1999 GMC C-SERIES automatic transmission fluid

yellowblue
2-10
Starting Your Diesel Engine
If you have a Caterpillar diesel engine, also refer to
your Caterpillar
Operation & Maintenance Manual for
starting procedure.
To make starting easier in cold weather (below 32F or
0C), the proper viscosity engine oil should be used. It's
also best to heat the engine oil first. You can do this by
using an engine coolant heater. A GM Automatic Ether
Injection System aids cold weather starting.
NOTICE:
Your diesel engine has an electric air intake
heater system which reduces white smoke and
helps start the engine in cold weather. Do not
spray starting fluid into the air intake where it
can contact the heater elements.
If you don't have the GM Automatic Ether
Injection System, don't use starting fluid or
you could damage your engine. If you have the
GM system, use only GM approved starting fluid
that has been tested to establish compatibility
with the air inlet heater system.
NOTICE:
If you ever have to have your vehicle towed, see
the part of this manual that tells how to do it
without damaging your vehicle. See ªTowing
Your Vehicleº in the Index.
Restarting the Diesel Engine While Moving
(Automatic Transmission)
If you have to restart the engine while the vehicle is
moving, you'll first have to shift the automatic transmission
to NEUTRAL (N). This safety feature prevents starting
the engine when the transmission is in a drive gear.
Stopping the Diesel Engine
If you have a Caterpillar diesel engine, see your
Caterpillar
Operation & Maintenance Manual.
1. Set the parking brake and shift to NEUTRAL (N) or
PARK (P).
2. Turn the ignition switch key to OFF.
If your vehicle has a two
-speed axle, see ªRear Axle,
Tw o
-Speed Electric Shift Controlº or ªRear Axle,
Tw o
-Speed Airshift Controlº in the Index.
ProCarManuals.com

6-
yellowblue
6-1
Section 6 Service and Appearance Care
Here you will find information about the care of your vehicle. This section begins with service and fuel information,
and then it shows how to check important fluid and lubricant levels. There is also technical information about your
vehicle, and a part devoted to its appearance care.
6
-2 Service
6
-4 Fuel (Gasoline Engine)
6
-5 Diesel Fuel Requirements and Fuel System
6
-6 Fuels in Foreign Countries (Gasoline Engines)
6
-7 Filling Your Tank
6
-8 Filling a Portable Fuel Container
6
-9 Checking Things Under the Hood
6
-11 Noise Control System
6
-13 Engine Oil (Gasoline Engine)
6
-17 Engine Oil (Caterpillar
Diesel Engine)
6
-17 Engine Air Cleaner/Filter
6
-18 Automatic Transmission Fluid
6
-19 Manual Transmission Fluid
6
-20 Rear Axle
6
-20 Rear Axle Shift Motor (Option)
6
-21 Radiator Pressure Cap (Gasoline Engines)
6
-22 Surge Tank Pressure Cap (Diesel Engines)
6
-22 Thermostat6
-23 Engine Coolant (Gasoline Engine)
6
-27 Engine Coolant (Caterpillar
Diesel Engine)
6
-28 Power Steering Fluid
6
-29 Windshield Washer Fluid
6
-30 Brakes
6
-36 Electric/Hydraulic Parking Brake Fluid
6
-42 Battery
6
-44 Other Service Items
6
-48 Tires
6
-59 Appearance Care
6
-59 Cleaning the Inside of Your Vehicle
6
-63 Cleaning the Outside Your Vehicle
6
-66 GM Vehicle Care/Appearance Materials
6
-67 Vehicle Identification Number (VIN)
6
-67 Service Parts Identification Label
6
-68 Electrical System
6
-74 Capacities and Specifications
6
-77 Air Conditioning Refrigerants
ProCarManuals.com

yellowblue
6-18
CAUTION:
Gasoline Engines Only: Operating the engine
with the air cleaner/filter off can cause you or
others to be burned. The air cleaner not only
cleans the air, it stops flame if the engine
backfires. If it isn't there, and the engine
backfires, you could be burned. Don't drive with
it off, and be careful working on the engine with
the air cleaner/filter off.
NOTICE:
Gasoline Engines Only: If the air cleaner/filter is
off, a backfire can cause a damaging engine fire.
And, dirt can easily get into your engine, which
will damage it. Always have the air cleaner/filter
in place when you're driving.
Your vehicle may also be equipped with an optional
Filterminder gage. See ªWarning Lights, Gages and
Indicatorsº in the Index.
Automatic Transmission Fluid
When to Check
A good time to have it checked is when the engine oil is
checked. See your Allison Automatic Transmission
Operator's Manual to find out when to change your
transmission fluid and filters.
How to Check and What to Use
The Allison Automatic Transmission Operator's Manual
that came with the vehicle shows how to check the
automatic transmission fluid and what fluid to use.
NOTICE:
Too much or too little fluid can damage your
transmission. Too much can mean that some of
the fluid could come out and fall on hot engine
parts or exhaust system parts, starting a fire. Be
sure to get an accurate reading if you check your
transmission fluid.
ProCarManuals.com

yellowblue
6-19 Automatic Transmission External Filter
Your automatic transmission spin-on type filter requires
periodic replacement. It is mounted just behind the
radiator on the outside of the passenger's side frame rail.
Consult the Allison Automatic Transmission Operator's
Manual that came with the vehicle for proper
change intervals.
Automatic Transmission External Filter
With Service Trans Filter Indicator Light
(Option)
This automatic transmission spin-on type filter is
mounted to the left of the transmission. It requires
replacement when the SERVICE TRANS FILTER
indicator light on the instrument panel comes on or
every three years, whichever occurs first.
Manual Transmission Fluid
When to Check
A good time to have it checked is when the engine oil is
checked. See your Maintenance Schedule to find out
when to change your transmission fluid and filters.
How to Check and What to Use
The Eaton Fuller Transmission Operator's Manual that
came with the vehicle shows how to check the manual
tranmsmission fluid and what fluid to use.
NOTICE:
Too much or too little fluid can damage your
transmission. Too much can mean that some of
the fluid could come out and fall on hot engine
parts or exhaust system parts, starting a fire. Be
sure to get an accurate reading if you check your
transmission fluid.
ProCarManuals.com

yellowblue
6-36
Electric/Hydraulic Parking
Brake Fluid
If you have an electric/hydraulic parking brake, a good
time to check the fluid level is when you check the fluid
levels under the hood.
If you need to add fluid, use Dexron III automatic
transmission fluid (GM Part Number 12345881).
How to Check and Add Fluid
First, apply the parking brake. To check the fluid level,
look at the MAX and MIN lines on the side of the
reservoir. If the level is below the MAX line, add fluid.
To add fluid, clean away any dirt around the reservoir
cap. Remove the reservoir cap and add enough fluid to
bring it up to the MAX level.
NOTICE:
Always use proper fluid (automatic transmission
fluid), not brake fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.
ProCarManuals.com

yellowblue
6-74
Replacement Bulbs
It is recommended that you use an AC
type bulb
whenever you need to replace one.
Before you replace any bulbs, be sure that all lamps are
off and the engine isn't running.
Capacities and Specifications
Replacement part numbers listed in this section are
based on the latest information available at the time of
printing. They are subject to later change. If a part listed
here isn't the same as the part in your vehicle when it
was built, or if you have any questions, please contact
your GM Truck dealer.
Engine Identification and Data
Engine RPO LG5 LP4/L21
Engine Type 7.2L L6 7.4L V8
Fuel System HEUI SPFI
Firing Order
1
-5-3-6-2-41-8-4-3-6-5-7-2
Wheel Nut Torque
Refer to ªTightening the Wheel Nutsº in this section for
wheel nut torque information.
Cooling System Capacity
Model Quarts (Liters)
7.2L 32.0 (30.0). . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
with automatic transmission 30.0 (28.4). . . . . . . . . .
7.4L 25.0 (23.7). . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
with automatic transmission 23.0 (22.7). . . . . . . . . .
Above capacities (volumes) are approximate.
Crankcase Capacity
Capacities (volumes) shown are for normal refill. Add
oil as indicated when the oil filter element is changed.
Capacities given are approximate
-- keep level within
the operating range. Do not operate with fluid level
below the ADD line.
Engine
Capacity
-- Quarts (Liters)
7.2L 21 (19.0)*
7.4L 8 (7.5)
*Additional oil is required with auxiliary oil filter
systems. Make sure to add enough extra oil to fill the
auxiliary oil filter system. For vehicles equipped with
the LUBERFINER 750
-C, add 14 quarts (13.25 L).
ProCarManuals.com

yellowblue
6-75
Extending the recommended oil change interval requires
the use of an infrared oil analysis program which shows
the condition of the oil and its additives. For more
information, consult your GM Truck dealer, who is an
authorized Caterpillar

engine dealer.
Transmission Capacity
Capacities (volumes) shown are approximate. For
manual transmissions, the correct oil level is to the
bottom of the fluid fill plug opening. The oil capacity
will vary, due to the angle of the transmission, with the
vehicle. For automatic transmissions, see the Allison
Automatic Transmission Operator's Manual for oil
check and maintenance information.
Manual Transmission Pints (Liters)
RT6609 12.0 (5.7). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RT6610 12.0 (5.8). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RTO6610 12.0 (5.8). . . . . . . . . . . . . . . . . . . . . . . . . . . RT6613 16.0 (7.5). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RT7608LL 19.5 (9.3). . . . . . . . . . . . . . . . . . . . . . . . . .
RT8609 15.0 (7.0). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FS4205A, FS4205B, FS4205C 12.5 (5.9). . . . . . . . . .
5205A, FS5205C 12.5 (5.9). . . . . . . . . . . . . . . . . . . . .
FS5306 18.0 (8.5). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FS6305A, FS6305B 19.0 (9.0). . . . . . . . . . . . . . . . . . .
FS6306 19.5 (9.2). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FS7206 20.0 (9.5). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
T8607B 36.0 (17.0). . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission Pints (Liters)
AT542 (for oil pan filter change) 30.0 (14.0)*. . . . . . .
AT545 (for oil pan filter change) 40.0 (19.0)*. . . . . . .
MT643 (for oil pan filter change) 13.0 (24.5)*. . . . . .
MT653 (for oil pan filter change) 36.0 (17.0)*. . . . . .
*Add two pints (one liter) when changing spin
-on filter.
ProCarManuals.com

yellowblue
7-18 Footnotes

= The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle's useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
(1) = If your vehicle has an Allison automatic
transmission, your GM Owner's Manual is
supplemented by an Allison Transmission Operator's
Manual. Always refer to these manuals for related
maintenance services.
(2) = Check the fluid level in the manual transmission.
(3) = An Emission Control Service.
(4) = A Noise Emission Control Device.
(5) = Applies only to vehicles sold in the United States.
(6) = Check fluid level in brake master cylinder, clutch
master cylinder (if equipped), power steering pump,
axle, transmission and hydraulic spring parking brake
pump (if equipped). A low fluid level in the brake
master cylinder can indicate worn brake linings and
should be checked accordingly.(7) = Inspect brake lines and hoses for proper hook
-up,
binding, leaks, cracks, chafing, etc. Inspect disc brake
pads for wear and rotors for surface condition. Check
brake pedal for excessive free play or travel (or every
6 months, whichever occurs first) and have serviced if
needed. Check brakes more often if driving habits and
conditions result in frequent braking.
(8) = Inspect hydraulic parking brake drum and linings
for wear or cracks and check linkage and adjustment.
Check spring brake actuator and pump for leaks.
Note: The spring brake section of the actuator is
non
-serviceable.
(9) = This vehicle has an Engine Oil Life Monitor. This
monitor will show you when to change the engine oil
and filter
-- usually between 3,000 miles (5 000 km) and
7,500 miles (12 500 km) since your last oil change.
Under severe conditions, the indicator may come on
before 3,000 miles (5 000 km). Never drive your vehicle
more than 7,500 miles (12 500 km) or 12 months
without an oil and filter change.
The system won't detect dust in the oil. So if you drive
in a dusty area, be sure to change your oil and filter
every 3,000 miles (5 000 km) or sooner if the Change
Oil Light comes on. Remember to reset the Oil Life
Monitor whenever the oil is changed. For more
information, see ªChange Oil Lightº in the Index.
ProCarManuals.com