Residual braking function, 34, 75
Revolution counter, 6
Rider Information Display, 66, 67 Clock, 67
Engine oil temperature display,
66
Fuel gauge, 67
Gear indicator, 67
Rider Information Display (FID), 6
Rider’s equipment, 84
Riding, 68
Riding and changing gear, 69
Risk of asphyxiation, 52
Risk of fatal accident, 53
Risk of fire, 52
Running in, 58, 59
Running-in speeds, 58
SSafety checklist, 20
Safety instructions Catalytic converter, 53
General, 52, 53
Salt on brakes, 70
Seat, 16
Seat lock, 5
Seat, adjusting, 17
Seat, removing, 16
Service, 81
Service worldwide, 82
Shock absorbers, 43
Shock-absorber settings, 43
Side stand, 54, 55
Sight glass for engine oil, 4
Spark plug, left, 4
Spark plug, right, 5
Speedometer, 6
Spring preload, 44 Front wheel, 44
Spring preload, adjusting, 44
Starter button, 13
Starting, 62, 63
Suspension strut, 4
System case, 18, 19
Q - S
10rsbkg2.book Seite 91 Dienstag, 19. November 2002 4:56 16