2001 SUBARU LEGACY overheating

ii
How to use this owner
’s manual
Using your Owner ’s manual
Before you op erate your vehic le, c arefully read thi s manual. To p rotec t
yourself and extend the servic e life of your vehic l e, follow the instruc tions
in this manual. Failure to ob serve these instruc tio ns may result in serious
injury and d amag e to your vehic le.
This manual is c omp osed of fourteen c hap ters. Eac h c hap ter b eg ins
with a b rief tab le of c ontents, so you c an usually tell at a g lanc e if that
c hap ter c ontains the information you want. Chapter 1: Seat, seatbelt and SRS airbags
This c hap ter informs you how to use the seat and se atb elt and c ontains
p rec autions for the SRS airb ag s.Chapter 2: Keys and doors
This c hap ter informs you how to op erate the keys, l oc ks and wind ows.
Chapter 3: Instruments and controls
This c hap ter informs you ab out the op eration of ins trument p anel ind ic a-
tors and how to use the instruments and other switc hes.
Chapter 4: Climate control
This c hap ter informs you how to op erate the c limate c ontrol.
Chapter 5: Audio
This c hap ter informs you how to op erate your aud io system.
Chapter 6: Interior equipment
This c hap ter informs you how to op erate interior eq uip ment.
Chapter 7: Starting and operating
This c hap ter informs you how to start and op erate y our SUBARU.
Chapter 8: Driving tips
This c hap ter informs you how to d rive your SUBARU i n various c ond i-
tions and exp lains some safety tip s on d riving .Chapter 9: In case of emergency
This c hap ter informs you what to d o if you have a p rob lem while d riving ,
suc h as a flat tire or eng ine overheating .Chapter 10: Appearance care
This c hap ter informs you how to keep your SUBARU lo oking g ood .

14-4Eng ine c omp artment overview
11-7
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Eng ine c oolant 11-15
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Eng ine exhaust g as (Carb on monoxid e) 8-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Eng ine hood 11-5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Eng ine oil 11-9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Eng ine overheating 9-14
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior c are 10-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
F
Fastening the seatb elt 1-18
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flat tires 9-4
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Floor mat (if eq uip p ed ) 6-14
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fog lig ht switc h (if eq uip p ed ) 3-24
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fold ing d own the rear seat — Station wag on 1-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front d ifferential g ear oil (AT vehic les) 11-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front fog lig ht (if eq uip p ed ) 11-53
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front seatb elt p retensioners 1-28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front seats 1-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front turn sig nal lig ht, p arking lig ht and marker l ig ht 11-53. . . . . . . . . . . . . . . . . . .
Front-wheel d rive warning lig ht (for AT vehic les) 3- 17
. . . . . . . . . . . . . . . . . . . . . . . . .
Fuel 7-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel ec onomy hints 8-3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel filler lid and c ap 7-4
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel g aug e 3-9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel req uirements 7-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse p anel loc ated b ehind the c oin tray 12-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse p anel loc ated in the eng ine c omp artment 12-10 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses 11-46
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses and c irc uits 12-6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
G
Glove c omp artment 6-5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GVWR and GAWR (Gross Vehic le Weig ht Rating and Gross Axle Weig ht Rating ) 8-19. . .

3-24Fog light switch (if equipped)
The fog lig hts op erate only when the head lig hts are
on low b eam. Push
the fog lig ht switc h to turn the fog lig hts on.
Press the switc h ag ain to turn them off.
HB2025BB
The ind ic ator lig ht loc ated on the switc h will illu minate when the fog
lig hts are on.
Wiper and washer
WARNING
In freezing weather, do not use the windshield washer until the
windshield is sufficiently warmed by the defroster.Otherwise the washer fluid can freeze on the windshield, blocking
your view.
CAUTION
Do not operate the washer continuously for more than ten se-
conds, or when the washer fluid tank is empty. This may cause
overheating of the washer motor. Check the washer fluid level fre-
quently, such as at fuel stops.

Interior equipment6-9
–
CONTINUED –
Cigarette lighter (if equipped)
CAUTION
The electrical power socket located on the lower part of the instrument panel is designed to use only a SUBARU genuine cig-arette lighter plug. Do not use non-genuine cigarette lighter plugsor any “plug-in” type electrical accessories in the socket. Doing
so may cause a short-circuit and overheating, resulting in a fire.
HB6011BA
The elec tric al p ower soc ket loc ated on the lower p a rt of the instrument
p anel c an only b e used as c ig arette lig hter soc ket. A c ig arette lig hter
p lug is an op tional ac c essory. It is availab le from your SUBARU d ealer.
If smoking is not d esired , always p ut the c ap on th e soc ket to p revent
any foreig n ob jec t from entering it.
Cigarette lighter (if equipped)
WARNING
To avoid being burned, never grasp the lighter by the end with the heating element. Doing so could result in injury and couldalso damage the heating element.
CAUTION
Do not hold the lighter pushed in, because it will overheat.

6-12
HB7008BA
HB6018BA
Elec tric al p ower (12V DC) from the b attery is on ta p at the soc ket
when the ig nition switc h is either in the “ACC ” or “ON ” p osition.
You c an use an in-c ar use elec tric al ap p lianc e b y c onnec ting it to the
soc ket. Electrical power socket located on the lower part of the instru- ment panel
CAUTION
The electrical power socket located on the lower part of theinstrument panel is designed to use only a SUBARU genuine cig-arette lighter plug. Do not use non-genuine cigarette lighter plugsor any “plug-in” type electrical accessories in the socket. Doing
so may cause a short-circuit and overheating, resulting in a fire.Refer to the “Cigarette lighter ” section in this chapter.
Convenience hook Coat hook CAUTION
Never hang anything on the coat hook that might obstruct the
driver’ s view or that could cause injury in sudden stops or in a
collision. And do not hang items on the coat hook that weigh 2.2lb (1 kg) or more.

Starting and operating7-21
–
CONTINUED –
NOTE Right after the engine has been started and before it has warmed up, you may hear a noise coming from areas adjacent to the powersteering pump which is located at the right-front area of the enginecompartment. This noise is normal. It does not indicate power steer-ing system trouble. Braking
Braking tips
WARNING
Never rest your foot on the brake pedal while driving. This can
cause dangerous overheating of the brakes and needless wearon the brake pads and linings.
When the brakes get wet
When d riving in rain or after washing the vehic le, the b rakes may g et
wet. As a result, b rake stop p ing d istanc e will b e l ong er. To d ry the
b rakes, d rive the vehic le at a safe sp eed while lig htly d ep ressing the
b rake p ed al to heat up the b rakes. Use of engine braking
Rememb er to make use of eng ine b raking in ad d ition to foot b raking .
When d esc end ing a g rad e, if only the foot b rake is used , the b rakes
may start working imp rop erly b ec ause of b rake fluid overheating ,
c aused b y overheated b rake p ad s. To help p revent th is, shift into a
lower g ear to g et strong er eng ine b raking . Braking when a tire is punctured
Do not d ep ress the b rake p ed al sud d enly when a tire is p unc tured .
This c ould c ause a loss of c ontrol of the vehic le. Keep d riving straig ht
ahead while g rad ually red uc ing sp eed . Then slowly p ull off the road
to a safe p lac e.

Driving tips8-39
–
CONTINUED –
nearest SUBARU d ealer. n
Driving on grades
Before g oing d own a steep hill, slow d own and shift into lower g ear
(if nec essary, use 1st g ear) in ord er to utilize th e eng ine b raking effec t
and p revent overheating of your vehic le ’s b rakes. Do not make sud -
d en d ownshifts. When d riving up hill in hot weather, the air c ond iti oner may turn off
automatic ally to p rotec t the eng ine from overheatin g .
When d riving up hill in hot weather, p ay attention t o the water tem-
p erature g aug e p ointer (for all vehic les) and AT OI L TEMP warning
lig ht (for AT vehic les) sinc e the eng ine and transm ission are relatively
p rone to overheating und er these c ond itions. If the water temp erature
g aug e p ointer ap p roac hes the OVERHEAT zone or the A T OIL TEMP
warning lig ht illuminates, immed iately switc h off t he air c ond itioner
and stop the vehic le at the nearest safe p lac e. Ref er to the “Eng ine
overheat ” sec tion in c hap ter 9, and “Warning and ind ic ator lig hts ”
sec tion in c hap ter 3. If your vehic le has a automatic transmission, avoid using the ac c el-
erator p ed al to stay stationary on an up hill slop e instead of using the
p arking b rake or foot b rake. That may c ause the tra nsmission fluid to
overheat. Also, if your vehic le is eq uip p ed with an automatic transmis-
sion, avoid d riving with the g ear selec tor lever in “ D ” when towing a
heavy trailer to p revent fluid overheating . n Parking on a grade
Always b loc k the wheels und er b oth vehic le and trai ler when p arking .
Ap p ly the p arking b rake firmly. You should not p ark on a hill or slop e.
But if p arking on a hill or slop e c annot b e avoid ed , you should take
the following step s:
1. Ap p ly the b rakes and hold the p ed al d own.
2. Have someone p lac e wheel b loc ks und er b oth the ve hic le and
trailer wheels.
3. When the wheel b loc ks are in p lac e, release the r eg ular b rakes
slowly until the b loc ks ab sorb the load .
4. Ap p ly the reg ular b rakes and then ap p ly the p arki ng b rake; slowly
release the reg ular b rakes.

9
In case of emergency
If you park your vehicle in an emergency 9-2. . . . . . . . . . . . . . . . . . . . . . . .
Temporary spare tire 9-3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flat tires 9-4
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 9-11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 9-14
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Towing 9-15
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moonroof — if the moonroof cannot be closed 9-25 . . . . . . . . . . . . . . . .
Maintenance tools 9-26
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jack and jack handle 9-27
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .