1999 CHEVROLET TRACKER heating

5-
Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
5-1
Section 5 Problems on the Road
Here you'll find what to do about some problems that can occur on the road.
5
-2 Hazard Warning Flashers
5
-2 Other Warning Devices
5
-3 Jump Starting
5
-8 Towing Your Vehicle
5
-8 Engine Overheating5
-11 Cooling System
5
-18 If a Tire Goes Flat
5
-18 Changing a Flat Tire
5
-28 If You're Stuck: In Sand, Mud, Ice or Snow

Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
5-8
Towing Your Vehicle
CAUTION:
To help avoid serious personal injury to you
or others:

Never let passengers ride in a vehicle that is
being towed.

Never tow faster than safe or posted speeds.

Never tow with damaged parts not
fully secured.

Never get under your vehicle after it has
been lifted by the tow truck.

Always secure the vehicle on each side with
separate safety chains when towing it.

Use only the correct hooks.
NOTICE:
Use the proper towing equipment to avoid
damage to the bumper, fascia or fog lamp areas
of the vehicle.
With current trends in automotive styles and design, it is
essential that the correct towing equipment is used to
tow a vehicle. Your vehicle can be towed with wheel
-lift
or car carrier equipment.
Consult your dealer or a professional towing service if
you need to have your vehicle towed. See ªRoadside
Assistanceº in the Index.
Engine Overheating
You will find a coolant temperature gage on your
vehicle's instrument panel. See ªEngine Coolant
Temperature Gageº in the Index.

Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
6-28
When the differential is cold, add enough lubricant to raise
the level to 1/2 inch (12 mm) below the filler plug hole.
When the differential is at operating temperature
(warm), add enough lubricant to raise the level to the
bottom of the filler plug hole.
What to Use
Refer to the Maintenance Schedule to determine what
kind of lubricant to use. See ªRecommended Fluids and
Lubricantsº in the Index.
Radiator Pressure Cap
JE±15±0026±X
NOTICE:
Your radiator cap is a 15.6 psi (110 kPa)
pressure
-type cap and must be tightly installed to
prevent coolant loss and possible engine damage
from overheating. Be sure the arrows on the cap
line up with the overflow tube on the radiator
filler neck.
When you replace your radiator pressure cap, an
ACDelco
cap is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a preset temperature.
When you replace your thermostat, an ACDelco


thermostat is recommended.

Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
6-29
Engine Coolant
The following explains your cooling system and how to
add coolant when it is low. If you have a problem with
engine overheating, see ªEngine Overheatingº in
the Index.
A 50/50 mixture of clean, drinkable water and the
proper coolant will:

Give freezing protection down to
-33F (-36C).

Give boiling protection up to 258F (125C).

Protect against rust and corrosion.

Help keep the proper engine temperature.

Let the warning lights and gages work as
they should.
What to Use
Use a mixture of one-half clean, drinkable water and
one
-half coolant that meets GM Specification 1825-M,
which won't damage aluminum parts. You can also use
a recycled coolant conforming to GM Specification
1825
-M with a complete coolant flush and refill.
If you use this coolant mixture, you don't need to add
anything else.
CAUTION:
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mixture will. Your vehicle's coolant
warning system is set for the proper coolant
mixture. With plain water or the wrong mixture,
your engine could get too hot but you wouldn't
get the overheat warning. Your engine could
catch fire and you or others could be burned.
Use a 50/50 mixture of clean, drinkable water
and the proper coolant.

Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
6-42 Dome Lamp
1. Gently pry the dome lamp lens from the lamp
assembly using a flat
-head screwdriver.
2. Remove the bulb by gently opening the retaining clip
and sliding the bulb out.
3. Insert a new bulb. Make sure that it is
seated properly.
4. Snap the dome lamp lens back into the dome
lamp assembly.
Tires
Your new vehicle comes with high-quality tires made by
a leading tire manufacturer. If you ever have questions
about your tire warranty and where to obtain service, see
your Chevrolet Warranty booklet for details.
CAUTION:
Poorly maintained and improperly used tires
are dangerous.

Overloading your tires can cause
overheating as a result of too much friction.
You could have an air
-out and a serious
accident. See ªLoading Your Vehicleº in
the Index.

Underinflated tires pose the same danger as
overloaded tires. The resulting accident
could cause serious injury. Check all tires
frequently to maintain the recommended
pressure. Tire pressure should be checked
when your tires are cold.

Overinflated tires are more likely to be
cut, punctured or broken by a sudden
impact
-- such as when you hit a pothole.
Keep tires at the recommended pressure.

Worn, old tires can cause accidents. If your
tread is badly worn, or if your tires have
been damaged, replace them.

Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
9-3
Damage
Finish 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sheet Metal 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Daytime Running Lamps 2-37 . . . . . . . . . . . . . . . . . . . . . . . . .
Dead Battery 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defects, Reporting Safety 8-10 . . . . . . . . . . . . . . . . . . . . . . . .
Defensive Driving 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defogger, Rear Window 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . .
Defogging 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defrosting 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions, Vehicle 6-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dome Lamp Bulb Replacement 6-42 . . . . . . . . . . . . . . . . . . . .
Dome Lamps 2-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door
Locks 2
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Downshifting 2-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drive Position, Automatic Transmission 2-16 . . . . . . . . . . . . .
Driver Position 1-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driving
City 4
-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defensive 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drunken 4-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Freeway 4-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Guidelines 4-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In a Blizzard 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In Foreign Countries 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
In the Rain 4-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Night 4-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road 4-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Curves 4-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Grades 4-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Hill and Mountain Roads 4-36 . . . . . . . . . . . . . . . . . . . .
On Snow and Ice 4-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Through Water 4
-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wet Roads 4-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Winter 4-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drunken Driving 4-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Easy Entry Seat 1-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Equipment, Adding 2-14, 3-14, 6-60 . . . . . . . . . . .
Electrical System 6-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine 6-11, 6-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant 6-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant Level Check 7-45 . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant Temperature Gage 2-63 . . . . . . . . . . . . . . . . . . . . .
Exhaust 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse Block 6-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification 6-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Level Check 7-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 5-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Running While Parked 2-28 . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 6-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your 2-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Compartment Fuse Block 6-62 . . . . . . . . . . . . . . . . . .
Engine Oil 6-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding 6-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Additives 6-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 6-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Used 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What Kind to Use 6-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
When to Change 6-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment, Adding to the Outside of Your Vehicle 6-3 . . . . . .
Ethanol 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
9-4
Exhaust, Engine 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Lamps 2-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fabric Cleaning 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fifth Gear, Manual Transmission 2-19 . . . . . . . . . . . . . . . . . . .
Filling a Portable Fuel Container 6-8 . . . . . . . . . . . . . . . . . . . .
Filling Your Tank 6-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filter, Engine/Air 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filter, Passenger Compartment 6-19 . . . . . . . . . . . . . . . . . . . .
Finish Care 6-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Finish Damage 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
First Gear, Manual Transmission 2-19 . . . . . . . . . . . . . . . . . . .
Flashers, Hazard Warning 5-2 . . . . . . . . . . . . . . . . . . . . . . . . .
Flash-to-Pass 2-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flat Tire, Changing 5-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid
Capacities 6
-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Level Check 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluids and Lubricants 7-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Foreign Countries, Fuel 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Four Wheel Drive (4WD) Light 2-67 . . . . . . . . . . . . . . . . . . . .
Fourth Gear, Manual Transmission 2-19 . . . . . . . . . . . . . . . . .
Four-Wheel Drive 2-20, 6-26 . . . . . . . . . . . . . . . . . . . . . . . . .
French Language Manual ii. . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Axle 6
-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Sidemarker Lamp Bulb Replacement 6-40 . . . . . . . . . . .
Front Turn Signal Lamp Bulb Replacement 6-40 . . . . . . . . . .
Fuel 6-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Lock 6-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filling a Portable Container 6-8 . . . . . . . . . . . . . . . . . . . . . .
Filling Your Tank 6-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gage 2-68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In Foreign Countries 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses and Circuit Breakers 6-60 . . . . . . . . . . . . . . . . . . . . . . .
Gages
Engine Coolant Temperature 2-63 . . . . . . . . . . . . . . . . . . . .
Fuel 2-68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GAWR 4-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Positions, Automatic Transmission 2-14 . . . . . . . . . . . . .
Gear Positions, Manual Transmission 2-19 . . . . . . . . . . . . . . .
Glove Box 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GM Mobility Program 8-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gross Axle Weight Rating 4-45 . . . . . . . . . . . . . . . . . . . . . . . .
Gross Vehicle Weight Rating 4-45 . . . . . . . . . . . . . . . . . . . . . .
Guide en Fran†ais ii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GVWR 4
-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Halogen Bulbs 6-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hazard Warning Flashers 5-2 . . . . . . . . . . . . . . . . . . . . . . . . . .
Head Restraints 1-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Headlamps 2-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bulb Replacement 6-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
High/Low Beam Changer 2-31 . . . . . . . . . . . . . . . . . . . . . .
Hearing Impaired, Customer Assistance 8-4 . . . . . . . . . . . . . .
Heating 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Highway Hypnosis 4-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hill and Mountain Roads 4-36 . . . . . . . . . . . . . . . . . . . . . . . . .
Hitches, Trailer 4-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hood
Checking Things Under 6
-9 . . . . . . . . . . . . . . . . . . . . . . . . .
Prop 6-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Release 6-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hood Latch Operation Check 7-45 . . . . . . . . . . . . . . . . . . . . .
Horn 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Clutch 6-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydroplaning 4-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Second Printing for Chevrolet Tracker Owner's Manual ± 1999
yellowblue
9-6
Low, Automatic Transmission 2-17 . . . . . . . . . . . . . . . . . . . . .
Lowering and Raising the Canvas Top 2-54 . . . . . . . . . . . . . .
Lubricants and Fluids 7-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication Service, Body 7-46 . . . . . . . . . . . . . . . . . . . . . . . .
Luggage Carrier 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance, Normal Replacement Parts 6-65 . . . . . . . . . . .
Maintenance Record 7-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance Schedule 7-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How it is Organized 7-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Introduction 7-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Long Trip 7-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Long Trip/Highway Definition 7-7 . . . . . . . . . . . . . . . . . . .
Long Trip/Highway Intervals 7-7 . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-45 . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-49 . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants 7-51 . . . . . . . . . . . . .
Scheduled Maintenance Services 7-4 . . . . . . . . . . . . . . . . . .
Short Trip 7-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Short Trip/City Definition 7-5 . . . . . . . . . . . . . . . . . . . . . . .
Short Trip/City Intervals 7-5 . . . . . . . . . . . . . . . . . . . . . . . .
Your Vehicle and the Environment 7-2 . . . . . . . . . . . . . . . .
Maintenance, Underbody 6-57 . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance When Trailer Towing 4-53 . . . . . . . . . . . . . . . . .
Malfunction Indicator Lamp 2-64 . . . . . . . . . . . . . . . . . . . . . .
Manual Adjust Mirror 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Front Seat 1-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission
Fluid 6
-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting 2-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your Engine 2-13 . . . . . . . . . . . . . . . . . . . . . . . . . .
Methanol 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Mirrors 2
-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convex Outside 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Adjust 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Remote Control 2-40 . . . . . . . . . . . . . . . . . . . . . . . . .
MMT 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mobility Program 8-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model Reference iii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mountain Roads 4
-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Multifunction Lever 2-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Neutral
Automatic Transmission 2-16 . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission 2-19 . . . . . . . . . . . . . . . . . . . . . . . . . .
New Vehicle Break-In 2-11 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Night Vision 4-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer 2-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer, Trip 2-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Driving 4-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Recovery 4-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 6-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Pressure Light 2-66, 6-13 . . . . . . . . . . . . . . . . . . . . . . . . .
Overdrive, Automatic Transmission 2-18 . . . . . . . . . . . . . . . .
Overdrive Off Light 2-68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating Engine 5-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-45 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-11 . . . . . . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-57 . . . . . . . . . . . . . . . . . . . . . . . .
Park
Automatic Transmission 2
-14 . . . . . . . . . . . . . . . . . . . . . . .
Shifting Into 2-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Out of 2-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .