2002.5 Peugeot 307 Break air filter

09-09-2002
Zero reset
Your PEUGEOT dealer carries out
this operation after each service.
However, if you carry out the service
yourself, the reset procedure is as
follows: Switch off the ignition,
Press and hold the trip recorder
reset button,
Switch on the ignition.
The display begins a countdown.
When the display shows 0, release
the button; the service symbol disap
pears.
Important: after this operation, if you
wish to disconnect the battery, lock
the vehicle and wait for at least five
minutes, otherwise the zero reset
will not be registered. MAINTENANCE OF PARTS SUBJECT TO WEAR and a check of
consumables
Certain essential components on your vehicle are subject to checks a
t specific
frequencies:
The brake fluid is to be replaced at a maximum of every 36,000/40,000 miles
(60 000 km) or every two years.
The pollen filter must be checked at each serviceby a PEUGEOT dealer
(services and intermediate visits) or more often, depending on the environ
ment (dust, pollution, etc.)
Replacement of the timing belt: consult a PEUGOT dealer.
For the 2 litre HDI turbo diesel engine (110 bhp) , maintenance of the partic
ulate emission filter and topping up of the additive reservoirmust be carried
out at a maximum of every 48,000 miles (80 000 km) , by a PEUGEOT deal
er.
Air bags and pretensioning parts on seat belts must be checked every
10 years.
The check on tyre inflation pressure must be carried out cold at least once a
month.
PEUGEOT SERVICING 21

09-09-2002
Arduous conditions of use
• Continuous doortodoor use.
• Town use (e.g. taxi).
• Repeated short journeys, with the engine cold at low te mperatures.
• A prolonged stay under the following conditions: – countries with temperatures often above +30 °C,
– countries with temperatures often below –15 °C,
– countries with a dusty atmosphere,
– countries whose lubricants or fuels do not conform to our recommen dations.
Recommendations:
– replace the air filterevery 24,000 miles (40 000 km) for petrol engines and every 27,000 miles (45 000 km) for diesel
engines,
– for replacement of the timing belt: contact a PEUGEOT dealer.
PEUGEOT SERVICING
24

09-09-2002
PEUGEOT SERVICING25
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st Service
A C Intermediate
DRAIN/REFILL Engine oil Bleed fuel filter (diesel) Oil filter Fuel filter *(petrol)REPLACE Fuel filter element (diesel) Air filter element Spark plugs (petrol) Engine oil (check + topup) Manual gearbox oil (check + topup) Battery (check + topup) if cap is removableLevel Screen wash (check + topup) Coolant (check + topup) Brake fluid (check + topup) Power steering fluid (check + top up according to specification) Operation of lights and indicators Condition of glass, headlamp and light lenses and mirrors Horn Windscreen washer jets Condition of wiper blades Condition and tension of the ancillary drive belts Handbrake Condition of hydraulic circuits (hoses and covers)CHECK Condition of rubber boots and gaiters Brake pads Play in hubs, link rods, ball joints, flexible mountings Shock absorbers Rear drum brake lining wear. Condition and pressure of tyres (including spare wheel) Emission control check as per current legislation (petrol) Smoke opacity (diesel) Pollen filter (according to specification) Visual check of the whole vehicle
SERVICE* Courtesy vehicle
ROAD TEST
: All driving conditions: Arduous conditions * According to country.

09-09-2002
1 Rev counter.
2 Seat belt not fastened warning
light.
3 Engine diagnostics warning
light.
4 Handbrake and low brake fluid
level warning light.
5 Lefthand direction indicator.
6 Coolant temperature indicator. 7
Battery charge warning light.
8 Central (STOP) warning light.
9 Engine oil pressure warning
light.
10 Low fuel level warning light.
11 Righthand direction indicator.
12 Fuel gauge.
13 ABS warning light. 14
Air bag warning light.indicator
light.
16 Speedometer.
17 Service indicator, oil level and
total distance recorder.
18 Trip recorder zero reset.
19 Rear fog lamp indicator light.
20 ESP/ASR warning light
21 Front fog lamps indicator
light.
22 Diesel engine preheating light.
23 Main beam headlamps
indicator light.
24 Low coolant level warning light.
25 Dipped beam headlamps
indicator light.
26 Water in diesel filter warning
light.
27 Lighting rheostat.
INSTRUMENTS AND CONTROLS
28
PETROL / DIESEL INSTRUMENT PANEL DIALS: MANUAL GEARBOX

09-09-2002
YOUR 307 IN DETAIL83
VENTILATION
1 . Windscreen deicing or demisting vents.
2 . Front window deicing or demisting vents.
3 . Side vents.
4 . Centre vents.
5 . outlet to front footwells.
6 . Air outlet to rear footwells.
Advice on operation Place the air flow control at a level sufficient to ensure a good renewal of air in the passenger compartment.
The ''OFF'' position cuts off all the air circulation in the passenger comp artment.
Note: only use the ''OFF'' position occasionally (risk of condensation).
For perfectly even air distribution, take care not to obstruct th e exterior air intake grilles, the vents and the air ducts under
the front seats, as well as the air extractor located in the b oot. Check that the pollen filter is in good condition.

1.4 LITRE PETROL ENGINE
1 Power steering reservoir.
2 Windscreen wash reservoir.
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box. 7
Air filter.
8 Dipstick.
9 Engine oil filler cap.
PRACTICAL INFORMATION 135
09-09-2002

09-09-2002
PRACTICAL INFORMATION
136
1
Power steering reservoir
2 Windscreen wash reservoir
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box. 7
Air filter.
8 Dipstick.
9 Engine oil filler cap.
1.6 LITRE 16V PETROL ENGINE

09-09-2002
PRACTICAL INFORMATION137
1
Power steering reservoir.
2 Windscreen wash reservoir.
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box. 7
Air filter.
8 Dipstick.
9 Engine oil filler cap.
2 LITRE 16V PETROL ENGINE