1998 VOLVO V90 air filter

1998 Volvo S90
Volvo allows the use of the
following "oxygenated fuels";
however, the octane ratings
listed on this page must still be
met. of fuel. Therefore, it is
advisable to refuel as soon as
possible when the needle nears
the red zone, or when the fuel
warning light comes on.
Driving economy pg. 56
Economical driving
conserves natural
resources

Better driving economy may be
obtained by thinking ahead,
avoiding rapid starts and stops
and adjusting the speed of your
vehicle to immediate traffic
conditions. Observe the
following rules:

l Bring the engine to normal
operating temperature as soon
as possible by driving with a
light foot on the accelerator
pedal for the first few minutes
of operation. A cold engine
uses more fuel and is subject to
increased wear.

l Whenever possible, avoid
using the car for driving short
distances. This does not allow
the engine to reach normal
operating temperature.

l Drive carefully and avoid
rapid acceleration and hard
braking.

l Do not exceed speed limit.

l Avoid carrying unnecessary
items (extra load) in the car.

l Check tire pressure regularly
l Remove snow tires when
threat of snow or ice has ended.

l Note that roof racks, ski
racks, etc., increase air
resistance and thereby fuel
consumption.

l Avoid using automatic
transmission kick-down feature
unless necessary.

l Avoid using the air
conditioning when it is not
required. When engaged, the
air conditioner's compressor
places places an additional load
on the engine. However, please
note that fuel consumption is
lower with the air conditioning
on than it is when driving with
the air conditioning switched
off and the windows down.

Other factors which decrease
gas mileage are:
l Worn or dirty spark plugs
l Incorrect spark plug gap
l Dirty air cleaner
l Dirty engine oil and clogged
oil filter
l Dragging brakes
l Incorrect front end alignment

Some of the above mentioned

file:///K|/ownersdocs/1998/1998_SV90/98S90_053.htm (4 of 6)12/30/2006 \
1:52:41 PM

1998 Volvo S90
Maintenance schedule

A= Adjust (Correct if necessary) I= Inspect (Correct or Replace if ne\
cessary)
R= Replace L= Lubricate
Maintenance Operation thousand
miles
(thousand km) 5
(8)
10
(16) 15
(25) 20
(32) 25
(40) 30
(48) 35
(56) 40
(64) 45
(72) 50
(80) 55
(88) 60
(96)
EMISSION SYSTEM
MAINTENANCE
Engine oil and filter R R R R R R R R R R R R
Engine drive belt (accessory belt) I R
Air cleaner filter R R
Spark plugs R R
Automatic transmission fluid I I I I I I
Timing belt - B 6304 S
4

1) See section "Engine oil" for detailed information.

NOTE: The oil should be changed at these intervals or after 750 hours of\
driving or after 12 months
which ever occurs first. See "Service Reminder indicator", page 19.

2) For services beyond 60,000 miles (96,000 km), consult your "Mainte\
nance Records booklet".
3) These intervals may apply, depending on actual driving conditions (\
see page 109 for details)
4) For proper functioning of the vehicle and its emission control syste\
m, Volvo recommends that the
file:///K|/ownersdocs/1998/1998_SV90/98S90_103.htm (5 of 7)12/30/2006 \
1:52:48 PM

1998 Volvo S90
extreme operating conditions such as trailer
towing in sustained ambient temperatures over
104° F (40° C). However, SAE 10W-30 synthetic
oil would be a better alternative in such
conditions.
SAE 15W-40 should not be used under normal
operating conditions.
American Petroleum Institute
(API) labels. These labels certify
the oil conforms to the applicable
standards and specifications of
the API.
Servicing pg. 110
Torque exhaust and
intake manifold nuts


A loose manifold could alter air/
fuel ratio and cause an increase
in emissions and/or poor
driveability.

Air cleaner

Replace the air cleaner cartridge
with a new one every 30,000
miles (48,000 km). The
cartridge should be replaced
more often when driving under
dirty and dusty conditions, The
filter cannot be cleaned and,
therefore, should always be
replaced with a new one.

Vacuum fittings, hoses
and connections


Unstable idle, misfiring, or poor
emission control is often caused
by leaking vacuum hoses or
connections. Check hoses and
connections on distributor
vacuum unit, connections on
heater control servo systems and
hydraulic brake servo.
Fuel system cap, tank
and lines, and
connections


The effectiveness of the fuel
system to contain hydrocarbons
is dependent largely on a
leakfree system. Check for
proper sealing of gasoline filler
cap which contains "O" ring-
type seals. Check all
evaporative hoses in vehicle for
tightness. Check fuel lines under
vehicle and repair if necessary.

Fuel (line) filter

The fuel line filter is located
next to the fuel pump. This filter
should be replaced every
100,000 miles (160,000 km).
The filter is replaced as one
complete unit.
Replace more frequently if
contaminated fuel is introduced
into the tank (or if there is
reason to suspect that this has
occurred).

Timing belt

WARNING!
The distributor ignition
system operates at very high
voltages. Special safety
precautions must be followed
to prevent injury.
Always turn the ignition off
when:
l Replacing distributor
ignition components e.g.
plugs, coil, etc.
l Do not touch any part of
the distributor ignition system
while the engine is running.
This may result in unintended
movements and body injury.


Replacing spark plugs

The spark plugs should be
changed every 30,000 miles
(48,000 km). However, city
driving or fast highway driving
may necessitate changing after
15,000 miles (24,000 km) of
driving. When installing new
plugs, be sure to fit the right type
file:///K|/ownersdocs/1998/1998_SV90/98S90_108.htm (3 of 6)12/30/2006 \
1:52:49 PM

1998 Volvo S90

Idle air control system

Your Volvo is equipped with an
electronically-controlled idle air
control system that requires no
checking or adjustment.
Volvo recommends that the
timing belt be replaced every
70,000 miles (112,000 km).

PCV system

The orifice nipple in the intake
manifold and the filter at the
end of the PCV hose in the
aircleaner should be inspected
every 60,000 miles (96,000 km).
Check/replace rubber hoses at
the same time.
and use correct torque, see
Specifications. When changing
the plugs, check that the
suppressor connectors are in
good condition. Cracked or
damaged connectors should be
replaced.
When changing the spark plugs,
clean the terminals and the
rubber seals.
Battery maintenance pg. 111
Battery maintenance

Driving habits and conditions, climate, the
number of starts, etc. all affect the service life and
function of the battery. In order for your battery to
perform satisfactorily, keep the following in mind:
l Check the fluid level in the battery every 6
months or every 10,000 * miles (16,000 km).
The fluid level in each battery cell should be
checked - use a screw driver to open the caps and
a flashlight to inspect the level.
*More frequently in warm climates.
l If necessary, add distilled water to
approximately 0.4 in. (10 mm) above the plates in
the cell or to the level indicator. See the
illustrations above.
l Check that the battery cables are correctly
connected and properly tightened.
l Never disconnect the battery when the engine is
running, for example when changing the battery.
l The battery should be disconnected when a
boost charger is used.
l Switch off the radio before disconnecting the
battery. If your radio has an antitheft code and the
battery is disconnected, the radio code has to be
reentered in order for the radio to function.
Fuel/emissions systems pg. 112
file:///K|/ownersdocs/1998/1998_SV90/98S90_108.htm (4 of 6)12/30/2006 \
1:52:49 PM