2001 SUBARU FORESTER overheating

ii
How to use this owner
’s manual
Using your Owner ’s manual
Before you op erate your vehic le, c arefully read thi s manual. To p rotec t
yourself and extend the servic e life of your vehic l e, follow the instruc tions
in this manual. Failure to ob serve these instruc tio ns may result in serious
injury and d amag e to your vehic le.
This manual is c omp osed of thirteen c hap ters. Eac h c hap ter b eg ins with
a b rief tab le of c ontents, so you c an usually tell at a g lanc e if that c hap -
ter c ontains the information you want. Chapter 1: Seat, seatbelt and SRS airbag
This c hap ter informs you how to use the seat and se atb elt and c ontains
p rec autions for the SRS airb ag .Chapter 2: Doors and Locks
This c hap ter informs you how to op erate the keys, l oc ks and wind ows.
Chapter 3: Instruments and controls
This c hap ter informs you ab out the op eration of ins trument p anel ind ic a-
tors and how to use the instruments and other switc hes.
Chapter 4: Climate control
This c hap ter informs you how to op erate the c limate c ontrol.
Chapter 5: Audio
This c hap ter informs you how to op erate your aud io system.
Chapter 6: Interior equipment
This c hap ter informs you how to op erate interior eq uip ment.
Chapter 7: Starting and operating
This c hap ter informs you how to start and op erate y our SUBARU.
Chapter 8: Driving tips
This c hap ter informs you how to d rive your SUBARU i n various c ond i-
tions and exp lains some safety tip s on d riving .Chapter 9: In case of emergency
This c hap ter informs you what to d o if you have a p rob lem while d riving ,
suc h as a flat tire or eng ine overheating .Chapter 10: Appearance care
This c hap ter informs you how to keep your SUBARU lo oking g ood .
Chapter 11: Maintenance and service

3-20Fog light switch (if equipped)
The fog lights operate only when the headlights are on low beam.
Push the fog light switch to turn the fog lights on.
Press the switch again to turn them off.
HB2025BB
The indicator light located on the switch will illuminate when the fog
lights are on.
Wiper and washer
WARNING
In freezing weather, do not use the windshield washer until the
windshield is sufficiently warmed by the defroster.Otherwise the washer fluid can freeze on the windshield, blocking
your view.
CAUTION
Do not operate the washer continuously for more than ten se-
conds, or when the washer fluid tank is empty. This may cause
overheating of the washer motor. Check the washer fluid level fre-
quently, such as at fuel stops.

6-8c onsole. To use the c up hold er, op en the lid b y p ul
ling its up p er ed g e.
Clock
HS0103
The c loc k d isp lays the time when the ig nition switc h is in the “ACC ” or
“ ON ” p ositions.
Setting the clock
To set the hour, p ress the “H ” b utton. To set the minutes, p ress the “M ”
b utton. To reset the minutes to “00 ” with a rad io time sig nal, p ush the
“ S ” b utton.
Accessory power socket Electrical power socket located on the left-lower part of the instrument panel CAUTION
The electrical power socket located on the lower part of the instrument panel is designed to use only a SUBARU genuine cig-arette lighter plug. Do not use non-genuine cigarette lighter plugsor any “plug-in” type electrical accessories in the socket. Doing
so many cause a short-circuit and overheating, resulting in a fire.Refer to the “Cigarette lighter ” section in this chapter.

Interior equipment6-11
–
CONTINUED –
Cigarette lighter (if equipped)
CAUTION
The electrical power socket located on the lower part of the instrument panel is designed to use only a SUBARU genuine cig-arette lighter plug. Do not use non-genuine cigarette lighter plugsor any “plug-in” type electrical accessories in the socket. Doing
so may cause a short-circuit and overheating, resulting in a fire.
HS0378
The elec tric al p ower soc ket loc ated on the lower p a rt of the instrument
p anel c an only b e used as c ig arette lig hter soc ket. A c ig arette lig hter
p lug is an op tional ac c essory. It is availab le from your SUBARU d ealer.
If smoking is not d esired , always p ut the c ap on th e soc ket to p revent
any foreig n ob jec t from entering it.
Cigarette lighter (if equipped)
WARNING
To avoid being burned, never grasp the lighter by the end with the heating element. Doing so could result in injury and couldalso damage the heating element.

7-22Braking
Braking tips
WARNING
Never rest your foot on the brake pedal while driving. This can
cause dangerous overheating of the brakes and needless wearon the brake pads and linings.
When the brakes get wet
When d riving in rain, in p ud d le or after washing th e vehic le, the
b rakes may g et wet. As a result, b rake stop p ing d is tanc e will b e long -
er. To d ry the b rakes, d rive the vehic le at a safe sp eed while lig htly
d ep ressing the b rake p ed al to heat up the b rakes. Use of engine braking
Rememb er to make use of eng ine b raking in ad d ition to foot b raking .
When d esc end ing a g rad e, if only the foot b rake is used , the b rakes
may start working imp rop erly b ec ause of b rake fluid overheating ,
c aused b y overheated b rake p ad s. To help p revent th is, shift into a
lower g ear. Braking when a tire is punctured
Do not d ep ress the b rake p ed al sud d enly when a tire is p unc tured .
This c ould c ause a loss of c ontrol of the vehic le. Keep d riving straig ht
ahead while g rad ually red uc ing sp eed . Then slowly p ull off the road
to a safe p lac e.
Brake system Two separate circuits
Your vehic le has two sep arate c irc uit b rake systems . Eac h c irc uit
works d iag onally ac ross the vehic le. If one c irc uit of the b rake system
should fail, the other half of the system still wor ks. If one c irc uit fails,
the b rake p ed al will g oes d own muc h c loser to the f loor than usual
and you will need to p ress it d own muc h hard er. And a muc h long er
d istanc e will b e need ed to stop the vehic le.

8-32
OM-H2791
If the ABS warning lig ht illuminates while the vehi c le is in motion,
stop towing the trailer and have rep airs p erformed immed iately b y the
nearest SUBARU d ealer. n Driving on grades
Before g oing d own a steep hill, slow d own and shift into low g ear
in ord er to utilize the eng ine b raking effec t and p revent overheating of
your vehic le ’s b rakes. Do not make sud d en d ownshifts.
When d riving up hill in hot weather, the air c ond iti oner may turn off
automatic ally to p rotec t the eng ine from overheatin g .
When d riving up hill in hot weather, p ay attention t o the water tem-
p erature g aug e need le (for all vehic les) and ATF OI L TEMP warning
lig ht (for AT vehic les) sinc e the eng ine and transm ission are relatively
p rone to overheating und er these c ond itions. If the water temp erature
g aug e need le ap p roac hes the OVERHEAT zone or the AT F OIL TEMP
warning lig ht illuminates, immed iately switc h off t he air c ond itioner
and stop the vehic le at the nearest safe p lac e. Ref er to “Eng ine over-
heat ” sec tion (c hap ter 9), and “Warning and ind ic ator lig hts ” sec tion
(c hap ter 3) in the owner ’s manual.
If your vehic le has a automatic transmission, avoid using the ac c el-
erator p ed al to stay stationary on an up hill slop e instead of using the
p arking b rake or foot b rake. That may c ause the tra nsmission fluid to
overheat. Also, if your vehic le is eq uip p ed with an automatic transmis-
sion, avoid d riving with the g ear selec tor lever in “ D ” when towing a
heavy trailer to p revent fluid overheating .

9
In case of emergency Hazard warning flasher9-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flat tires 9-2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 9-8
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 9-10
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Towing 9-11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moonroof – if the moonroof cannot be closed 9-15 . . . . . . . . . . . . . . . . . .
Maintenance tools 9-16
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire changing tools 9-16
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

9-10Make sure that the c ab les are not near any moving p
arts and that
the c ab le c lamp s are not in c ontac t with any other metal.
5. Start the eng ine of the vehic le with the b ooster b attery and run it at
mod erate sp eed . Then start the eng ine of the vehic l e that has the d is-
c harg ed b attery.
6. When finished , c arefully d isc onnec t the c ab les in exac tly the re-
verse ord er.
Engine overheating
WARNING
Never attempt to remove the radiator cap until the engine hasbeen shut off and has fully cooled down. When the engine is hot,the coolant is under pressure. Removing the cap while the engineis still hot could release a spray of boiling hot coolant, which
could burn you very seriously.
If the eng ine overheats, safely p ull off the road a nd stop the vehic le in a
safe p lac e.
If steam is coming from the engine compartment
Turn the eng ine off and g et everyone away from the vehic le until it
c ools d own. If no steam is coming from the engine compartment
1. Keep the eng ine running at id ling sp eed .
2. Op en the hood to ventilate the eng ine c omp artment .
Confirm that the c ooling fan is turning . If the fan is not turning , im-
med iately turn the eng ine off and c ontac t your auth orized d ealer for
rep air.
3. After the eng ine c oolant temp erature has d rop p ed , turn off the en-
g ine.
If the temp erature g aug e stays at the overheated zo ne, turn the en-
g ine off.
4. After the eng ine has fully c ooled d own, c hec k the c oolant level in