2002.5 Peugeot Boxer fuel cap

4YOUR BOXER AT A GLANCE
16-09-2002
THE KEYS The keys allow you to switch on the ignition and operate thepassenger air bag disarmingswitch as well as to independentlyoperate the locks on the frontdoors, the fuel filler cap and theglove box. Central locking
From the driver's door, the keys allow you to lock and unlock thefront, passenger and rear doors. If one of the doors is open, it is impossible to operate the centrallocking. The remote control performs the same functions at a distance.The remote control key Locking ➜
Press button Ato lock the
vehicle. This is confirmed by fixed lighting of the direction indi-cators for approximately twoseconds.
Unlocking Press button Bto unlock the
vehicle. This is confirmed by rapid flashing of the direction indicators. STARTING
STOP position:
the ignition is off. 1st notch, MAR (Accessories) position:
the ignition is off but
the accessories can be used. A VV (Starting) position:
Operates the starter.P ARK position:
position enabling you to leave the side lights on when parked,
with the ignition off and the keyremoved.
11 3

OPENING THE BONNET Inside the vehicle: Push the
control on the right-hand side, under the instrument panel. Outside the vehicle: lift the control, raise thebonnet and secure thestrut to keep the bonnetopen.
FILLING WITH FUEL This operation must be carried out with the
engine switched off.
➜ Open the fuel filler flap by pressing the front of it.
➜ Insert the key then turn it to the left.
➜ Remove the cap and hook it onto the hook on the inside of the flap.
An indication on the cap shows which type of fuel to use.
When you fill your tank, do not continue after the third cut-off of the
pump. This could cause a malfunction. The capacity of the tank is approximately 70 litres. ➜ After filling the tank, lock the cap and close the flap.
Low fuel level warning light
From the time this light comes on, you have approxima-
tely 8 litres of fuel left.
YOUR BOXER AT A GLANCE14
120120
16-09-2002

16-09-2002
PEUGEOT SERVICING27
A, B AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
: All driving conditions: Arduous conditions * According to country.
1st Level
Operations Description of operation serviceAB C Intermediate
DRAIN/REFILL- Engine oil - Bleed fuel filter (diesel) - Oil filter - Fuel filter* (petrol)REPLACE- Fuel filter element (diesel)- Air filter element- Spark plugs (petrol)- Engine oil (check + top-up) - Manual gearbox oil (check + top-up) - Battery (check + top-up) if cap is removable LEVEL- Screen wash (check + top-up)- Coolant (check + top-up) - Brake fluid (check + top-up) - Power steering fluid (check + top up according to specification) - Operation of lights and indicators - Condition of glass, headlamp and light lenses and mirrors - Horn - Windscreen washer jets - Condition of wiper blades - Condition and tension of the ancillary drive belts - Handbrake and clutch - Condition of hydraulic circuits (hoses and covers) CHECK- Condition of rubber boots and gaiters - Brake pads - Play in hubs, link rods, ball joints, flexible mountings- Shock absorbers- Rear drum brake lining wear- Condition and pressure of tyres (including spare wheel) - Emission control check as per current legislation (petrol) - Smoke opacity (diesel) - Pollen filter (according to specification) - Visual check of the whole vehicle
SERVICE*- Courtesy vehicle
ROAD TEST

16-09-2002
YOUR BOXER IN DETAIL113
THE KEYS The keys allow you to switch on the ignition and operate the passengerair bag disarming switch as well as toindependently operate the locks onthe front doors, the fuel filler cap andthe glove box. Unfolding the key Button
1unfolds the ley from the remo-
te control casing.
To re-fold the key, press button 1and
fold the key into the remote control casing. Central locking
From the driver's door, the keys allow you to lock and unlock the front doors,the side door (Minibus) and the reardoors. If one of the front doors is open, the central locking does not work. The remote control performs the same functions at a distance. The remote control Locking Press button
Ato lock the vehicle.
This is confirmed by fixed lighting of the direction indicators for approxi-mately two seconds. Unlocking Press button Bto unlock the vehicle.
This is confirmed by rapid flashing of the direction indicators. Locating your car
To
locate your car, if you have locked
it, in a car park: ☞ press button A. The courtesy
lights come on and the direction indicators flash for a fewseconds.

16-09-2002
OPENING THE BONNET From inside: pull the handle on the
right-hand side under the fascia. From outside: lift the catch Aand
raise the bonnet. Bonnet strut Secure the strut to hold the bonnet open. Before closing the bonnet, replace the strut in its housing.
To
close
Lower the bonnet and release it at the end of its travel. Check that thebonnet is properly locked. FILLING WITH FUEL Low fuel level
When the minimum fuel level in the tank is reached, thiswarning light comes on. You can have approxima-
tely 8 litres of fuel left.
The engine must be switched off when filling with fuel. ☞
Open the fuel filler flap by pres-sing the front of it.
☞ Insert the key then turn it to theleft.
☞ Remove the cap and hang it onthe hook located on the inside ofthe flap.
An indication on the cap reminds youwhich type of fuel to use. When you fill your tank, do not conti-
nue after the third cut-off of the
pump. This could cause your vehicleto malfunction. The capacity of the tank is approximately 70 litres. ☞ After filling the tank, lock the cap and close the fuel filler flap.
The key cannot be removed from thelock until the cap has been replacedon the fuel tank.
YOUR BOXER IN DETAIL
120

16-09-2002
TECHNICAL DATA
160
Manual
(5-speed)
PETROL ENGINES
ENGINES
2 litre injection
Cubic capacity (cm 3
) 1998
Bore x stroke (mm) Maximum power 80
EU standard (kW)Maximum power at engine 5 500
speed (rpm)Maximum torque EU standard (Nm) 1 6 8
Maximum torque at engine 3 400
speed (rpm) Fuel Unleadedb
OIL CAPACITY (in litres)Engine (with cartridge replacement) 4 . 7 5
Gearbox-Final drive
MODELS: Model codes GEARBOX

16-09-2002
TECHNICAL DATA161
Manual
Manual
(5-speed) (5-speed) DIESEL ENGINES
ENGINES 2 litre Turbo HDI 2.2 litre Turbo HDI Cubic capacity (cm
3
)1 997 2 178
Bore x stroke (mm)
Maximum power
EU standard (kW) 64 74
Maximum power at engine speed (rpm) 4 0004 000
Maximum torque EU standard (Nm) 1 9 5 2 4 0
Maximum torque at engine 1 900 1 900
speed (rpm) Fuel DieselDiesel
OIL CAPACITY (in litres)
Engine (with cartridge replacement) 5 . 3 5 . 3
Gearbox-FInal drive
MODELS: Model codes GEARBOX

16-09-2002
TECHNICAL DATA
162
Manual Automatic Manual
(5-speed) (4-speed) (5-speed) DIESEL ENGINES
ENGINES 2.8 litre Turbo HDI 2.8 litre Turbo TED Cubic capacity (cm
3
)2 798 2 798
Bore x stroke (mm)
Maximum power
EU standard (kW) 93.5 90
Maximum power at engine speed (rpm) 3 6003 600
Maximum torque EU standard (Nm) 3 0 0 2 8 5
Maximum torque at engine speed (rpm) 1 8001 800
Fuel DieselDiesel
OIL CAPACITY (in litres)
Engine (with cartridge replacement) 7 7
Gearbox-Final drive
MODELS: Model codes GEARBOX