7 - 41
CHASFRONT AND REAR BRAKES
ACHTUNG:CAUTION:
Brake fluid may damage painted sur-
faces and plastic parts. Therefore,
always clean up any spilt brake fluid
immediately.
4. Bleed:
• brake system
Refer to “BLEEDING THE HYDRAULIC
BRAKE SYSTEM” in chapter 3.
5. Check:
• brake fluid level
Below the minimum level mark a ®
Add the recommended brake fluid to
the proper level.
Refer to “CHECKING THE BRAKE
FLUID LEVEL” in chapter 3.
6. Check:
• brake lever operation
Soft or spongy feeling ® Bleed the
brake system.
Refer to “BLEEDING THE HYDRAULIC
BRAKE SYSTEM” in chapter 3.
EB702290
ASSEMBLING THE REAR BRAKE MASTER
CYLINDER
1. Install:
• copper washers
• brake hoses
• union bolt
WARNINGWARNING
Proper brake hose routing is essential to
insure safe motorcycle operation. Refer
to “CABLE ROUTING”.
ACHTUNG:CAUTION:
When installing the brake hose onto the
brake master cylinder, make sure that
the brake pipe touches the projection a
as shown.
aa
New
T R..30 Nm (3.0 m · kg, 22 ft · lb)
7 - 42
CHASFRONT AND REAR BRAKES
2. Fill:
• brake fluid reservoir
WARNINGWARNING
• Use only the designated brake fluid.
Other brake fluids may cause the rub-
ber seals to deteriorate, causing leak-
age and poor brake performance.
• Refill with the same type of brake fluid
that is already in the system. Mixing
brake fluids may result in a harmful
chemical reaction, leading to poor
brake performance.
• When refilling, be careful that water
does not enter the reservoir. Water
will significantly lower the boiling
point of the brake fluid and could
cause vapor lock.
ACHTUNG:CAUTION:
Brake fluid may damage painted sur-
faces and plastic parts. Therefore,
always clean up any spilt brake fluid
immediately.
3. Bleed:
• brake system
Refer to “BLEEDING THE HYDRAULIC
BRAKE SYSTEM” in chapter 3.
Recommended brake fluid
DOT 4
4. Check:
• brake fluid level
Below the minimum level mark a ®
Add the recommended brake fluid to
the proper level.
Refer to “CHECKING THE BRAKE
FLUID LEVEL” in chapter 3.
5. Adjust:
• brake pedal position
Refer to “ADJUSTING THE REAR
BRAKE” in chapter 3.
6. Adjust:
• rear brake light operation timing
Refer to “ADJUSTING THE REAR
BRAKE LIGHT SWITCH” in chapter 3.
