1999 TOYOTA AVENSIS service

AB0163
Wire Harness
Diameter
Stripped Wire Harness Section
H11605
Pull RS–28
– SUPPLEMENTAL RESTRAINT SYSTEMCURTAIN SHIELD AIRBAG ASSEMBLY

Always wash your hands with water after completing
the operation.
When scrapping a vehicle, deploy the airbag and scrap
the vehicle with the curtain shield airbag assembly still
installed.
2. DEPLOYMENT WHEN DISPOSING OF CURTAIN
SHIELD AIRBAG ASSEMBLY
NOTICE:

When disposing of the curtain shield airbag assem-
bly only, never use the customer’s vehicle to deploy
the airbag.

Be sure to follow the procedure given below when de-
ploying the airbag.
HINT:
Have a battery ready as the power source to deploy the airbag.
(a) Remove the curtain shield airbag assembly.
CAUTION:
Store the curtain shield airbag assembly with the airbag
deployment curtain shield facing upward.
(b) Using a service–purpose wire harness, tie down the cur-
tain shield airbag assembly.
Wire harness: Stripped wire harness section
1.25 mm
2
or more (0.0019 in2 or more)
HINT:
To calculate the square of the stripped wire harness section :
Square = 3.14 x (Diameter)
2 divided by 4
CAUTION:
If a wire harness which is too thin or some other thing is
used to tie down the curtain shield airbag assembly, it may
be snapped by the shock when the airbag is deployed. This
is highly dangerous. Always use a wire harness for vehicle
use which is at least 1.25 mm
2 (0.0019 in2).
(1) Cut the deployment section of the curtain shield air-
bag assembly.

I12471
A
B
: Low Pressure Charging Hose
: High Pressure Charging HoseA
B
AC2A7–02
N04392
Sleeve AC–4
– AIR CONDITIONINGMANIFOLD GAUGE SET (1CD–FTV)
MANIFOLD GAUGE SET
(1CD–FTV)
SET ON
1. CONNECT CHARGE HOSE TO MANIFOLD GAUGE
SET
Tighten the nuts by hand.
CAUTION:
Do not connect the wrong hoses.
2. CONNECT QUICK DISCONNECT ADAPTERS TO
CHARGING HOSES
Tighten the nuts by hand.
3. CLOSE BOTH HAND VALVES OF MANIFOLD GAUGE
SET
4. REMOVE CAPS FROM SERVICE VALVE ON REFRIG-
ERANT LINE
5. CONNECT QUICK DISCONNECT ADAPTER TO SER-
VICE VALVES
HINT:
Push the quick disconnect adapter onto the service valve, slide,
then slide the sleeve of the quick disconnect adapter downward
to lock it.

AC2A8–01
N06553
– AIR CONDITIONINGMANIFOLD GAUGE SET (1CD–FTV)
AC–5
SET OFF
1. CLOSE BOTH HAND VALVES OF MANIFOLD GAUGE
SET
2. DISCONNECT QUICK DISCONNECT ADAPTERS
FROM SERVICE VALVES ON REFRIGERANT LINE
HINT:
Slide the sleeve of the quick disconnect adapter upward to un-
lock the adapter and remove it from the service valve.
3. INSTALL CAPS TO SERVICE VALVES ON REFRIGER-
ANT LINE

ID–2ALPHABETICAL INDEX (A – S)
A
Page
ABBREVIATIONS USED IN THIS MANUAL
(TERMS) IN–34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AIR CONDITIONING (PREPARATION) PP–22. . . . . . . . . . . . .
AIR CONDITIONING
(SERVICE SPECIFICATIONS) SS–19. . . . . . . . . . . . . . . . . .
B
BODY (PREPARATION) PP–20. . . . . . . . . . . . . . . . . . . . . . . . . .
BODY (SERVICE SPECIFICATIONS) SS–18. . . . . . . . . . . . . . .
BODY ELECTRICAL (PREPARATION) PP–19. . . . . . . . . . . . . .
BODY ELECTRICAL
(SERVICE SPECIFICATIONS) SS–16. . . . . . . . . . . . . . . . . .
BRAKE (PREPARATION) PP–11. . . . . . . . . . . . . . . . . . . . . . . . .
BRAKE (SERVICE SPECIFICATIONS) SS–11. . . . . . . . . . . . . .
BRAKE PEDAL BR–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
C
CIRCUIT INSPECTION
(SUPPLEMENTAL RESTRAINT SYSTEM)
(DIAGNOSTICS) DI–8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CLIP BO–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
COMBINATION METER BE–2. . . . . . . . . . . . . . . . . . . . . . . . . .
COMBUSTION TYPE POWER HEATER AC–9. . . . . . . . . . . .
COMPRESSOR AND MAGNETIC CLUTCH
(1CD–FTV) AC–25. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CONDENSER FAN (1CD–FTV) AC–30. . . . . . . . . . . . . . . . . . . .
CURTAIN SHIELD AIRBAG ASSEMBLY RS–20. . . . . . . . . . . .
D
DIAGNOSTIC TROUBLE CODE CHART
(SUPPLEMENTAL RESTRAINT SYSTEM)
(DIAGNOSTICS) DI–4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DIFFERENTIAL CASE (E251) MX–41. . . . . . . . . . . . . . . . . . . . .
DRIVE BELT SR–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DRIVE BELT (1CD–FTV) AC–1. . . . . . . . . . . . . . . . . . . . . . . . .
E
ELECTRICAL TYPE POWER HEATER AC–23. . . . . . . . . . . . .
F
FOG LIGHT SYSTEM BE–1. . . . . . . . . . . . . . . . . . . . . . . . . . . .
FOR ALL OF VEHICLES IN–9. . . . . . . . . . . . . . . . . . . . . . . . . .
FRONT DRIVE SHAFT SA–1. . . . . . . . . . . . . . . . . . . . . . . . . . .
G
GENERAL INFORMATION
(HOW TO TROUBLESHOOT ECU
CONTROLLED SYSTEMS) IN–18. . . . . . . . . . . . . . . . . . . . .
GENERAL INFORMATION
(HOW TO USE THIS MANUAL) IN–1. . . . . . . . . . . . . . . . .
GENERAL INFORMATION
(REPAIR INSTRUCTIONS) IN–4. . . . . . . . . . . . . . . . . . . . .
H
HOW TO PROCEED WITH TROUBLESHOOTING
(HOW TO TROUBLESHOOT ECU
CONTROLLED SYSTEMS) IN–19. . . . . . . . . . . . . . . . . . . . . Page
HOW TO TROUBLESHOOT ECU
CONTROLLED SYSTEMS IN–18. . . . . . . . . . . . . . . . . . . . . .
HOW TO USE THE DIAGNOSTIC CHART AND
INSPECTION PROCEDURE
(HOW TO TROUBLESHOOT ECU
CONTROLLED SYSTEMS) IN–29. . . . . . . . . . . . . . . . . . . . .
HOW TO USE THIS MANUAL IN–1. . . . . . . . . . . . . . . . . . . . .
I
IDENTIFICATION INFORMATION IN–3. . . . . . . . . . . . . . . . . .
INPUT SHAFT (E251) MX–23. . . . . . . . . . . . . . . . . . . . . . . . . . . .
INSTRUMENT PANEL BO–13. . . . . . . . . . . . . . . . . . . . . . . . . . . .
M
MANIFOLD GAUGE SET (1CD–FTV) AC–4. . . . . . . . . . . . . . .
MANUAL TRANSAXLE (E251)
(PREPARATION) PP–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
MANUAL TRANSAXLE (E251)
(SERVICE SPECIFICATIONS) SS–4. . . . . . . . . . . . . . . . . .
MANUAL TRANSAXLE ASSEMBLY (E251) MX–9. . . . . . . . . .
MANUAL TRANSAXLE UNIT (E251) MX–2. . . . . . . . . . . . . . . .
O
OIL PUMP (E251) MX–38. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OUTPUT SHAFT (E251) MX–30. . . . . . . . . . . . . . . . . . . . . . . . . .
P
PARTS LOCATION
(SUPPLEMENTAL RESTRAINT SYSTEM)
(DIAGNOSTICS) DI–5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
POWER STEERING FLUID SR–3. . . . . . . . . . . . . . . . . . . . . . .
POWER STEERING VANE PUMP
(2C–T, 2C–TE, 1CD–FTV) SR–6. . . . . . . . . . . . . . . . . . . . . .
PRE–CHECK
(SUPPLEMENTAL RESTRAINT SYSTEM)
(DIAGNOSTICS) DI–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PRECAUTION (FOR ALL OF VEHICLES) IN–9. . . . . . . . . . .
R
REFRIGERANT LINE AC–6. . . . . . . . . . . . . . . . . . . . . . . . . . . .
RELAY (1CD–FTV) AC–29. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REPAIR INSTRUCTIONS IN–4. . . . . . . . . . . . . . . . . . . . . . . . .
ROOF HEADLINING (Liftback) BO–27. . . . . . . . . . . . . . . . . . . . .
ROOF HEADLINING (Sedan) BO–22. . . . . . . . . . . . . . . . . . . . . .
ROOF HEADLINING (Wagon) BO–32. . . . . . . . . . . . . . . . . . . . .
S
SHIFT AND SELECT LEVER SHAFT (E251) MX–40. . . . . . . . .
SHIFT LEVER AND CONTROL CABLE (E251) MX–48. . . . . . .
SIDE AIRBAG ASSEMBLY RS–9. . . . . . . . . . . . . . . . . . . . . . . .
SIDE AND CURTAIN SHIELD AIRBAG SENSOR
ASSEMBLY RS–34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SLIDING ROOF BO–11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SRS AIRBAG RS–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
STANDARD BOLT (SERVICE SPECIFICATIONS) SS–1. . . .
STEERING (PREPARATION) PP–12. . . . . . . . . . . . . . . . . . . . . .
STEERING (SERVICE SPECIFICATIONS) SS–13. . . . . . . . . .
SUPPLEMENTAL RESTRAINT SYSTEM
(DIAGNOSTICS) DI–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SUPPLEMENTAL RESTRAINT SYSTEM
(PREPARATION) PP–16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

ID–3ALPHABETICAL INDEX (S – W)
Page
SUPPLEMENTAL RESTRAINT SYSTEM
(SERVICE SPECIFICATIONS) SS–15. . . . . . . . . . . . . . . . . .
SUSPENSION AND AXLE (PREPARATION) PP–6. . . . . . . . .
SUSPENSION AND AXLE
(SERVICE SPECIFICATIONS) SS–9. . . . . . . . . . . . . . . . . .
T
TERMINALS OF ECU
(SUPPLEMENTAL RESTRAINT SYSTEM)
(DIAGNOSTICS) DI–6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TERMS IN–34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING (E251) MX–1. . . . . . . . . . . . . . . . . . . . .
V
VACUUM PUMP (1CD–FTV) BR–2. . . . . . . . . . . . . . . . . . . . . .
VEHICLE IDENTIFICATION AND ENGINE SERIAL
NUMBER (IDENTIFICATION INFORMATION) IN–3. . . . .
VEHICLE LIFT AND SUPPORT LOCATIONS
(REPAIR INSTRUCTIONS) IN–7. . . . . . . . . . . . . . . . . . . . .
W
WATER TEMPERATURE SWITCH (1CD–FTV) AC–36. . . . . . .
WINDSHIELD BO–3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WIRE HARNESS AND CONNECTOR RS–39. . . . . . . . . . . . . .