1999 CHEVROLET VENTURE washer fluid

yellowblue
6-25
Power Steering Fluid
The power steering fluid reservoir is located to the right
of the windshield washer fluid reservoir, at the back of
the engine compartment.
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless you suspect there is a leak in the system or
you hear an unusual noise. A fluid loss in this system
could indicate a problem. Have the system inspected
and repaired.
How to Check Power Steering Fluid
When the engine compartment is cool, wipe the cap and
the top of the reservoir clean, then unscrew the cap and
wipe the dipstick with a clean rag. Replace the cap and
completely tighten it. Then remove the cap again and
look at the fluid level on the dipstick.
When the engine compartment is hot, the level should be
at the ªHº mark. When it's cold, the level should be at
the ªCº mark. If the fluid is at the ADD mark, you
should add fluid.
What to Use
To determine what kind of fluid to use, see
ªRecommended Fluids and Lubricantsº in the Index.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.

yellowblue
6-26
Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer's instructions before use. If you will be
operating your vehicle in an area where the temperature
may fall below freezing, use a fluid that has sufficient
protection against freezing.
Adding Washer Fluid
The windshield washer fluid
reservoir is located on the
passenger's side of the
vehicle, near the fuse and
relay center.
Open the cap labeled WASHER FLUID ONLY.
Add washer fluid until the tank is full.
NOTICE:

When using concentrated washer fluid,
follow the manufacturer's instructions for
adding water.

Don't mix water with ready
-to-use washer
fluid. Water can cause the solution to freeze
and damage your washer fluid tank and
other parts of the washer system. Also,
water doesn't clean as well as washer fluid.

Fill your washer fluid tank only
three
-quarters full when it's very cold. This
allows for expansion if freezing occurs,
which could damage the tank if it is
completely full.

Don't use engine coolant (antifreeze) in
your windshield washer. It can damage
your washer system and paint.

yellowblue
6-61
Fuses Usage
LH HEADLP
LOWNot Used
LH HEADLP
HIGHNot Used
ABS/TCS IGN Electronic Brake Control
Module/Electronic Brake Traction
Control Module (EBCM/EBTCM)
ABS SOL LH and RH Front Brake
Solenoid Valve
HVAC/DRL Air Inlet Actuator, DRL Control
Module, Heater
-A/C Control,
Temperature Door Actuator
(Front) and Rear Window
Defogger Relay
BCM PRGRM Body Control Module (BCM)
RH HEADLP
LOWNot Used
RH HEADLP
HIGHNot Used
PCM IGN MAIN Relay and PCMUnderhood Fuse and Relay Center
This fuse and relay center is located in the engine
compartment, in front of the windshield washer
fluid reservoir.
The fuses marked spare are available if a replacement
fuse is needed.
To remove the cover, turn the knob clockwise and lift up
on the remote positive (+) battery terminal cover.
Remove the cover.

yellowblue
6-65
Engine Crankcase - Oil
and Filter Change4.5 quarts (4.3 L) . . . . . . . . . . .
Fuel Capacity
Standard/Regular 19.8 gallons (75.0 L). . . . . . . . . . .
Optional/Extended 24.3 gallons (92.0 L). . . . . . . . .
Refrigerant,
Air Conditioning*See Refrigerant . . . . . . . . . . . .
Label under the hood.
Tire Pressures, SizesSee Tire
-Loading . . . . . . . . . . .
Information label on driver's door.
Wheel Nut Torque100 lb
-ft (140 N´m) . . . . . . . . . .
Windshield Washer Fluid1 gallon (0.37 L) . . . . . . .
*See Air Conditioning Refrigerants later in
this section.
NOTE: All capacities are approximate. When adding, be
sure to fill to the appropriate level, as recommended in
this manual.
Engine Specifications
Engine VIN Code E. . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Type V6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Firing Order 1
-2-3-4-5-6 . . . . . . . . . . . . . . . . . . . . . .
Horsepower 185. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thermostat Temperature
Specification 195
F (91
C) . . . . . . . . . . . . . . . . . . .
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you're not sure, ask your dealer.
Normal Maintenance
Replacement Parts
Air Cleaner Filter AC Type A-1028C . . . . . . . . . . . . .
Passenger Compartment Air Filter (2) 52482929. . . .
Engine Oil Filter PF47. . . . . . . . . . . . . . . . . . . . . . . .
Spark Plugs AC Type 41
-940 . . . . . . . . . . . . . . . . . . .
Gap: 0.060 inches (1.5 mm)
Windshield Wiper Blades
Length 24.0 inches (60.0 cm). . . . . . . . . . . . . . . . . .
Type Sheperd's Hook. . . . . . . . . . . . . . . . . . . . . . . . .
Backglass Wiper Blade
Length 16 inches (40.6 cm). . . . . . . . . . . . . . . . . . . .
Type Sheperd's Hook. . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
7-30
Part B: Owner Checks and Services
Listed in this part are owner checks and services which
should be performed at the intervals specified to help
ensure the safety, dependability and emission control
performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. See ªEngine Oilº in the Index for
further details.
Engine Coolant Level Check
Check the engine coolant level and add DEX
-COOL

coolant mixture if necessary. See ªEngine Coolantº in
the Index for further details.Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the
windshield washer tank and add the proper fluid if
necessary. See ªWindshield Washer Fluidº in the
Index for further details.
At Least Once a Month
Tire Inflation Check
Make sure tires are inflated to the correct pressures.
See ªTiresº in the Index for further details.
Cassette Deck Service
Clean cassette deck. Cleaning should be done every
50 hours of tape play. See ªAudio Systemsº in the
Index for further details.

yellowblue
7-35
Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from
your dealer.
USAGE
FLUID/LUBRICANT
Engine OilEngine Oil with the American
Petroleum Institute Certified For
Gasoline Engines ªStarburstº
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle's engine, see
ªEngine Oilº in the Index.
Engine Coolant50/50 mixture of clean, drinkable
water and use only GM
Goodwrench

DEX-COOL
or
Havoline
DEX-COOL

Coolant. See ªEngine Coolantº in
the Index.
USAGEFLUID/LUBRICANT
Hydraulic Brake
SystemDelco Supreme 11
Brake Fluid
(GM Part No. 12377967 or
equivalent DOT
-3 Brake Fluid).
Windshield
Washer SolventGM Optikleen
Washer Solvent
(GM Part No. 1051515)
or equivalent.
Parking Brake
Cable GuidesChassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements of
NLGI # 2, Category LB or
GC
-LB.
Power Steering
SystemGM Power Steering Fluid (GM
Part No. 1052884
- 1 pint,
1050017
- 1 quart, or equivalent).
Automatic
TransaxleDEXRON
-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant,
Superlube
(GM Part
No. 12346241 or equivalent).

yellowblue
9-9
Comfort Controls 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fan Control 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside Seat Position 1-46 . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Comfort Guides 1-50 . . . . . . . . . . . . . . . . . . . . .
Seat Audio 3-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat Passengers 1-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seats 1-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage Compartments 2-72 . . . . . . . . . . . . . . . . . . . . . . . . .
Window Defogger 3-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windshield Washer 2-58 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rearview Mirror, Inside Day/Night 2-66 . . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants 7-35 . . . . . . . . . . . . . . .
Recovery Tank, Coolant 5-14 . . . . . . . . . . . . . . . . . . . . . . . . . .
Recreational Vehicle Towing 4-29 . . . . . . . . . . . . . . . . . . . . . .
Refrigerants, Air Conditioning 6-65 . . . . . . . . . . . . . . . . . . . .
Remote Compact Disc Player 3-25 . . . . . . . . . . . . . . . . . . . . .
Remote Operation of the Power Sliding Door 2-9 . . . . . . . . . .
Removing
Bucket Seats 1
-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Split Bench Seat 1-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement
Bulbs 6
-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts 6-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel 6-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing
Bucket Seats 1
-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belts 1-91 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat and Restraint System Parts After a Crash 1-91 . . . . . .
Split Bench Seat 1-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reporting Safety Defects 8-10 . . . . . . . . . . . . . . . . . . . . . . . . .
Resetting the Power Sliding Door 2-30 . . . . . . . . . . . . . . . . . .
Restraints
Checking 1
-90 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Head 1-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Reminder Light 1
-23, 2-88 . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Parts After a Crash 1-91 . . . . . . . . . . . . . . . . . . .
Second Row Safety Belt Stowage 1-7 . . . . . . . . . . . . . . . . .
System Check 7-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Restraints, Child 1-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Resynchronization 2-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REVERSE (R) 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Right Front Passenger Position 1-37 . . . . . . . . . . . . . . . . . . . .
Roadside Assistance 8-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Roadside Assistance, Canadian 8-7 . . . . . . . . . . . . . . . . . . . . .
Rocking Your Vehicle 5-33 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotation, Tires 6-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Extender 1-90 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belts 1-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adults 1-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Care 6-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Center Rear Passenger Position (Bench Seat) 1-52 . . . . . . .
Center Rear Passenger Position (Bucket Seat) 1-54 . . . . . . .
Children 1-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver Position 1-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Extender 1-90 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How to Wear Properly 1-28 . . . . . . . . . . . . . . . . . . . . . . . . .
Incorrect Usage 1-31, 1-88, 1-89 . . . . . . . . . . . . . . . . . . . .
Lap Belt 1-52, 1-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lap-Shoulder 1-28, 1-47 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Larger Children 1-87 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passenger Position 1-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pretensioners 1-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Questions and Answers 1-27 . . . . . . . . . . . . . . . . . . . . . . . .
Rear Comfort Guides 1-50 . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Seat Outside Passenger Positions 1-46 . . . . . . . . . . . .
Rear Seat Passengers 1-46 . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing After a Crash 1-91 . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-12
Trailer (Continued)
Towing 4-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn Signals 4-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Weight 4-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transaxle Fluid, Automatic 6-18 . . . . . . . . . . . . . . . . . . . . . . .
Transmitters, Keyless Entry 2-7 . . . . . . . . . . . . . . . . . . . . . . . .
Transportation, Courtesy 8-8 . . . . . . . . . . . . . . . . . . . . . . . . . .
Trip
Computer 2
-104 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer 2-87 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TTY Users 8-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn Signal and Lane Change Signals 2-56 . . . . . . . . . . . . . . .
Turn Signal Reminder on Chime 2-56 . . . . . . . . . . . . . . . . . . .
Turn Signal/Multifunction Lever 2-55 . . . . . . . . . . . . . . . . . . .
Turn Signals When Towing a Trailer 4-38 . . . . . . . . . . . . . . . .
Underbody Flushing Service 7-33 . . . . . . . . . . . . . . . . . . . . .
Underbody Maintenance 6-54 . . . . . . . . . . . . . . . . . . . . . . . . .
Underhood Fuse and Relay Center 6-61 . . . . . . . . . . . . . . . . .
Vehicle
Control 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Damage Warnings vii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions 6
-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification Number 6-56 . . . . . . . . . . . . . . . . . . . . . . . . .
Loading 4-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage 6-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ventilation System 3-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Visors
Lighted Vanity Mirrors 2
-80 . . . . . . . . . . . . . . . . . . . . . . . . .
Sun 2-79 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vanity Mirrors 2-79 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Devices 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Lights, Gages and Indicators 2-88 . . . . . . . . . . . . . . .
Warranty Information 8-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer Fluid, Windshield 6-26 . . . . . . . . . . . . . . . . . . . . . . . .
Washing Your Vehicle 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Weatherstrip Lubrication 7-31 . . . . . . . . . . . . . . . . . . . . . . . . .
Weatherstrips 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel
Alignment 6
-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nut Torque 5-29, 6-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement 6-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Used Replacement 6-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wrench 5-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 2-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Rear Quarter 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Side Latches 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Side Panels 2-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windshield Washer 2-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 2-57, 6-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid Level Check 7-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 2-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windshield Wiper 2-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 2-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blade Replacement 6-38 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Winter Driving 4-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiper Blade Check 7-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiper Blades, Cleaning 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring, Headlamp 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wrench, Wheel 5-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .