1999 CHEVROLET LUMINA radiator

yellowblue
6-26
CAUTION:
Turning the radiator pressure cap when the
engine and radiator are hot can allow steam
and scalding liquids to blow out and burn you
badly. With the coolant recovery tank, you will
almost never have to add coolant at the radiator.
Never turn the radiator pressure cap
-- even a
little
-- when the engine and radiator are hot.
CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don't spill coolant on a hot engine.
Power Steering Fluid
3100 (Code M)
V6 Engine 3800 (Code K)
V6 Engine
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless you suspect there is a leak in the system or
you hear an unusual noise. A fluid loss in this system
could indicate a problem. Have the system inspected
and repaired.

yellowblue
6-34
4. Install the electrical connector to the bulb.
5. Install the new bulb by inserting the smallest tab
on the bulb base into the matching notch in the
retaining ring. Turn the bulb a quarter
-turn clockwise
until it stops.
6. Close the hood.
Front Parking and Turn Signal Lamp
1. Open the hood. There is one flap on each side of
the radiator.
2. Open the flap by lifting the tab.

yellowblue
6-35
3. Position the radiator air side baffle aside and remove
the two fasteners. Remove the snap screw from
the fascia.4. Slide the headlamp assembly inboard to release the
mounting tabs and gently pull the inside of the
assembly away from the vehicle.
5. Push the tab on the bulb socket and turn
it counterclockwise. Pull the socket out of
the assembly.
6. Remove the bulb from the socket by pulling it out.
Do not twist the bulb.
7. Push in the new bulb.
8. Reverse Steps 1 through 4 to replace the assembly.

yellowblue
6-65
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same. If the
air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used. If
you're not sure, ask your dealer.
Normal Maintenance
Replacement Parts
Engine Air Cleaner/Filter
All Engines A1208C. . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery
3100 (Code M) V6 600 CCA. . . . . . . . . . . . . . . . . .
3800 (Code K) V6 690 CCA. . . . . . . . . . . . . . . . . . .
Engine Oil Filter
3100 (Code M) V6 PF47. . . . . . . . . . . . . . . . . . . . .
3800 (Code K) V6 PF47. . . . . . . . . . . . . . . . . . . . . .
PCV Valve
3100 (Code M) V6 CV892C. . . . . . . . . . . . . . . . . . . . Radiator Cap
All Engines RC27. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spark Plugs
3100 (Code M) V6 AC Type 41
-940 . . . . . . . . . . . . . .
Gap: 0.060 inches (.152 cm)
3800 (Code K) V6 AC Type 41
-921 . . . . . . . . . . . . . .
Gap: 0.060 inches (1.52 cm)
Windshield Wiper
Length 22 inches (56 cm). . . . . . . . . . . . . . . . . . . . .
Type hook. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle Dimensions
Wheelbase 107.5 inches (273.0 cm). . . . . . . . . . . . . .
Tread Width (Front) 59.5 inches (151.2 cm). . . . . . . .
Tread Width (Rear) 59.1 inches (150.0 cm). . . . . . . .
Length 200.9 inches (510.4 cm). . . . . . . . . . . . . . . . .
Width 72.5 inches (184.1 cm). . . . . . . . . . . . . . . . . . .
Height 54.8 inches (139.2 cm). . . . . . . . . . . . . . . . . . .

Scheduled Maintenance
yellowblue
7-12
100,000 Miles (166 000 km)
Inspect spark plug wires.
An Emission Control Service.
Replace spark plugs.
An Emission Control Service.
Change automatic transaxle fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
± In heavy city traffic where the outside temperature regularly reaches 90
F
(32
C) or higher.
± In hilly or mountainous terrain.
± When doing frequent trailer towing.
± Uses such as found in taxi, police or delivery service.
If you haven't used your vehicle under severe service conditions listed
previously and, therefore, haven't changed your automatic transaxle fluid,
change both the fluid and filter.
150,000 Miles (240 000 km)
Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See ªEngine Coolantº in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Service.
ACTUAL
SERVICED BY:MILEAGE
DATE
ACTUAL
SERVICED BY:MILEAGE
DATE

yellowblue
7-18 Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the outside
of the radiator and air conditioning condenser. To help
ensure proper operation, a pressure test of the cooling
system and pressure cap is recommended at least once
a year.
Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook
-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.

yellowblue
9-3
Cleaning 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum Wheels 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Lamps/Lenses 6-51 . . . . . . . . . . . . . . . . . . . . . . . .
Fabric 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fabric Protection 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glass Surfaces 6-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside of Your Vehicle 6-47 . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument Panel 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior Plastic Components 6-49 . . . . . . . . . . . . . . . . . . . . .
Leather 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside of Your Vehicle 6-51 . . . . . . . . . . . . . . . . . . . . . . . .
Special Problems 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stains 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tires 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vinyl 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheels 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windshield and Wiper Blades 6-50 . . . . . . . . . . . . . . . . . . .
Climate Control System 3-2 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clock, for Systems with Automatic Tone Control,
Setting the 3
-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clock, for Systems without Automatic Tone Control,
Setting the 3
-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Comfort Controls 3-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compact Disc Player
Care 3
-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Errors 3-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compact Spare Tire 5-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Console Storage 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Control of a Vehicle 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convenience Net 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Convex Outside Mirror 2
-40 . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant 6-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bleed Valves 5-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heater, Engine 2-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator 5-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recovery Tank 5-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What to Use 6-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
When Trailer Towing 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling System 5-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Courtesy Lamps 2-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Courtesy Transportation 8-8 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cruise Control 2-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cupholders 2-40, 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Customer Assistance
for Text Telephone Users 8
-4 . . . . . . . . . . . . . . . . . . . . . . . .
Information 8-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Offices 8-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Customer Satisfaction Procedure 8-2 . . . . . . . . . . . . . . . . . . . .
Damage
Finish 6-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sheet Metal 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Daytime Running Lamps 2-36 . . . . . . . . . . . . . . . . . . . . . . . . .
Dead Battery 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defects, Reporting Safety 8-10 . . . . . . . . . . . . . . . . . . . . . . . .
Defensive Driving 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-8
Paint Spotting, Chemical 6-53 . . . . . . . . . . . . . . . . . . . . . . . .
Park
Automatic Transaxle 2
-19 . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Into 2-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Out of 2-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking
At Night 2
-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake 2-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake and Automatic Transaxle PARK (P)
Mechanism Check 7
-16 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lots 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-27 . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking On Hills, Leaving 4-40 . . . . . . . . . . . . . . . . . . . . . . . .
Passenger Position 1-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passing 4-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PASS-Key
II 2-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-17 . . . . . . . . . . . . . . . . . .
Portable Fuel Container, Filling 6-7 . . . . . . . . . . . . . . . . . . . . .
Power
Door Locks 2
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Fuses 6-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside Mirrors 2-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat 1-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Fluid 6-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-19 . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-12 . . . . . . . . . . . . . . . . . . .
Radiator Pressure Cap 6-22 . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio Reception 3-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radios 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rain, Driving In 4-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rain, Other Tips 4-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reading Lamps, Rearview Mirror 2-38 . . . . . . . . . . . . . . . . . .
Rear
Door Child Security Locks 2
-5 . . . . . . . . . . . . . . . . . . . . . .
Outside Seat Position 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Comfort Guides 1-30 . . . . . . . . . . . . . . . . . . . . .
Seat Passengers 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Window Defogger 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rearview Mirror, Inside Day/Night 2-39 . . . . . . . . . . . . . . . . .
Reclining Front Seatbacks 1-4 . . . . . . . . . . . . . . . . . . . . . . . . .
Recovery Tank, Coolant 5-15 . . . . . . . . . . . . . . . . . . . . . . . . . .
Recreational Vehicle Towing 4-30 . . . . . . . . . . . . . . . . . . . . . .
Refrigerants, Air Conditioning 6-65 . . . . . . . . . . . . . . . . . . . .
Remote
Keyless Entry 2
-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk Release 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement
Bulbs 6
-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts 6-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel 6-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Safety Belts 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reporting Safety Defects 8-10 . . . . . . . . . . . . . . . . . . . . . . . . .
Restraints
Care of Safety Belts 6
-50 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Child 1-36, 1-40, 1-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .