1999 GMC C-SERIES oil temperature

yellowblue
6-23
Engine Coolant (Gasoline Engine)
The cooling system in your vehicle is filled with
DEX
-COOL
engine coolant. This coolant is designed
to remain in your vehicle for 5 years or 150,000 miles
(240 000 km), whichever occurs first, if you add only
DEX
-COOL
extended life coolant.
The following explains your cooling system and how to
add coolant when it is low. If you have a problem with
engine overheating, see ªEngine Overheatingº in
the Index.
A 50/50 mixture of clean, drinkable water and
DEX
-COOL
coolant will:

Give freezing protection down to
-34F (-37C).

Give boiling protection up to 252F (122C).

Protect against rust and corrosion.

Help keep the proper engine temperature.

Let the warning lights and gages work as
they should.
NOTICE:
When adding coolant, it is important that you
use only DEX
-COOL (silicate-free) coolant.
If coolant other than DEX-COOL is added to
the system, premature engine, heater core or
radiator corrosion may result. In addition, the
engine coolant will require change sooner
-- at
30,000 miles (50 000 km) or 24 months,
whichever occurs first. Damage caused by the
use of coolant other than DEX
-COOL is not
covered by your new vehicle warranty.
ProCarManuals.com

yellowblue
6-47 Front Wheel Bearings with Oil-Filled Hubs
If your vehicle has oil-filled
hubs, occasionally check to
see if they have enough oil.
You can tell by looking into
the sight glass to see if there
is oil there.
If there isn't, clean the rubber fill plug in the center of
the glass, and then remove it. Be careful not to allow
any dirt or water to get into the oil. Add enough of the
recommended oil to bring it up to the level mark that
you'll see on the glass.
Refer to your Maintenance Schedule for the proper oil
to use.
When you fill the hub, check the glass again after
driving a short distance. It takes a while for the oil to
flow through the system, and you may find that you
have to add a little more to fill it to the proper level.
Air Conditioning System
Every now and then, have your dealership check your
air conditioning system to be sure it has not lost any
cooling ability. If you think the system is not working
properly, have your GM Truck dealer check it out as
soon as possible.
The air conditioning won't work when the temperature
outside is below 40
F (4
C).
NOTICE:
If your vehicle is equipped with factory air
conditioning, the system is charged with the
R
-134a refrigerant. Servicing of the air
conditioning system should be performed by a
trained service technician.
ProCarManuals.com

yellowblue
7-5
Scheduled Maintenance
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
after 100,000 miles (166 000 km) should be performed
at those same intervals.
This vehicle has a computer that lets you know when to
change your engine oil. This is not based on mileage,
but on engine revolutions and engine operating
temperature. When the computer has calculated that the
oil needs changing, the Oil Life Indicator will indicate
that a change is necessary.
See ªFootnotesº at the end of this Maintenance Schedule
for further explanation of maintenance services and
Caterpillar

diesel application.
100 Miles (160 km)
Wheel stud nut service. (45)
500 Miles (800 km)
Wheel stud nut service. (45)
1,000 Miles (1 600 km)
Wheel stud nut service. (45)(46)
3,000 Miles (5 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
Clutch pedal free travel service. (10)
Rear axle air shift motor service. (11)
6,000 Miles (10 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
Chassis lubrication service (or every 6 months,
whichever occurs first). (12)
Lubricate door hinge pins and rollers with engine oil.
Wheels and tires service. (15)
Hydraulic brake service (or every 6 months,
whichever occurs first). (7)
Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)
Clutch pedal free travel service. (10)
9,000 Miles (15 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
ProCarManuals.com

yellowblue
7-20
(16) = Check spring-to-axle U-bolts and shackle bolts
for proper torque. See the service manual for torque
sequence and specifications. When parts are replaced,
the torque must be checked and adjusted more often
during the first 6,000 miles (10 000 km). Check torque
at 500 miles (800 km) and 2,000 miles (3 000 km) after
first use of parts.
(17) = Check complete exhaust system and cab areas
near the exhaust system for broken, damaged, missing or
out
-of-position parts. Also inspect for open seams,
holes, loose connections or other conditions which could
let exhaust fumes seep into the driver compartment.
Needed repairs should be made at once. To help
maintain system integrity, replace exhaust pipes
whenever a new muffler is put on.
(18) = Check all engine drive belts for cracks, fraying,
wear and proper tension. Adjust or replace as needed.
(19) = Check throttle linkage for damaged or missing
parts (including throttle return springs), interference or
binding. Fix any problems at once. Do not lubricate
accelerator and cruise control cables.
(20) = With the engine off and below normal operating
temperature, check to see that the thermostatically
controlled engine cooling fan can be rotated by hand on
viscous
-operated drives. Replace as needed.(21) = Check shields and underhood insulation for
damage or looseness. Adjust or replace as needed.
(22) = Lubricate caliper housing, caliper support spring
and caliper support key.
(23) = Wheel bearing service:

Grease type
-- Clean, inspect and lubricate with the
proper wheel bearing grease at designated intervals
or when hubs are removed. See ªRecommended
Fluids and Lubricantsº in the Index.

Oil
-filled type -- Some wheel bearings are lubricated
by rear axle lubricant. When you have oil
-filled
hubs, use lubricant identical to that used in your rear
axle. Lubricant change intervals are the same for
front and rear axles. However, you must maintain oil
level at the OIL LEVEL mark between change
intervals. See ªRecommended Fluids and
Lubricantsº in the Index.
(24) = Check the air intake system installation to see
that gaskets are seated properly and all hose
connections, fasteners and other components are tight.
For gasoline engines, also check to be sure the air
cleaner housing is properly seated, that the cover fits
tightly and that the wing nut is tight. Tighten
connections and fasteners or replace parts as required.
ProCarManuals.com

yellowblue
7-28
Part C: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by
name, part number or specification may be obtained
from your dealer.
USAGE
FLUID/LUBRICANT
Engine Oil
(Gasoline
Engine)Engine Oil with the American
Petroleum Institute Certified For
Gasoline Engines ªStarburstº
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle's engine, see
ªEngine Oilº in the Index.
Engine Oil
(Caterpillar
Diesel Engine)See the Caterpillar
Operation &
Maintenance Manual for Engine
Oil recommendations.
Engine Coolant
(GM Gasoline
Engine)50/50 mixture of clean, drinkable
water and use only GM
Goodwrench

DEX-COOL
or
Havoline
DEX-COOL

Coolant. See ªEngine Coolantº in
the Index.
USAGEFLUID/LUBRICANT
Engine Coolant
(Caterpillar
Diesel Engine)See the Caterpillar
Operation &
Maintenance Manual for Engine
Coolant recommendations.
Hydraulic Brake
SystemDelco Supreme 11
Brake Fluid
(GM Part No. 12377967 or
equivalent DOT
-3 Brake Fluid).
Windshield
Washer SolventGM Optikleen
Washer Solvent
(GM Part No. 1051515)
or equivalent.
Clutch Bearing
LubricantClutch Bearing Lubricant (GM
Part No. 12345777 or equivalent)
or NLGI #3 consistency.
Exhaust Brake
Ball Joint Cap
LubricantHigh-Temperature Grease (GM
Part No. 1051344 or equivalent) or
NLGI #3 consistency.
Spring Parking
Brake Hydraulic
PumpDEXRON
-III Automatic
Transmission Fluid.
ProCarManuals.com

yellowblue
9-5
Gages
Air Pressure 2-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Coolant Temperature 2-61 . . . . . . . . . . . . . . . . . . . .
Engine Oil Pressure 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filterminder 2-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel 2-68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hourmeter 2-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Pressure 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Speedometer 2-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Temperature 2-69 . . . . . . . . . . . . . . . . . . . . . .
Voltmeter 2-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Guide en Fran†ais ii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hazard Warning Flasher Switch 5-3 . . . . . . . . . . . . . . . . . . .
Hazard Warning Flashers 5-2 . . . . . . . . . . . . . . . . . . . . . . . . . .
Head Restraints 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Headlamps 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
High/Low Beam Changer 2-34 . . . . . . . . . . . . . . . . . . . . . .
Wiring 6-68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heating 3-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Highway Hypnosis 4-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hill and Mountain Roads 4-22 . . . . . . . . . . . . . . . . . . . . . . . . .
Hood
Access Panels 6
-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking Things Under 6-9 . . . . . . . . . . . . . . . . . . . . . . . . .
Latches Check 7-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Horn 2-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Hourmeter Gage 2
-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Brake Warning Light 2-58 . . . . . . . . . . . . . . . . . . . .
Hydroplaning 4-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Positions 2-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation, Tire 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspections
Engine Cover Check 7
-27 . . . . . . . . . . . . . . . . . . . . . . . . . .
Underbody 7-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument Panel 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Breaker Block 6-69 . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-61 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cluster 2-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Intake Heater Indicator Light 2-63 . . . . . . . . . . . . . . . . . . . . . .
Inter-Axle Differential Lock Control 2-40 . . . . . . . . . . . . . . . .
Jump Starting 5-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Keys 2-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Labels
Certification/Tire 4-28, 6-67 . . . . . . . . . . . . . . . . . . . . . . . .
Service Parts Identification 6-67 . . . . . . . . . . . . . . . . . . . . .
Vehicle Identification Number 6-67 . . . . . . . . . . . . . . . . . . .
Lamp and Bulb Data 6-74 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lamp Check 7-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ProCarManuals.com