1999 OLDSMOBILE ALERO radiator

yellowblue
6-21
CAUTION:
Turning the surge tank pressure cap when the
engine and radiator are hot can allow steam and
scalding liquids to blow out and burn you badly.
Never turn the surge tank pressure cap
-- even a
little
-- when the engine and radiator are hot.
The vehicle must be on a level surface. When your
engine is cold, the coolant level should be at the
FULL COLD mark, or a little higher.
If the light comes on and
stays on, it means you're
low on engine coolant.Adding Coolant
If you need more coolant, add the proper DEX
-COOL

coolant mixture at the surge tank, but only when the
engine is cool.
CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don't spill coolant on a hot engine.
When replacing the pressure cap, make sure it is
hand
-tight.
ProCarManuals.com

Scheduled Maintenance
yellowblue
7-12
100,000 Miles (166 000 km)
Inspect spark plug wires (except 2.4L Code T L4 engine).
An Emission Control Service.
Replace spark plugs.
An Emission Control Service.
Change automatic transaxle fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
± In heavy city traffic where the outside temperature regularly reaches
90
F (32
C) or higher.
± In hilly or mountainous terrain.
± When doing frequent trailer towing.
± Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, the fluid and
filter do not require changing.
150,000 Miles (240 000 km)
Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See ªEngine Coolantº in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Service.
ACTUAL
SERVICED BY:MILEAGE
DATE
ACTUAL
SERVICED BY:MILEAGE
DATE
ProCarManuals.com

yellowblue
7-17
Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall). You should let your dealer's
service department or other qualified service center
do these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a service manual. See ªService and Owner
Publicationsº in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook
-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out
-of-position parts as well as open seams,holes, loose connections or other conditions which could
cause a heat build
-up in the floor pan or could let
exhaust fumes into the vehicle. See ªEngine Exhaustº in
the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside of the
radiator and air conditioning condenser. To help ensure
proper operation, a pressure test of the cooling system and
pressure cap is recommended at least once a year.
Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook
-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake parts,
including calipers, parking brake, etc. You may need to
have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
ProCarManuals.com

yellowblue
9-5
Ignition Positions 2-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Transaxle Lock Check 7-16 . . . . . . . . . . . . . . . . . . . .
Illuminated Entry/Exit 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation, Tire 6-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside Day/Night Rearview Mirror 2-44 . . . . . . . . . . . . . . . . .
Inspections 7-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake System 7-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Cooling System 7-17 . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust System 7-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Drive Axle Boot 7-17 . . . . . . . . . . . . . . . . . . . . . . . . .
Front Drive Axle Seal 7-17 . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator and Heater Hose 7-17 . . . . . . . . . . . . . . . . . . . . . .
Steering 7-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension 7-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle System 7-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument Panel 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cluster 2-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse Block 6-53, 6-54, 6-55 . . . . . . . . . . . . . . . . . . . . . . . .
Intensity Control 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior Lamps 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jack, Tire 5-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Key Lock Cylinders Service 7-14 . . . . . . . . . . . . . . . . . . . . .
Keys 2-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Labels
Certification 4-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Parts Identification 6-52 . . . . . . . . . . . . . . . . . . . . . Tire
-Loading Information 4-32 . . . . . . . . . . . . . . . . . . . . . .
Vehicle Identification Number 6-52 . . . . . . . . . . . . . . . . . . .
Lamps 2-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior 2-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fog 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirror Reading 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Reminder 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Leaving Your Vehicle 2-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Leaving Your Vehicle with the Engine Running 2-28 . . . . . . .
Lights
Air Bag Readiness 1
-25, 2-55 . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock Brake System Warning 2-57, 4-7 . . . . . . . . . . . .
Brake System Warning 2-52, 6-25 . . . . . . . . . . . . . . . . . . . .
Change Oil 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Charging System Indicator 2-55 . . . . . . . . . . . . . . . . . . . . . .
Check Engine 2-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cruise 2-67 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Oil Pressure Light 2-64 . . . . . . . . . . . . . . . . . . . . . .
Enhanced Traction System Active 2-59 . . . . . . . . . . . . . . . .
Enhanced Traction System Warning 2-58 . . . . . . . . . . . . . .
Interior 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Coolant Warning 2-60, 6-21 . . . . . . . . . . . . . . . . . . . .
Low Oil 2-65, 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Tire Pressure 2-61 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Wash 2-67 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Pressure 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Reminder 1-8, 2-54 . . . . . . . . . . . . . . . . . . . . . .
Security 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Engine Soon 2-62 . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Vehicle Soon 2-67 . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Your Vehicle 4-32 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Out Switch 2-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ProCarManuals.com

yellowblue
9-7
Passenger Position 1-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passing 4-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passing with a Trailer 4-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passlock
2-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-17 . . . . . . . . . . . . . . . . . .
Power
Accessory Outlets 2
-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Locks 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Mirror 2-45 . . . . . . . . . . . . . . . . . . . . . . . .
Seats 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Fluid 6-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-22 . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-11, 8-12, 8-13 . . . . . . . . .
Radiator 5-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio Reception 3-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radios 3-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rain, Driving In 4-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear
Door Security Locks 2
-7 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside Seat Position 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Comfort Guides 1-32 . . . . . . . . . . . . . . . . . . . . .
Seat Passengers 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Window Defogger 3-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Turn Signal Lamp Bulb Replacement 6-32 . . . . . . . . . . .
Rearview Mirror 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reclining Front Seatbacks 1-5 . . . . . . . . . . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants 7-18 . . . . . . . . . . . . . . .
Recreational Vehicle Towing 4-30 . . . . . . . . . . . . . . . . . . . . . .
Refrigerants, Air Conditioning 6-59 . . . . . . . . . . . . . . . . . . . . Remote
Lock Control 2
-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk Release 2-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk Release Lockout 2-13 . . . . . . . . . . . . . . . . . . . . . . . .
Remote Lock Control 2-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 2-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement
Bulbs 6
-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts 6-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel 6-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Safety Belts 1-54 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reporting Safety Defects 8-10, 8-11 . . . . . . . . . . . . . . . . . . . .
Restraints
Checking 1
-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Child 1-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Head 1-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Parts After a Crash 1-54 . . . . . . . . . . . . . . . . . . .
System Check 7-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Resynchronization 2-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reverse, Automatic Transaxle 2-23 . . . . . . . . . . . . . . . . . . . . .
Right Front Passenger Position 1-23 . . . . . . . . . . . . . . . . . . . .
Roadside Assistance 8-6, 8-7 . . . . . . . . . . . . . . . . . . . . . . . . . .
Rocking Your Vehicle 5-29 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotation, Tires 6-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Extender 1-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Reminder Light 1-8, 2-54 . . . . . . . . . . . . . . . . . . .
Safety Belts 1-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adults 1-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Care 6-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Center Rear Passenger Position 1-35 . . . . . . . . . . . . . . . . . .
Children 1-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver Position 1-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ProCarManuals.com