1999 YAMAHA YZF-R7 oil level

8 - 21
–+ELECSIGNALING SYSTEM
EB806000
SIGNALING SYSTEM
CIRCUIT DIAGRAM
B
(BLACK) (DARK GRAY)
(BLACK)B
L
B
L
K
WWW
86
7RR
Br
BBRR
L/W BrL/W
RR
R
B
B
BBB
B
R
WWW(BLACK)
L/W
B
R/B
R/L
G/B
R/L
L/W
B (BLUE)
Gy
Gy/B
B
B(BLUE)
Gy
B
Br
G
L/R
B
Br
G L/R
B
Br/W
Br
B
B
B
B
L/WBr
R/W
G/Y R/W
B/WB/L(GRAY)
(BROWN)
h
Br
YB
BBr
Y (BROWN) (BROWN)
R/YLBr/WP
B(BLUE) (BLUE)(BLACK) (BLACK)
Br
BBR/WR/B
Y
P
ON OFF
R
RL/R
LBr/L
B
R/L
G/W(BLACK)
R/L R/BR/G L/R(GREEN)
(BLACK) (BLACK)(BLACK)(BLACK)
O Gy
B
Br/G
B Br
L/G W/G
Y/G
BYL
B
B
G
Ch Dg
BL/W
L/R
R/BB/Y
L/YSb
R/L R/B
Br/WB1G/W B/L
L/Y
W
B/L
W/B L/YB/L
W/YL/Y
L/Y
Br L
R
Br/LR
Br/L
L/W
L/Y
Br
L/W
L/Y L/B
L L/R
B L/Y
L/R LB B BB
W
WW
W
WW
B
BB
B
B B1
B
BB
B
B
B/YL/Y
B/YL/Y
R/Y
L P
B Br/WDg
ChB/YYG
L/Y
Ch
B/YDg
G
L/YY
B
R
G
B/L
YLWBYPBL
GBB/W
(BLACK)YB
BCh
(BLACK)BDg
B
(GRAY)(BLACK)
(BLACK)
(BLACK) (GRAY)
(GRAY)
(GRAY)
(GRAY) (GRAY)B/W B/L
B/L B/L
W/LP/B Y/L
R
B
PASS
(BLACK)
(BLACK)ChB
(BLACK)DgB
N
B(BLACK)B
(BLACK) (BLACK)
O/G B(BLACK) (BLACK)
L
R/L G/B
M
R/L L/B
N
R/LR/L O/B
OY
Y/R C YG/R C GBr/R C BrGy/R C Gy
R R/LRRRRY
P
RG G(BROWN)
Q
RBr Br
Gy(DARK GRAY)R(GRAY)
R
R/YLg/Y
R/Y Lg/Y R/WB/L
R/Y
R
Y/L
B
L/R
YL/R
Gy/B
Gy
G/WB1
W/Y
W1
L/R B/L
YLW/B
Y/L W/L
P/W P/LR/Y
Br/W R/W
Lg/YL/W B/W
R/L
R/B L/WW G
Lg
L/R L/BSb
B/Y B B/R L/Y
RBR
R/G
4
BL/Y
BB
Br/L
BrBrL
B
B
B
B
BR/GB1
B
Y
B
R/WR/B
R/GR/BL/RR/L
Br
G/WR/L
L/YW/BB/L
GyGy/B
R/L
L/R
L/W
B/LL
B
Br/W
Br
Y
LPWP
B2
B2
R PB
(BLACK)
B3
B3W2
Y/G L/GBr/G Br/R
Gy/R
BrBrO/B
G/Y L/B G/B G/R
Y/R
W/G Y/B R/B
O/B
R/L
L/B
GyO
O Lg/R
B
B
B
BB Gy
Gy/G Gy/G Gy/G
O/G O/GO/G
Gy GyGy/G
Br/G
W/G
Y/G
L/G
Br
WW/YB/L
L/Y
Lg/RG/Y W/YY/B
L/YBSb
Sb
R/GG/WWYChL
W
BrP
P G Y Ch Dg B
Dg
B
BBBB
B
Dg
ChBr
LR/Y
L/Y B/Y
Br/LBr/LBr/L
BrR/YR/W
B2
Gy
Gy/BB3
R/B
G/B
L/B
O/B
Gy/R
Lg/RY/R
G/R
Br/R
R/W
R/Y
Lg/Y
W1
W2
(BLACK)
(BLACK)
(BLACK)
(BLACK) (GRAY)
B
L
B
B/L
Br/W
B/LG/W
S
T
U
V W J
Z
R/G
B L/Y
W/YG/Y W Y/B
Br
G/WLg/R Lg Y
ChDg
L
gf f e dc b a` ] \[ FE DC
I
G
H
X
j k
l
m
n
op
i w
v u

t s
r qBA@Br9 5 3 2
1
Œ

 
£¢ ¤
¥
¦xy

(BLACK)
Y
L/W
Y/B
G/Y
Y/L
W/L
P/BR
B3 W/B
B/L
L
Y
P/W
P/L
Br
G/W
B/W
W/Y
Br
B2
|
~
z } {
L/Y
A
A
A
A
AA
AAAA
A C
A
A
A
A A
A
P/LP/W
BB/L BB/L
DL DL
C
W/LP/B
WIRE HARNESS SUB LEAD
B/L B/L
BB
R/L R/L L
R/L R/L L
LRR
LR
R(GRAY)
(GRAY)
WIRE HARNESS SUB LEADY/R
Br/RP/W
G/R Gy/R P/L
WYBr
PG
Gy(BLACK)
(BLACK)
WIRE HARNESS SUB LEAD HEADLIGHT AND METER SUB-WIRE HARNESS
(BLACK)
(BLACK)
WIRE HARNESS
Y W/Y G/WG/W
R/G L G/Y Dg
Br
GY
G L/YW/Y
L/Y BBr
B W Y/B Lg Lg/RCh L/R
L/R
G/Y
R/GDg
L
Lg/R
Lg
W
Y/B ChA
BC
D
D R/L D R/L D R/L D
R
B1
Br/G
W/G
Y/G
L/G
Br
L/R
1Main switch
5Battery
6Main fuse
0Relay unit
ZNeutral switch
\Fuel level indicator light
]Warning light (oil level indicator)
^Neutral indicator light
aTachometer
bCombination meter
eTurn signal indicator light
hOil level switch
iHorn
kRear turn signal light (right)
lRear turn signal light (left)
mFront turn signal light (right)
nFront turn signal light (left)
oTail/brake light
pRear brake light switch
vTurn signal switch
wHorn switch
xTurn signal relay
yFuel pump (thermistor)
|Front brake light switch
 Signaling system fuse

8 - 22
–+ELECSIGNALING SYSTEM
TROUBLE SHOOTING
• Any of the following fail to light: turn signal light, brake light or an indicator light.
• The horn fails to sound.
Check the main and signal system fuses
continuity.
Check the condition of the battery.
Check the main switch.
Check the entire signaling system’s wiring.
Check the bulbs and
bulb sockets.
Check the LED’s of
the indicator light.
Check the brake
switchs.
Replace the meter
assembly.
Check the neutral
switch.
Replace the meter
assembly. Check the relay unit.
Check the continuity of the thermistor in the fuel pump.OK
OK
OK
OK
OK
OK
OK
OK
OK
OKNo good
No good
No good
No goodReplace.
Replace.
Replace.
Replace.
Replace.
Replace.
Replace.Recharge or replace.
Recharge or replace.
No goodNo good
No good
No good
No good
No good
No good
No good No good
No good OK
OK
BAD
OK Check the horn switch.
Check the horn. Replace.
Replace. Check the turn signal
switch.
Replace the turn
signal relay.
Replace the meter
assembly.
Replace the meter
assembly.
Replace the meter
assembly.Check the oil level
switch.
Replace the fuel
pump. Replace the left
handlebar switch.
Replace the
left handlebar
switch.

8 - 23
–+ELECSIGNALING SYSTEM
NOTE:
• Before troubleshooting, remove the following part(-s):
1) fuel tank
2) bottom cowling
3) front cowling
4) rear cowling
• Troubleshoot with the following special tool(-s).
Pocket tester
90890-03112
CHECKING THE RELAY UNIT
• Remove the relay unit from the coupler.
• Connect the pocket tester (W ´ 1) to the
relay unit terminals as shown.
• Check the starting circuit cutoff relay for
continuity.
NOTE:
When you switch the tester’s positive and
negative probes, the readings in the above
chart will be reversed.
• Are the tester readings correct?
Yes ® Good.
No ® Replace.
CHECKING THE OIL LEVEL SWITCH
• Drain the engine oil.
• Remove the oil level switch.
• Connect the pocket tester (W ´ 1) to the oil
level switch connector as shown.
• Check the oil level switch for continuity as
follows.
• Are the oil level switch readings correct?
Yes ® Good.
No ® Replace. Tester positive probe ®
sky blue 1
Tester negative probe ®
blue/red 2Continu-
ity
Tester positive probe ®
blue/red 2
Tester negative probe ®
sky blue 1No conti-
nuity
Tester positive probe ® white 1
Tester negative probe ® ground
Oil level switch float posi-
tion is upper .Continu-
ity
Oil level switch float posi-
tion is lower õ.No conti-
nuity
R/B L/WW G
Lg
L/R L/BSbB/Y B B/R L/Y
1 2
W
W
õ
11

YZF-R7 WIRING DIAGRAM
1
Main switch

2
Rectifier/regulator

3
Generator

4
Backup fuse (odometer)

5
Battery

6
Main fuse

7
Starter relay

8
Starter motor

9
Diode

0
Relay unit

A
Diode

B
Sidestand switch

C
Camshaft sensor

D
Throttle position sensor

E
Intake air pressure sensor

F
Atmospheric pressure sensor

G
Intake air temperature sensor

H
Coolant temperature sensor

I
Pickup coil

J
ECU

K
Cylinder #1 - injector 1

L
Cylinder #2 - injector 1

M
Cylinder #3 - injector 1

N
Cylinder #4 - injector 1

O
Cylinder #1 - injector 2

P
Cylinder #2 - injector 2

Q
Cylinder #3 - injector 2

R
Cylinder #4 - injector 2

S
Cylinder #1 - ignition coil

T
Cylinder #2 - ignition coil

U
Cylinder #3 - ignition coil

V
Cylinder #4 - ignition coil

W
CDI unit

X
Fall detection switch

Y
Speed sensor

Z
Neutral switch

[
Meter assembly

\
Fuel level indicator light

]
Warning light (oil level indicator)

^
Neutral indicator light

a
Tachometer

b
Combination meter

c
Warning light (coolant temperature indicator)
d
High beam indicator light
e
Turn signal indicator light
f
Meter light
gWarning light (engine trouble indicator)
hOil level switch
i
Horn
jHeadlight
kRear turn signal light (right)
lRear turn signal light (left)
mFront turn signal light (right)
nFront turn signal light (left)
oTail/brake light
pRear brake light switch
q
Left handlebar switch
rClutch switch
sLights switch
t
Pass switch
uDimmer switch
vTurn signal switch
wHorn switch
xTurn signal relay
yFuel pump
zMain relay
{
Right handlebar switch|Front brake light switch
}Engine stop switch
~Start switch
Œ
Electronic fuel injection system fuseCYCLELOCK Signaling system fuse
¢Headlight fuse£
ECU fuse¤Radiator fan motor fuse
¥Thermo switch
¦Radiator fan motor
COLOR CODE
B ............ black
Br ........... brown
Ch .......... chocolate
Dg .......... dark green
G ............ green
Gy .......... gray
L ............ blue
Lg .......... light green
O ............ orange
P ............ pink
R ............ red
Sb .......... sky blue
W ........... white
Y ............ yellow
B/L ......... black/blue
B/R ......... black/red
B/W ....... black/white
B/Y ......... black/yellow
Br/G ....... brown/green
Br/L ........ brown/blue
Br/R ....... brown/red
Br/W ...... brown/white
G/B ........ green/black
G/R ........ green/red
G/W ....... green/white
G/Y ........ green/yellow
Gy/B ...... gray/black
Gy/G ...... gray/green
Gy/R ...... gray/red
L/B ......... blue/black
L/G ......... blue/green
L/R ......... blue/red
L/W ........ blue/white
L/Y ......... blue/yellow
Lg/R ....... light green/red
Lg/Y ....... light green/yellow
O/B ........ orange/black
O/G ........ orange/green
P/B ......... pink/black
P/L ......... pink/blue
P/W ........ pink/white
R/B ......... red/black
R/G ........ red/green
R/L ......... red/blue
R/W ....... red/white
R/Y ......... red/yellow
W/B ....... white/black
W/G ....... white/green
W/L ........ white/blue
W/Y ....... white/yellow
Y/B ......... yellow/black
Y/G ........ yellow/green
Y/L ......... yellow/blue
Y/R ......... yellow/rod