1999 TOYOTA AVENSIS sensor

PP282–01
– PREPARATIONSUPPLEMENTAL RESTRAINT SYSTEM
PP–17
RECOMMENDED TOOLS
09042–00020Torx Socket T40 .Airbag sensor assembly
Seatback assembly
09082–00050TOYOTA Electrical Tester Set.
09082–00040TOYOTA Electrical Tester.

SS–8
– SERVICE SPECIFICATIONSMANUAL TRANSAXLE (E251)
Transmission case x Transaxle case
2930022
Transmission oil pipe x Transaxle case1717513
Reverse shift arm bracket assembly x Transaxle case1717513
Transmission oil pump assembly x Transaxle case1717513
Transaxle case receiver x Transaxle case7.47565 in.·lbf
Clutch release fork support4748035
Control lever housing support bracket x Transaxle case1717513
Vehicle speed sensor1717513
Clutch release line bracket x Transaxle case1717513
Back–up light switch4041030
Filler and drain plugs4950036
No.1 and No.2 oil receiver pipes x Transmission case1717513
Transmission oil cooler sub–assembly x Elbow3435025
Elbow x Transaxle case2727520
Transmission oil pump case x Oil pump cover101058
Differential left case x Differential right case6364046
Ring gear set bolt1241,26091
Shift lever assembly x Body121209
Retainer x Body4.95043 in.·lbf
Grommet retainer x Body4.95043 in.·lbf

SS0IZ–02
SS–10
– SERVICE SPECIFICATIONSSUSPENSION AND AXLE
TORQUE SPECIFICATION
Part tightenedN·mkgf·cmft·lbf
Drive shaft center bearing bracket set bolt6465047
Lower suspension arm x Lower ball joint1271,30094
Tie rod and x steering knuckle4950036
Axle hub x Drive shaft2162,200159
ABS speed sensor set bolt8.08271 in.·lbf
Hub nut1031,05076

SS061–28
– SERVICE SPECIFICATIONSSUPPLEMENTAL RESTRAINT SYSTEM
SS–15
SUPPLEMENTAL RESTRAINT SYSTEM
TORQUE SPECIFICATION
Part tightenedN·mkgf·cmft·lbf
Steering wheel x Steering main shaft7879058
Front passenger airbag assembly x Instrument panel reinforcement2121015
Seatback frame set bolt2525518
Front seat installation bolt3737527
Front seat belt lap outer ancher set bolt4243031
Curtain shield airbag (infrater) x Instrument panel reinforcement9.810087 in.·lbf
Curtain Shield Airbag (deployment section) x Body55144 in.·lbf
Side and curtain shield airbag sensor assembly x Body2121015
Front seat outer belt retractor Upper bolt
Lower bolt5.0
4251
43044 in.·lbf
31
Instrument panel x Reinfocement1818413
Seatback x Body2121415

H11822
Airbag Sensor
AssemblySide Airbag Assembly (RH)
(Squib)
Pretensioner (RH)
(Squib)
Side and Curtain Shied
Airbag Sensor (RH)1
2
3
4
5
6
7
89
10
11
12
1314
15Front Airbag Sensor
(RH)
Front Passenger Airbag
Assembly (Squib)
Spiral Cable
Steering Wheel
Pad (Squib)
No.1 J/B
Pretensioner (LH)
(Squib) Front Airbag Sensor
(LH)
Side Airbag Assembly (LH)
(Squib)
16
19
18
17
2021Curtain Shied Airbag
Assembly (RH) (Squib)
Curtain Shied Airbag
Assembly (LH) (Squib)
Side and Curtain Shied
Airbag Sensor (LH) DI–2
– DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM


 


  


H01358
Airbag Sensor Assembly Connector
Short SpringShort SpringShort Spring
Before ReleaseAfter Release
Connector
Connector
Short SpringShort Spring
Before Release
Paper
After Release
Paper
5821
Connector
Paper
12
3
1019
Short Spring
– DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
DI–3

DI694–01
DI–4
– DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
DIAGNOSTIC TROUBLE CODE CHART
If a malfunction code is displayed during the DTC check, check the circuit listed for that code in the table
below (Proceed to the page given for that circuit.).
DTC No.
(See Page)Detection ItemTrouble AreaSRS
Warning Light
81
(DI–8)Short in curtain shield airbag (RH) cir-
cuit (to ground)
Curtain shield airbag (RH) (squib)

Airbag sensor assembly

Wire harness
Blink
82
(DI–12)Short in curtain shield airbag (RH) cir-
cuit circuit (to B+)
Curtain shield airbag (RH) (squib)

Airbag sensor assembly

Wire harness
Blink
83
(DI–15)Short in curtain shield airbag (RH) squib
circuit
Curtain shield airbag (RH) (squib)

Airbag sensor assembly

Wire harness
Blink
84
(DI–18)Open in curtain shield airbag (RH) squib
circuit
Curtain shield airbag (RH) (squib)

Airbag sensor assembly

Wire harness
Blink
85
(DI–21)Short in curtain shield airbag (LH) circuit
(to ground)
Curtain shield airbag (LH) (squib)

Airbag sensor assembly

Wire harness
Blink
86
(DI–25)Short in curtain shield airbag (LH) circuit
circuit (to B+)
Curtain shield airbag (LH) (squib)

Airbag sensor assembly

Wire harness
Blink
87
(DI–28)Short in curtain shield airbag (LH) squib
circuit
Curtain shield airbag (LH) (squib)

Airbag sensor assembly

Wire harness
Blink
88
(DI–31)Open in curtain shield airbag (LH) squib
circuit
Curtain shield airbag (LH) (squib)

Airbag sensor assembly

Wire harness
Blink
HINT:

When the SRS warning light remains lit up and the DTC is the normal code, this means a voltage source
drops.
This malfunction is not stored in memory by the airbag sensor assembly and if the power source volt-
age returns to normal, the SRS warning light will automatically go out.

When 2 or more codes are indicated, the codes will be displayed in numeral order starting from the
lowest numbered code.

If a code not listed on the chart is displayed, the airbag sensor assembly is faulty.

DI695–01
H11591
Combination Meter
(Warning Light)Steering Wheel Pad
(with Airbag)
Airbag Sensor Assembly Front Passenger
Airbag Assembly
Side Airbag Assembly
(LH)
Seat Belt
Pretensioner (LH)Side Airbag Assembly (RH)
Seat Belt
Pretensioner (RH)
Front Airbag
Sensor (LH)
Front Airbag Sensor (RH)
Side and Curtain Shield
Airbag Sensor (RH) Side and Curtain Shield
Airbag Sensor (LH)Curtain Shield Airbag
Assembly (LH)Curtain Shield Airbag Assembly (RH)
– DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
DI–5
PARTS LOCATION