1999 CHEVROLET S10 check engine light

yellowblue
4-7
Avoid needless heavy braking. Some people drive in
spurts
-- heavy acceleration followed by heavy
braking
-- rather than keeping pace with traffic. This is a
mistake. Your brakes may not have time to cool between
hard stops. Your brakes will wear out much faster if you
do a lot of heavy braking. If you keep pace with the
traffic and allow realistic following distances, you will
eliminate a lot of unnecessary braking. That means
better braking and longer brake life.
If your engine ever stops while you're driving, brake
normally but don't pump your brakes. If you do, the
pedal may get harder to push down. If your engine
stops, you will still have some power brake assist. But
you will use it when you brake. Once the power assist is
used up, it may take longer to stop and the brake pedal
will be harder to push.
Anti-Lock Brakes (ABS)
Your vehicle has anti-lock brakes (ABS). ABS is an
advanced electronic braking system that will help
prevent a braking skid.
When you start your engine and begin to drive away,
your anti
-lock brake system will check itself. You may
hear a momentary motor or clicking noise while this test
is going on. This is normal.
If there's a problem with the
anti
-lock brake system, this
warning light will stay on.
See ªAnti
-Lock Brake
System Warning Lightº in
the Index.

yellowblue
4-39
You can run the engine to keep warm, but be careful.
CAUTION:
Snow can trap exhaust gases under your vehicle.
This can cause deadly CO (carbon monoxide) gas
to get inside. CO could overcome you and kill
you. You can't see it or smell it, so you might not
know it is in your vehicle. Clear away snow from
around the base of your vehicle, especially any
that is blocking your exhaust pipe. And check
around again from time to time to be sure snow
doesn't collect there.
Open a window just a little on the side of the
vehicle that's away from the wind. This will help
keep CO out.
Run your engine only as long as you must. This saves
fuel. When you run the engine, make it go a little faster
than just idle. That is, push the accelerator slightly. This
uses less fuel for the heat that you get and it keeps the
battery charged. You will need a well
-charged battery to
restart the vehicle, and possibly for signaling later on
with your headlamps. Let the heater run for a while.Then, shut the engine off and close the window almost
all the way to preserve the heat. Start the engine again
and repeat this only when you feel really uncomfortable
from the cold. But do it as little as possible. Preserve the
fuel as long as you can. To help keep warm, you can get
out of the vehicle and do some fairly vigorous exercises
every half hour or so until help comes.
Recreational Vehicle Towing
Your vehicle should not be towed with all four wheels
on the ground. Your transmission has no provision for
internal lubrication while being towed. To properly tow
your vehicle, it should be placed on a platform trailer
with all four wheels off the ground. Towing with all four
wheels on the ground should be avoided.
In rare cases when it's unavoidable and your vehicle
must be towed with all four wheels on the ground, the
propeller shaft to axle yoke orientation should be
marked and the propeller shaft removed following
the applicable service manual removal/installation
procedure. See ªService and Owner Publicationsº in
the Index.

yellowblue
6-21
Check the fluid level only when your engine is off, the
vehicle is parked on a level place and the transmission is
cool enough for you to rest your fingers on the
transmission case.
Then, follow these steps:
1. Remove the filler plug.
2. Check that the lubricant level is up to the bottom of
the filler plug hole.
3. If the fluid level is good, install the plug and be sure
it is fully seated. If the fluid level is low, add more
fluid as described in the next steps.
How to Add Fluid
Here's how to add fluid. Refer to the Maintenance
Schedule to determine what kind of fluid to use. See
ªRecommended Fluids and Lubricantsº in the Index.
1. Remove the filler plug.
2. Add fluid at the filler plug hole. Add only enough
fluid to bring the fluid level up to the bottom of the
filler plug hole.
3. Install the filler plug. Be sure the plug is fully seated.
Hydraulic Clutch
The hydraulic clutch system in your vehicle is
self
-adjusting. A slight amount of play (1/4 inch to
1/2 inch or 6 mm to 12 mm) in the pedal is normal.
It isn't a good idea to ªtop offº your clutch fluid.
Adding fluid won't correct a leak. A fluid loss in this
system could indicate a problem. Have the system
inspected and repaired.

yellowblue
7-42
Part B: Owner Checks and Services
Listed in this part are owner checks and services which
should be performed at the intervals specified to help
ensure the safety, dependability and emission control
performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your vehicle,
make sure they are the proper ones, as shown in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil if necessary.
See ªEngine Oilº in the Index for further details.
Engine Coolant Level Check
Check the engine coolant level and add DEX
-COOL

coolant mixture if necessary. See ªEngine Coolantº in
the Index for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the windshield
washer tank and add the proper fluid if necessary. See
ªWindshield Washer Fluidº in the Index for further details.
At Least Once a Month
Tire Inflation Check
Make sure tires are inflated to the correct pressures.
See ªTiresº in the Index for further details.
Cassette Deck Service
Clean cassette deck. Cleaning should be done every
50 hours of tape play. See ªAudio Systemsº in the
Index for further details.
At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag system
does not need regular maintenance.)

yellowblue
9-5
Hearing Impaired, Customer Assistance 8-4 . . . . . . . . . . . . . .
Heated Outside Rearview Mirrors 2-46 . . . . . . . . . . . . . . . . . .
Heating 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
High/Low Beam Changer 2-36 . . . . . . . . . . . . . . . . . . . . . . . .
Highway Hypnosis 4-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hill and Mountain Roads 4-34 . . . . . . . . . . . . . . . . . . . . . . . . .
Hitches, Trailer 4-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hood 6-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Horn 2-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Horsepower 6-67 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Clutch 6-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check 7-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-21, 7-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydroplaning 4-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition
Positions 2-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Lock Check 7-45 . . . . . . . . . . . . . . . . . . . . . .
Illuminated Entry 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation, Tire 6-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside Day/Night Rearview Mirror 2-45 . . . . . . . . . . . . . . . . .
Inspections
Brake System 7
-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drive Axle 7-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Cooling System 7-46 . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Drive Axle Boot Seal 7-46 . . . . . . . . . . . . . . . . . . . . .
Steering 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle System 7-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transfer Case 7-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Instrument Panel 2
-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cluster 2-52, 2-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse Block 6-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior Lamps 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jack, Tire 5-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Seat 1-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Key in the Ignition 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Key Lock Cylinders Service 7-43 . . . . . . . . . . . . . . . . . . . . . .
Key Release Button 2-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Keyless Entry System 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Keys 2-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Labels
Certification/Tire 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse 6-63, 6-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Parts Identification 6-60 . . . . . . . . . . . . . . . . . . . . .
Vehicle Identification Number 6-60 . . . . . . . . . . . . . . . . . . .
Lamps 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dome 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Map 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lamps On Reminder 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Latches, Seatback 1-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Leaving Your Vehicle 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Leaving Your Vehicle with the Engine Running 2-28 . . . . . . .
Lighter 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-6
Lights
Air Bag Off 1-28, 2-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag Readiness 1-22, 2-56 . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock Brake System Warning 2-60, 4-7 . . . . . . . . . . . .
Brake System Warning 2-60 . . . . . . . . . . . . . . . . . . . . . . . . .
Charging System 2-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Gages 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Fuel 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Reminder 1-7, 2-55 . . . . . . . . . . . . . . . . . . . . . .
Security Warning 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service 4WD 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Engine Soon 2-61 . . . . . . . . . . . . . . . . . . . . . . . . . .
Shift 2-23, 2-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading, Truck-Camper 4-43 . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Your Vehicle 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Your Vehicle Off-Road Driving 4-14 . . . . . . . . . . . .
Locking Rear Axle 2-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lockout Prevention 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Locks
Door 2
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Transmission Check 7-45 . . . . . . . . . . . . . . . . . . . .
Key Lock Cylinder Service 7-43 . . . . . . . . . . . . . . . . . . . . .
Power Door 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loss of Control 4-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Fuel Light 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubricants and Fluids 7-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication Service
Body 7
-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tailgate 7-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lumbar Controls 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance Record 7-51 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance Schedule 7-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Long Trip/Highway 7-6, 7-29 . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-42 . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-46 . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants 7-48 . . . . . . . . . . . . .
Scheduled Maintenance Services 7-4 . . . . . . . . . . . . . . . . . .
Short Trip/City 7-5, 7-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance, Underbody 6-58 . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance When Trailer Towing 4-54 . . . . . . . . . . . . . . . . .
Malfunction Indicator Lamp 2-61 . . . . . . . . . . . . . . . . . . . . . .
Manual Front Seat 1-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Lumbar Support 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission
Check 7
-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-20, 7-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 2-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting 2-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Methanol 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirrors 2-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convex Outside 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Illuminated Visor Vanity 2-49 . . . . . . . . . . . . . . . . . . . . . . .
Inside Day/Night Rearview 2-45 . . . . . . . . . . . . . . . . . . . . .
Power Remote Control 2-45 . . . . . . . . . . . . . . . . . . . . . . . . .
Visor Vanity 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model Reference vi. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mountain Roads 4
-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Multifunction Lever 2-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Neutral
Automatic Transmission 2-20 . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission 2-22 . . . . . . . . . . . . . . . . . . . . . . . . . .
New Vehicle ªBreak-Inº 2-12 . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-8
Rearview Mirror 2-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reclining Front Seatbacks 1-3 . . . . . . . . . . . . . . . . . . . . . . . . .
Recovery Hooks 5-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recovery Tank, Coolant 5-13, 6-26 . . . . . . . . . . . . . . . . . . . . .
Recreational Vehicle Towing 4-39 . . . . . . . . . . . . . . . . . . . . . .
Replacement Bulbs 6-67 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement Parts 6-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement, Wheel 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reporting Safety Defects 8-10 . . . . . . . . . . . . . . . . . . . . . . . . .
Restraints
Check 7
-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Child 1-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Parts After a Crash 1-52 . . . . . . . . . . . . . . . . . . .
Retained Accessory Power 2-15 . . . . . . . . . . . . . . . . . . . . . . . .
Reverse
Automatic Transmission 2
-19 . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission 2-22 . . . . . . . . . . . . . . . . . . . . . . . . . .
Right Front Passenger Position 1-20 . . . . . . . . . . . . . . . . . . . .
Roadside Assistance 8-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Canadian 8-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rocking Your Vehicle 5-33 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotation, Tires 6-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belts 1-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adults 1-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Care 6-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Center Passenger Position 1-31 . . . . . . . . . . . . . . . . . . . . . .
Children 1-34, 1-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver Position 1-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Extender 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How to Wear Properly 1-12 . . . . . . . . . . . . . . . . . . . . . . . . .
Label 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Lap Belt 1
-31, 1-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lap-Shoulder 1-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Questions and Answers 1-11 . . . . . . . . . . . . . . . . . . . . . . . .
Rear Seat Passengers 1-33 . . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder Light 1-7, 2-55 . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing After a Crash 1-52 . . . . . . . . . . . . . . . . . . . . . . . .
Right Front Passenger Position 1-20 . . . . . . . . . . . . . . . . . .
Use During Pregnancy 1-19 . . . . . . . . . . . . . . . . . . . . . . . . .
Why They Work 1-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Chains 4-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Defects, Reporting 8-10 . . . . . . . . . . . . . . . . . . . . . . . .
Safety Warnings and Symbols iii. . . . . . . . . . . . . . . . . . . . . . .
Scheduled Maintenance Services 7
-4 . . . . . . . . . . . . . . . . . . . .
Seatback
Latches 1
-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reclining Front 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seats 1-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seats and Restraint Systems 1-1 . . . . . . . . . . . . . . . . . . . . . . . .
Second Gear
Automatic Transmission 2
-20 . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission 2-22 . . . . . . . . . . . . . . . . . . . . . . . . . .
Security Warning Light 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . .
Service 4WD Light 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service and Appearance Care 6-1 . . . . . . . . . . . . . . . . . . . . . .
Service Engine Soon Light 2-61 . . . . . . . . . . . . . . . . . . . . . . .
Service Parts Identification Label 6-60 . . . . . . . . . . . . . . . . . .
Service Publications 8-12, 8-13 . . . . . . . . . . . . . . . . . . . . . . . .
Service Work, Doing Your Own 6-2 . . . . . . . . . . . . . . . . . . . .
Sheet Metal Damage 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shift Light 2-23, 2-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting 2-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Into Park 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Out of Park 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Side Access Panel 2-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .