1999 DODGE RAM light
[x] Cancel search: lightPage 5 of 1691
"G" ABBREVIATION TABLE
"G" ABBREVIATION TABLE
ABBREVIATION DEFINITION G grams GND or GRND Ground GRN Green GRY Gray Ga. Gauge Gals. gallons Gov. Governor
"H" ABBREVIATION TABLE
"H" ABBREVIATION TABLE
ABBREVIATION DEFINITION H/D Heavy Duty HAC High Altitude Compensation HC Hydrocarbons HEDF High Speed Electro Drive Fan relay or
circuit HEGO Heated Exhaust Gas Oxygen Sensor HEGOG or HEGO Ground circuit HEI High Energy Ignition HLDT Headlight HO High Output HP High Performance HSC High Swirl Combustion HSO High Specific Output HTR Heater HVAC Heating Headlt. Headlight Hg Mercury Hgt. Height Htr. Heater Hz Hertz (Cycles Per Second)
"I" ABBREVIATION TABLE
"I" ABBREVIATION TABLE
ABBREVIATION DEFINITION I.D. Inside Diameter IAC Idle Air Control IACV Idle Air Control Valve IC Integrated Circuit ID Identification IDM Ignition Diagnostic Monitor IGN Ignition system or circuit ILC Idle Load Compensator In. Hg Inches of Mercury INCH Lbs. Inch Pounds INFL REST Inflatable Restraint INJ Injector or Injection IP Instrument Panel IPC Instrument Panel Cluster
Page 6 of 1691
"I" ABBREVIATION TABLE (con’t)
ABBREVIATION DEFINITION ISA Idle Speed Actuator ISC Idle Speed Control ISS Idle Stop Solenoid ITS Idle Tracking Switch IVSV Idle Vacuum Switching Valve Ign. Ignition In. Inches Inj. Injector
"J" ABBREVIATION TABLE
"J" ABBREVIATION TABLE
ABBREVIATION DEFINITION J/B Junction Block
"K" ABBREVIATION TABLE
"K" ABBREVIATION TABLE
ABBREVIATION DEFINITION k/ohms 1000 ohms (kilo as in k/ohms) kg Kilograms (weight) kg/cm Kilograms Per Square Centimeter KAM Keep Alive Memory KAPWR Keep Alive Power KM/H Kilometers Per Hour KOEO Key On Engine Off KOER Key On Engine Running KS Knock Sensor
"L" ABBREVIATION TABLE
"L" ABBREVIATION TABLE
ABBREVIATION DEFINITION L Liter(s) L/D Light Duty LCD Liquid Crystal Display LED Light Emitting Diode LH Left Hand LOS Limited Operation Strategy LT BLU Light Blue LT GRN Light Green LUS Lock-Up Solenoid Lbs. Pounds Lt(s). Light(s) Lugg. Luggage
Page 7 of 1691
"M" ABBREVIATION TABLE
"M" ABBREVIATION TABLE
ABBREVIATION DEFINITION mA Milliamps mV Millivolts mfd. Microfarads Mm Millimeters M/T Manual Transaxle or Transmission MA PFI Mass MA or MAF Mass Airflow MAF Mass Air Flow Sensor MAFS Mass Airflow System MAP Manifold Absolute Pressure Sensor MAT Manifold Air Temperature MCU Microprocessor Control Unit MCV Mixture Control Valve MEM-CAL Memory Calibration Chip MFI Multiport Fuel Injection MIL Malfunction Incicator Light MLP Manual Lever Position MPFI Multi Point Fuel Injection MPH Miles Per Hour MPI Multi-Point (Fuel ) Injection Man. Manual Mech. Mechanical Mem. Memory Mtr. Motor
"N" ABBREVIATION TABLE
"N" ABBREVIATION TABLE
ABBREVIATION DEFINITION N.m Newton-Meter NA Not Available NDS Neutral Drive Switch NGS Neutral gear Switch NOx Oxides of Nitrogen NPS Neutral Pressure Switch No. Number Nos. Numbers
"O" ABBREVIATION TABLE
"O" ABBREVIATION TABLE
ABBREVIATION DEFINITION O Oxygen O.D. Outside Diameter O/S Oversize O2 Oxygen OC Oxidation Catalyst OCC Output Circuit Check OD Overdrive ODO Odometer
Page 9 of 1691
"R" ABBREVIATION TABLE
"R" ABBREVIATION TABLE
ABBREVIATION DEFINITION RABS Rear Anti-Lock Brake System RAC Remote Accessory Control RAM Random Access Memory RAP Retained Accessory Power RECIRC Recirculation RED Red RH Right hand ROM Read Only Memory RPM Revolutions Per Minute RVB Rear Vacuum Break RWAL Rear Wheel Anti-Lock Brake RWD Rear Wheel Drive Recirc. Recirculate or Recirculation Reg. Regulator Rly. Relay
"S" ABBREVIATION TABLE
"S" ABBREVIATION TABLE
ABBREVIATION DEFINITION SAW Spark Angle Word _ SBC Single Bed Converter _ SBEC Single Board Engine Controller _ SC Super Charged _ SCC Spark Control Computer _ SCS Air Suction Control Solenoid _ SDM Supplemental Restraint System Diagnostic Module _ SDU SRS Diagnostic Unit _ SEN Sensor _ SES Service Engine Soon _ SFI Sequential (Port) Fuel Injection _ SIG RTN Signal Return circuit _ SIL Shift Indicator Light _ SIR Supplemental Inflatable Restraint _ SMEC Single Module Engine Controller _ SOHC Single Overhead Cam _ SOL or SoL Solenoid _ SPFI Sequential Port Fuel Injection _ SPK Spark Control _ SPOUT Spark Output Signal _ SRS Supplemental Restraint System (Air Bag) _ SS 3/4-4/3 Shift Solenoid circuit _ SSI Solid State Ignition _ STAR Self-Test Automatic Readout _ STI Self Test Input circuit _ STO Self-Test Output _ SUB-O2 Sub Oxygen Sensor _ Sen. Or Sens. Sensor _ Sol. Solenoid _ Sprchg. Supercharger _ Strg. Steering _ Susp. Suspension _ Sw. Switch _ Sys. System _
Page 12 of 1691
A/C C O M PR ESSO R R EFR IG ER AN T O IL C HEC KIN G
1999 D odge P ic ku p R 1500
1999 GENERAL SERVICING
A/C Compressor Refrigerant Oil Checking
All Models
* PLEASE READ THIS FIRST *
NOTE: For compressor applications, see COMPRESSOR APPLICATIONS &
BODY DESIGNATIONS. DO NOT exceed A/C system refrigerant oil
capacity when servicing system. See CAPACITIES.
BODY DESIGNATIONS
BODY DESIGNATIONS (CHRYSLER CORP. CARS) \
\
\
\
\
\
\
Model ( 1) Body Designation
Avenger & Sebring Coupe ................................ "FJ22" Body
Breeze, Cirrus & Stratus ................................. "JA" Body
Concorde, Intrepid, LHS & 300M ........................... "LH" Body
Neon ..................................................... "PL" Body
Sebring Convertible ...................................... "JX" Body
( 1) - Body codes are determined by fifth character of VIN code.
\
\
\
\
\
\
\
BODY DESIGNATIONS (CHRYSLER CORP. LIGHT TRUCKS & VANS) \
\
\
\
\
\
\
Model Body Designation
Caravan, Town & Country, & Voyager ..................... "NS" Series
Dakota ................................................. "AN" Series
Durango ................................................ "DN" Series
Ram Pickup .......................................... "BR/BE" Series
Ram Van/Wagon .......................................... "AB" Series
\
\
\
\
\
\
\
BODY DESIGNATIONS (FORD MOTOR CO. LIGHT TRUCKS & VANS) \
\
\
\
\
\
\
Model Body Designation
Explorer & Mountaineer .................................. "U" Series
Pickup .................................................. "F" Series
Ranger .................................................. "R" Series
Van ..................................................... "E" Series
\
\
\
\
\
\
\
BODY DESIGNATIONS (GENERAL MOTORS CARS) \
\
\
\
\
\
\
Model ( 1) Body Designation
Alero, Cutlass, Grand Am & Malibu ......................... "N" Body
Aurora & Riviera .......................................... "G" Body
Bonneville, Eighty Eight, LeSabre & LSS ................... "H" Body
Camaro & Firebird ......................................... "F" Body
Catera .................................................... "V" Body
Cavalier & Sunfire ........................................ "J" Body
Century, Grand Prix, Intrigue, Lumina, Monte Carlo &
Regal .................................................... "W" Body
Page 13 of 1691
DeVille & Seville ......................................... "K" Body
Corvette .................................................. "Y" Body
Eldorado .................................................. "E" Body
Metro ..................................................... "M" Body
Park Avenue ............................................... "C" Body
Prizm ..................................................... "S" Body
Saturn .................................................... "Z" Body
(1) - Body codes are determined by fourth character of VIN code.
\
\
\
\
\
\
\
BODY DESIGNATIONS (GENERAL MOTORS LIGHT TRUCKS & VANS) \
\
\
\
\
\
\
Model ( 1) Body Designation
Astro & Safari
2WD ................................................... "M" Series
4WD ................................................... "L" Series
Blazer, Bravada, Envoy, Jimmy, Pickup & Sonoma
2WD ................................................... "S" Series
4WD ................................................... "T" Series
Commercial Chassis & Motorhome .......................... "P" Series
Escalade, Pickup, Sierra, Silverado, Suburban, Tahoe & Yukon
2WD ................................................... "C" Series
4WD ................................................... "K" Series
Express & Savana ........................................ "G" Series
Tracker ................................................. "J" Series
Montana, Silhouette & Venture ........................... "U" Series
( 1) - Series codes are determined by fifth character of VIN code.
\
\
\
\
\
\
\
BODY DESIGNATIONS (JEEP LIGHT TRUCKS) \
\
\
\
\
\
\
Model ( 1) Body Designation
Cherokee ............................................... "XJ" Series
Grand Cherokee ......................................... "WJ" Series
Wrangler ............................................... "TJ" Series
( 1) - Series codes are determined by fifth character of VIN code.
\
\
\
\
\
\
\
COMPRESSOR APPLICATIONS
COMPRESSOR APPLICATIONS (CARS) \
\
\
\
\
\
\
Application Compressor
Chrysler Corp.
Avenger & Sebring Coupe
2.0L (DOHC) ........................ Nippondenso 10PA17C 10-Cyl.\
2.5L (SOHC) .............................. Sanden MSC90-C Scroll\
Breeze, Cirrus & Stratus .................... Sanden TRS-90 Scroll
Concorde, Intrepid, LHS & 300M ........ Nippondenso 10PA17 10-Cyl.
Neon .................................. Nippondenso 10PA17 10-Cyl.
Sebring Convertible ......................... Sanden TRS-90 Scroll
Ford Motor Co.
Except Taurus 3.4L SHO ........................ Ford FS-10 10-Cyl.
Taurus 3.4L SHO .................................... Sanden Scroll
General Motors ( 1)
"C" Body ...................................... Harrison V5 5-Cyl.
Page 14 of 1691
"E" Body ................................. Harrison HD6/HT6 6-Cyl.
"F" Body
3.8L Engine ................................. Harrison V5 5-Cyl.
5.7L Engine ................................. Harrison V7 7-Cyl.
"G" Body
Aurora ................................. Harrison HD6/HT6 6-Cyl.
Riviera ..................................... Harrison V5 5-Cyl.
"H" Body ...................................... Harrison V5 5-Cyl.
"J" Body ...................................... Harrison V5 5-Cyl.
"K" Body ................................. Harrison HD6/HT6 6-Cyl.
"M" Body ..................................... Nippondenso 10-Cyl.
"N" Body ...................................... Harrison V5 5-Cyl.
"S" Body ...................................... Harrison V5 5-Cyl.
"V" Body ...................................... Harrison V5 5-Cyl.
"W" Body ...................................... Harrison V5 5-Cyl.
"Y" Body ...................................... Harrison V7 7-Cyl.
"Z" Body ....................................... Zexel Rotary Vane
(1) - Body codes are determined by fourth character of VIN code.
\
\
\
\
\
\
\
COMPRESSOR APPLICATIONS (LIGHT TRUCKS & VANS) \
\
\
\
\
\
\
Application Compressor
Chrysler Corp.
Dakota & Ram Pickup ........................ Sanden SD-7H15 7-Cyl.
Durango .................................... Sanden SD-7H15 7-Cyl.
Caravan, Town & Country, & Voyager .... Nippondenso 10PA17 10-Cyl.
Ram Van/Wagon ............................... Sanden TR-105 Scroll
Ford Motor Co.
"E" Series Van ................................ Ford FS-10 10-Cyl.
Expedition & Navigator ........................ Ford FS-10 10-Cyl.
Explorer & Mountaineer ........................ Ford FS-10 10-Cyl.
"F" Series Pickup
Except Super Duty ........................... Ford FS-10 10-Cyl.
Super Duty ............................... Sanden SD-7H15 7 Cyl.
Ranger ........................................ Ford FS-10 10-Cyl.
Villager ........................................... FS-10 10-Cyl.
Windstar ...................................... Ford FS-10 10-Cyl.
General Motors ( 1)
"C" & "K" Series ......................... Harrison HD6/HT6 6-Cyl.
"G" Series .................................... Harrison V5 5-Cyl.
"J" Series ................................... Nippondenso 10-Cyl.
"L" & "M" Series ......................... Harrison HD6/HT6 6-Cyl.
"P" Series ............................... Harrison HD6/HT6 6-Cyl.
"S" & "T" Series
2.2L ........................................ Harrison V7 7-Cyl.
4.3L ................................... Harrison HD6/HT6 6-Cyl.
"U" Series .................................... Harrison V5 5-Cyl.
Jeep
Cherokee ................................... Sanden SD-7H15 7-Cyl.
Grand Cherokee ........................ Nippondenso 10PA17 10-Cyl.
Wrangler ................................... Sanden SD-7H15 7-Cyl.
( 1) - Series codes are determined by fifth character of VIN code.
\
\
\
\
\
\
\
CAPACITIES
NOTE: Always refer to underhood A/C specification label in engine
compartment or A/C compressor label while servicing A/C
Page 15 of 1691
system. If A/C specification label and specifications in this
article differ, use underhood label specifications.
REFRIGERANT OIL & R-134a REFRIGERANT CAPACITY (CARS)
\
\
\
\
\
\
\
Application ( 1) Oil Oz. Refrigerant Oz.
Chrysler Corp.
Avenger & Sebring Coupe
2.0L (DOHC) ...................... 2.7-4.1 ......... 24.7-26.1\
2.5L (SOHC) ...................... 5.7-6.4 ......... 24.7-26.1\
Breeze, Cirrus & Stratus ............. 5.0 ................ 20.0
Concorde, Intrepid, LHS & 300M ....... 5.0 ................ 28.0
Neon ................................. 6.8 ................ 28.0
Sebring Convertible .................. 5.0 ................ 20.0
Ford Motor Co.
Continental .......................... 7.0 ................ 34.0
Contour, Cougar & Mystique ........... ( 1) ................. ( 1)
Crown Victoria & Grand Marquis ....... 7.0 ................ 38.0
Escort, Coupe & Tracer ............... 7.0 ................ 28.0
Mustang .............................. 7.0 ................ 34.0
Sable & Taurus ....................... 7.0 ................ 34.0
Town Car ............................. 7.0 ................ 38.0
General Motors
"C" Body ............................. 9.0 ................ 32.0
"E" & "K" Bodies ................ ( 1) 8.0-9.0 ............. 32.0
"F" Body ............................. 9.0 ................ 24.0
"G" Body
With HD6/HT6 Compressor ............ 8.0 ................ 32.0
With V5 Compressor ................. 9.0 ................ 32.0
"H" Body ............................. 9.0 ................ 32.0
"J" Body ............................. 9.0 ................ 24.0
"M" Body ............................. 3.4 ........... 19.0-21.0
"N" Body ............................. 9.0 ................. ( 2)
"S" Body ......................... ( 3) 4.1 ........... 22.9-26.5
"V" Body ............................. 9.0 ................ 33.5
"W" Body ............................. 9.0 ................ 30.0
"Y" Body ............................. 9.0 ................ 24.0
"Z" Body ............................. 5.0 ................ 24.0
( 1) - Total system capacity, unless otherwise noted. Refer to
underhood A/C specification label in engine compartment for
specified oil type.
( 2) - Refrigerant capacity for Alero and Grand Am is 36.0 ounces.
Refrigerant capacity for Cutlass and Malibu is 28.0 ounces.
( 3) - Compressor oil capacity.
\
\
\
\
\
\
\
REFRIGERANT OIL & R-134a REFRIGERANT CAPACITY (LIGHT TRUCKS & VANS) \
\
\
\
\
\
\
Application ( 1) Oil Oz. Refrigerant Oz.
Chrysler Corp.
Caravan, Town & Country, & Voyager
Without Rear Unit ................... 9.0 ............... 34.0
With Rear Unit ..................... 13.4 ............... 44.0
Dakota ................................ 8.1 ............... 28.0
Durango
Without Rear Unit ................... 5.5 ............... 28.0
With Rear Unit ...................... 8.0 ............... 30.0
Ram Pickup ............................ 8.1 ............... 30.0
Ram Van/Wagon
Without Rear Unit ................... 8.0 ............... 34.0