2000 HONDA CIVIC oxygen

Ground-to-Components I ndex
f.,lONOTE: All ground wires are BLK unless otherwise noted.
GroundPageComponents or Circuit Grounded
Battery (BLKYEL)
Steering pump bracket
t+-rg ITransmission housing
l
G101
(-1)
G101
(-2)
14-2
and
14-3
ano
14-1
Powertrain or engine control module (PG1 and pG2 are BLK: LG1 and LG2 are
BRN/BLK), EGR control solenoid valve (CW, EGR valve and lift sensor (Dt6yS enginewith M,/T), Engine coolant temperature switch, pGM-Fl main relay, power steeringpressure switch (USA), Primary HO2S (D16Y5 engine with l\/,/T), Vehicle speed sensor,VTEC pressure switch (D16Y5/D16Y8 engines), CKF sensor (BRN/BLK), Transmission
control module (CYf) (Pc1 is BLK: LG1 is BRN/BLK)
Shielding betvveen the PCM or ECM and these components (all have BRN/BLK wires):
CKF sensor, TDC/CKP/CYP sensor. Primary and secondary heated oxygen sensors.
Knock sensor (CWDl6YB engine), Mainshaft speed sensor (AiT except CVT),
I Countershaft speed sensor (A/T except CVf)
Shielding between the TCM and these components (CVT) (all have BRN/BLK wires):
Drive pulley speed sensor, Driven pulley speed sensor, Secondary gear shaft
speed sensor
Powertrain or engine control module (PG1 and pG2 are BLK; LG1 and LGz are
BRN/BLK), EGR control solenoid valve (D16Y5 engine), EGR valve (Dt685), Engine
coolant temperature switch, Fuel pressure regulator shut-off solenoid valve (D1685),
PGM-FI main relay, Power steering pressure switch (USA), Vehicle speed sensor, VTECpressure switch (All except D16Y7 engine), CKF sensor (A

except 81642) (BRN/BLK)
Shielding between the PCM or ECM and these components (all have BRN/BLK wires):
CKF sensor, TDC/CKP/CYP sensor, Primary and secondary heated oxygen sensors,
Knock sensor (All except D16Y7 engine), i/ainshaft speed sensor (Arf except CW),
Countershaft speed sensor (A,/T except CVf), Drive pulley speed sensor (CW), Drivenpulley speed sensor (CVT), Secondary gear shaft speed sensor (CVf)
I Badiator fan motor, Right front parking/turn signat tight, Right headtight
G20214-4I Cruise control actuator, Left front parking/turn signal lights, Left headlight, Rear window
I washer motor, Windshield washer motor, Washer fluid level switch (,99-'00 Canada)
G401| +-o
and
14-7
Accessory power socket, Brake fluid level switch, Clutch interlock switch (M/T), Clutchswitch (lillT with cruise/D16Y5 engine with MfD, Combination wiper switch (Z wires),
Cruise control main switch, Cruise control unit, Dash lights brightness controller, Data
link connector, Daytime running lights control unit (Canada), Gauge assembly, Horn('96-'97 models), Integrated control unit, Interlock control unit (ArI), Keyless door lock
control unit ('99-'00 models with keyless), Moonroof close and open relays, Moonroof
switch, Park pin switch (A/r), Power window relay, Rear window defogger relay, Rear
window defogger switch ('96-'98 models), Steering lock, Stereo radio tuner (,96-,98
USA: LX, EX, and HX), Turn signal/hazard relay, Windshield wiper motor.....plus
everything grounded through G402
6-6

Ground Distribution
- Gl01 (All '96-'98 models except D1685; '99100 D16y5 with M/T)
NOTE: Wires shown without color codes
:--- CVr --' D16y5/
i rnlts_ ' ._ 016y8,MISSION',englnes
: CONTROL ' PGM.FI :: MODULE i UAIH ; VTEC, TTCM) ; RELAY . PRESSURE' Paae 39-5 ' Paoe 23 ' SWITCHI pHdro et ' n 6roao ' Page 23-4I vtEw 69 | vtEw 1a ' pHoro 44' r---.t ' r-1 I i-r
POWERTRAIN orENGINE CONTROLMODULE (PCM or ECM)Page 23-3PHATO 86vlEw 7a; r---1 ;r-1 , r, I t,t | ,l
: I t:t | :l, L---J, L-J ' L-, A26Y A13Y , 3,2
i T T: I I
I I, I t,,-I T T: T i
: I t:--I-. :
i I \li:; -4, ;!-------------l-i '
'lF;% :21 ,vlEw 28 ;
_ - t\4/T -
PRIMARYHEATEDOXYGENSENSOR(H02S)Page 23-13
ll
tl
"i[",..
14
o---1\
I

PGM-FI (All '9e'98 Models except D1685; '99-'00 D16YS with M/T)
- D16Y8 Engine
I
I
-t---"",t ;
ii hffi- i ffis* #""r, i"[' | (PTAN6 , gCC2l fips)'L-------4-----
i -:l i ,,,rt[
"'[ D2
lllHd,..--"ffi[il
iffi;',::l-l' anv ll '97 model: allCoubes, I' au I calitornia Sedan I
i n":, *t,*%,nof
'o0"" "",
lf1 fr3::fj* |
:"*iu,.'o ' lJ l;'F#F. I
id[fr?4;" i
'[ i
i +l L'i':----i ---I- - - - - -::'
iko,*o* [U!3v'0" I
rrar) ' lniczdt I
6i?----i''-v------J
BEO/^YEL
sensor nput(ECo
NTsensol lnpdlnqrr
BA /BLK).l
.a
II
t
k
PRIMARYHEATEDOXYGENSENSOR(H02S)
c123
cr23PHOTO 42
_1
ALX
ALK
-i
INTAKEAIRTEMPER.ATUREOAT)SENSORPHOTO 15
E33"ln'*' l-1-l
g.:;'$;lfj
H
t
,{
LT GA
2
GNN/BLK
8!(7YEL
c 5(Terml-nala8n4)
vtEw 38
GRN/BIK
Dll
BLI(AVHT
a ' sSfl, *SffT3,. {
I grourd heater'clntrot r\
t!IL------- -------
23-10

FED/YEL! il'Jlilli:Distribulon,
i
!aa
il-
"""r"a^ Itl
+9,1:1o,,,
Fromnext page.FI
t
H
INTAKE '
AIR ;TEMPER. .ATURE(rAr)SENSOR 'PHO|O 4s i 4
BRN/BLK
c123PHO|O 40vlEw 19c123
PRIMARYHEATEDOXYGENSENSOR(HO2S)
PRIMARYHEATEDOXYGENSENSOR(H02S)
-- -.-g c123,7 ,t1":.," I :: ' t---o} "",'"?",vtEw 19ErKl i:: ll [ .________i
leggtqe"d! ll:: I | :Distribution. I I ,; ll ll :
ffi31i1'1 ! lii i l:i ioty I er-rcrwr | :
:i*-! ! i
:i ! ! i
-a-- Glol:i I I :"uu,
--------t; igul,.[l :g.ili'""'"t i
11TI i
#?:?.'A6tr
i
F -tt-*i - I - - - -(-Po"GFil PowERTRAIN
i sdltGr i irimari' ' I oR ENGINE
! ;il;n i nciis' 'lcortnor
hear.r 'l MODULE| , haat.. .tMvuuLE
I ; ;;ii;r i | (PcM oR EcM)
I | ------riPHOfOS6L ------ - ------J vtae al
(cont'd)
. I OR ENGINE' HOzS Primary i CONTROLI fruzs Fflmary a c(JNIHor Label VS celt Dumo HOzS' ' , primary | MOOULE
i l"dqanc6 vohags Befe{ence bell . heater i : !-1029 | (p-Q!/| OB: red$snce voltag€ Beftrence c€ll heater ' : HOzS | (PCM OB: insJt input voltage control control ; ; inpul I ECM), (rABELt Ms+) tlP-.vs-) (rp+) (Po2sHrc) ; , l"Y_ j r;!J?.*----i---
i
-l "*
I'*l*'l
*l
i iillirlr I
:L+.1 l----,. (_l_.o-l
: I annar-x | :
: I I see Grourd
23-13

PGM-FI (All '99-'q) Models except D16Y5 with M/T and D1685) (cont'd)
- Dl6Y7 Engine
ct6
(
k
GRN
GRN/ALK
II
)
-l.a
FUELTANKPRES-SURESENSOR(See S/M1
BLK
GFN/BLK
GNN/BLK
6
GAN/8LX
8
GFiI/BIK
tis3 :INTAKEAIRTEMPER-ATURE(|AT)SENSOR
PRIMARYHEATEDOXYGENSENSOR(HO2S)
c'123
c123
cs68PHOTO 103
c401
vtEw 40
ct31
vlEvt S9
FffiflH
{
r,Bi".'#
H
r{
t
f 5:o#'""'"n
rtrt
BLK
at
It
lFueltan* TP \lpr€asura Rg{grsncs ssnsor ECT IAT Primary IF€nsor inpJt voltago input sensor input sensor inpul HO2S inout I| (rt^xn Naca Crpsr lscn - -- 1-ran -- -(p,ioi3i-- ,L------- -----J
BLKT^YEL
clt5(Ierminals 8-14)
vlEw38
contaol
24-8

PGM-FI (All '9S"00 Models except D16Y5 with M/T and D1685) (cont'd)
- Dl6Y8/816A2 Engines
c123PHO|O 133
)
t
II
r
k
'l
ir
c27
3 crsoI (Termlnals
ll 18-20)
li#?t?,"
It
ll
I ".r,".*ll
lt
ll
I
lt
lL___3
H'I
t
I
I
I Rrol tankipressure Fobrsnco: ssnsot inDul volt4€| (Pr^No 0ccaL-- --- - -*'I
:*I-.
;iH$ffi1
l-Flitii!
lJri li::#'":l
"oil ??$j
"rt
*tinr+- l+-
*'.,9s,g';,, f
-:i*<'lrp !
-I$"";*", o"",".,. I"rnLi':______I
ALK
INTAKEAIRTEMPER.ATURE(rAr)SENSORPHO|O 15
PRIMARYHEATEDOXYGENSENSOR(H02S)PHOTO 13iF}$iH
:{
F#-H
{
c123PHOTO 133
LT GFII
2
ORN/ALX
c1r5(Iermlnalr8-14)PHOfO 16
I
I
I
I
24-10

PGM-FI (Dl685) (cont'd)
\'(
UNDER-DASHFUSE/RELAYBOXPHOTO 58
POWERTRAIN T
PrimaryHO2SInput(PHO25)
Secondary
input
CONTROLMODULE(PcM)PHO|O A6vlEW 70
S€s PowerDistribution,p6gs 1&5.
i (PHozst (sHo?srL-------
I
I
J,
Lti
J,
-'!
!
t
!
"l
See GroundDistuibution,pago 14-2.
G101PHOfO 33
i'tj I
:li
Sea PowerDislibution,pag€'1G5.
c't23
c123
PRIMARYHEATEDOXYGENSENSOR(HO2S)
c125
c125
SECONDARYHEATEDOXYGENSENSOR(HO2S)
(1
BLK
BLK
2
GFN/ALK
HOzS' HO2S
POWERTRAINCONTROL MODULE(PcM)
n€aterconlrolhgatercontrolI
25-8

Connector ldentification and Wire Harness Routing
Connector
or
Terminal
Number ol
Cavities/
Color
LocationConnects toNotes
Main Wire Harness (Left side of dash and floor branch): '96-'97 models
c401
c402
c403
c404
c405
c406
c407
c407
c408
c409
c410
c411
c412
c413
c414
c415
c416
c417
c418
c419
c420
c421
c422
w+4J
c424
c425
c427
c428
c429
c430
c431
c432
c433
c434
lJ+OC
c437
v+.to
c439
14-GRY
4-ORN
4-NAT
14-GRY
4-NAT
8-GRY
2-GRY
2-GRY
1-BRN
1O-WHT
12-GRY
24-BLU
3-YEL
16-GRY
4.BLU
7-BRN
6.NAT
2-N/A
2-YEL
18-GRN
2O.GRN
18-GRN
7-GRN
6-GRN
4-NAT
4-WHT
8.WHT
6-WHT
4-NAT
7-NAT
3-GRY
8-GRY
4.GRY
14-GRY
2-GRY
4-GRY
26-GRY
22-GRY
1-GRN
Behind left kick panel
Behind left kick panel
Under left side ot dash
Under left side of dash
Under left side of dash
Under left side of dash
Under lett side ot dash
Under left side of dash
Under left side of dash
Behind under-dash fuse/relay box
Above under-dash fuse/relay box
Above under-dash fuse/relay box
Above under-dash fuse/relay box
Under left side of dash
Under left side of dash
Above under-dash fuse/relay box
Under left side of dash
Under left side of dash
Under left side of dash
Behind under-dash fuse/relay box
Behind under-dash fuse/relay box
Behind under-dash fuse/relay box
Front of under-dash iuse/relay box
Front of under-dash fuse/relay box
Under left side of dash
Under left side of dash
Behind steering column cover
Behind steering column cover
Behind steering column cover
Behind steering column cover
Under left side of dash
Under lett side ot dash
Below front console
Below front console
Below front console
Below front console
Behind lett kick panel
Behind left kick panel
Behind under-dash fuse/relay box
Floor wire harness
Floor wire harness
Light flasher relay connector(Security)
Cruise control unit
DRL control unit connector A
DRL control unit connector B
Roof wire harness
Moonroof wire harness
Front fog light connector
Integrated control unit
Dashboard wire harness
Dashboard wire harness
SRS main harness
Data link connector
Starter cut relay
lgnition switch
Security starter cut relay conneclor
Clutch switch
Clutch interlock switch
Under-dash fuse/relay box
Underdash fuse/relay box
Under-dash fuse/relay box
Under-dash fuse/relay box
Underdash fuse/relay box
Horn relay
Brake switch
Combination wiper switch
connector A
Combination wiper switch
connector B
Combination light swilch
connector A
Combination light switch
connector B
Cable reel
lnterlock control unit
Secondary heated oxygen sensor
sub-narness
A,/T gear position switch
Shift lock solenoid
Park pin switch and A,/T gear
position console light
TCM connector A
TCM connector B
Under-dash luse/relay box
ABS
Optional
Canada
Canada-2
'4
Optional
AtT
M/T
Optional'5
M/T
Atl
'6
AN
AN
Atf
CVT
CVT
G401Left kick panelBody ground, via main wire
harness
.2: Without moonroof .5: M/T (with cruise control or for D16Y5 engine)"4: With moonroof .6: With secondary heated oxygen sensor (HO2S)
203-20