2001 Mercury Sable trunk

If your vehicle is a sedan, the fuel
pump shut-off switch is located on
the right side of the trunk behind
the trunk liner.
If your vehicle is a wagon, the fuel
pump shut-off switch is located
behind the service panel on the
right side of the cargo area.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
Roadside emergencies
137

²In the sedan, these are located in
the trunk cargo area storage
compartment.
²In the wagon, they are stored in
the left side rear trim panel for
the temporary spare and in the
floor cargo area storage
compartment for the full size
spare.
3. If equipped with a wheel cover
that's bolted on, loosen the five
plastic nuts with the lug nut
wrench.
4. Remove the center ornament or wheel cover from the wheel with the
tapered end of the wheel lug nut wrench that came with your vehicle.
Insert and twist the handle, then pry against the wheel.
Roadside emergencies
145

5. Carefully pull bulb straight out of
the socket and push in the new
bulb.
6. Install the bulb socket into the
lamp assembly by rotating it
clockwise.
7. Carefully position the headlamp
assembly onto the vehicle.
8. Hold the headlamp assembly
snugly against the vehicle and install
the retainer pins straight down to lock the lamp into place.
9. Before reinstalling the bolt, make sure the retainer pins are fully
seated, and install bolt on headlamp housing.
10. Turn the headlamps on and make sure they work properly. If the
headlamp was correctly aligned before you changed the bulb, you should
not need to align it again.
Replacing high-mount brakelamp bulbs Ð Sedan only
²TYPE A
1. Open trunk and locate the
insulator under the rear window.
Maintenance and care
196

Replacing license plate lamp bulbs
Wagon
1. Remove screw and the license
plate lamp assembly from liftgate.
2. Remove bulb socket by turning
counterclockwise.
3. Carefully pull the bulb out from
the socket and push in the new
bulb.
4. Install the lamp assembly on
liftgate with screw.
Sedan
1. Remove two screws, grommets
and the license plate lamp assembly
from the trunk lid.
2. Carefully pull the bulb from the
socket and push in the new bulb.
3. Install the lamp assembly on
trunk lid with two grommets,
ensuring the grommets are pushed
all the way in to the trunk lid and
secure with two screws.
Maintenance and care
199

Replacing tail/brake/turn signal/backup lamp bulbs
Sedan
The tail lamp, brake lamp, turn
signal lamp and backup lamp bulbs
are located in the same portion of
the tail lamp assembly. Follow the
same steps to replace either bulb.
1. Open trunk and remove two
plastic mushroom nuts, three push
pins and the plastic cover from
inside the trunk to access the lamp
assembly.
2. Carefully pull the carpet away to
expose the lamp assembly hardware.
3. Remove four nut and washer
assemblies and the lamp assembly
from the vehicle.
4. Remove the bulb socket by
rotating it counterclockwise, then
pulling it out of the lamp assembly.
5. Pull the bulb from the socket and
push in the new bulb.
6. Install the bulb socket into the
lamp assembly by rotating it
clockwise.
7. Install the lamp assembly on the
vehicle with four nut and washer
assemblies ensuring the washers on the nuts are flush with the body to
prevent water from entering the trunk.
8. Carefully push the carpet back in to place and install the plastic cover
inside the trunk with three push pins and two plastic mushroom nuts.
Maintenance and care
200

Fluid Ford Part
NameApplication Capacity
Windshield
washer fluid -
RearUltra-Clear
Windshield
Washer
ConcentrateWagon 1.8L (60.9 oz.)
1Use Ford Premium Engine Coolant (green in color). DO NOT USE Ford
Extended Life Engine Coolant (orange in color). Refer toAdding engine
coolant, in the Maintenance and Care chapter.
LUBRICANT SPECIFICATIONS
ItemsFord Part
Name or
equivalentFord Part
NumberFord
Specification
Brake fluid High
Performance
DOT 3 Motor
Vehicle Brake
FluidC6AZ-19542-AB ESA-M6C25-A
and DOT 3
Door latch, hood
latch, auxiliary
hood latch, seat
tracks, trunk
and liftgate
latchesMulti-Purpose
GreaseDOAZ-19584-AA
or
F5AZ-19G209-AAESA-M1C93-B
or
ESR-M1C159-A
Lock cylinders Penetrating and
Lock LubricantMotorcraft XL-1 none
Automatic
transaxle (AX4S
and 4F50N)Motorcraft
MERCONtV
AT FXT-5-QM
MERCONtV
Engine oil Motorcraft SAE
5W-20 Super
Premium Motor
OilXO-5W20-QSP WSS-M2C153-H
and API
Certification
Mark
Constant
velocity jointsCV Joint Grease
(High Temp.)E43Z-19590-A ESP-M1C207-A
Capacities and specifications
212

GAWR ......................................128
GVWR ......................................128
trailer towing ..........................128
Locks
autolock .....................................71
childproof ..................................57
Lubricant specifications ...212±213
Lumbar support, seats ...............79
M
Mirrors .........................................54
cleaning ...................................206
heated ........................................58
side view mirrors (power) .......58
Moon roof ....................................54
Motorcraft parts ................186, 210
O
Octane rating ............................185
Odometer .....................................15
Oil (see Engine oil) ..................157
Overdrive ...................................124
P
Panic alarm feature, remote
entry system ................................65
Parking brake ............................120
Parts (see Motorcraft parts) ....210
Pedals (see Power
adjustable foot pedals) ...............46
Power adjustable foot pedals .....46
Power distribution box
(see Fuses) ...............................141Power door locks ........................57
Power steering ..........................122
fluid, checking and adding ....167
fluid, refill capacity ................211
fluid, specifications .........212±213
R
Radio ............................................29
Relays ................................138, 143
Remote entry system ...........63, 65
illuminated entry ......................65
locking/unlocking doors ...........64
opening the trunk .....................64
panic alarm ...............................65
replacement/additional
transmitters ...............................65
replacing the batteries .............66
Roof rack ...................................134
S
Safety belts (see Safety
restraints) ............13, 81, 83±87, 89
Safety defects, reporting ..........230
Safety restraints ..............81, 83±90
belt minder ...............................92
cleaning the safety belts ..95, 209
extension assembly ..................91
for adults .............................84±87
for children .....................103±104
lap belt ......................................89
warning light
and chime ........................9, 13, 92
Safety seats for children ..........105
Seat belts
(see Safety restraints) ...............81
Seats ............................................77
Index
235

child safety seats ....................105
cleaning ...........................208±209
SecuriLock passive
anti-theft system ...................73, 75
Servicing your vehicle ..............153
Spark plugs,
specifications .....................210, 213
Specification chart,
lubricants ...........................212±213
Speed control ..............................47
Speedometer ...............................14
Starting your vehicle ........113, 115
jump starting ..........................147
Steering wheel
tilting .........................................52
T
Tachometer .................................14
Tires ...........................143, 178±180
changing ..........................143±144
checking the pressure ............180
replacing ..................................181
rotating ....................................180
snow tires and chains ............181
tire grades ...............................179
treadwear ................................179
Towing .......................................130
recreational towing .................133
trailer towing ..........................130
wrecker ....................................152
Traction control ..................46, 121
active light ..................................8
Transaxle
automatic operation ...............123
fluid, refill capacities ..............211lubricant specifications ..........213
Transmission
fluid, checking and adding
(automatic) .............................168
lubricant specifications ..........212
Trip odometer .............................15
Trunk .........................61, 63±64, 76
remote release ..........................60
Turn signal ..............................8, 50
V
Vehicle dimensions ...................213
Vehicle Identification
Number (VIN) ...........................216
Vehicle loading ..........................128
Ventilating your vehicle ...........117
W
Warning chimes ...........................13
Warning lights (see Lights) .........8
Washer fluid ..............................161
Water, Driving through .............129
Windows
power .........................................56
rear wiper/washer .....................51
Windshield washer fluid and
wipers
checking and adding fluid .....161
checking and cleaning ....177±178
liftgate reservoir .....................162
operation ...................................50
replacing wiper blades ...........178
Wrecker towing .........................152
Index
236