1998 PONTIAC GRAND AM power steering

3100 (CODE M) Engine
When you open the hood, you’ll see:
A. Engine Coolant Surge Tank
B. Power Steering Fluid Reservoir
C. Engine Oil Fill Cap
D. Engine Oil Dipstick G. Windshield Washer
E. Automatic Transaxle Fluid Reservoir
Fluid Dipstick
H. Air Cleaner
E Brake Fluid Reservoir I. Battery

Surge Tank Pressure Cap
I NOTICE:
~~
Your pressure cap is an 15 psi (105 kPa)
pressure-type cap and must be tightly installed
to
prevent coolant loss and possible engine damage
from overheating.
When you replace your surge tank pressure cap, a GM
cap is recommended.
Thermostat
Power Steering Fluid
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a preset temperature.
When you replace your thermostat,
an ACDelco@
thermostat
is recommended.
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless you suspect there
is a leak in the system or
you hear an unusual noise.
A fluid loss in this system
could indicate
a problem. Have the system inspected
and repaired.
6-29

How To Check Power Steering Fluid
When the engine compartment is cool, wipe the cap and
the top of the reservoir clean, then unscrew the cap and
wipe the dipstick with a clean rag. Replace the cap and
completely tighten it. Then remove the cap again and
look at the fluid level on the dipstick.
The level should be at the
C mark. If necessary, add only
enough fluid to bring the level up to the mark.
What to Use
To determine what kind of fluid to use, see
“Recommended
Fluids and Lubricants” in the Index.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses
and seals.
Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer’s instructions before use. If you will be
operating your vehicle in
an area where the temperature
may
fall below freezing, use a fluid that has sufficient
protection against freezing.
Adding Washer Fluid
?
Open the cap labeled WASHER FLUID ONLY. Add
washer fluid until the
tank is full.
6-30

Fuse
PWR WDO
TURN
Usage
Power Window (Circuit Breaker)
Turn Signal Lamps
Fuse
INT LPS
PWR ST
RDO IGN
HTR-A/C
CRUISE
TAIL LPS
LTR
Usage
Alarm Module (Illuminated Entry,
Warning Chimes, Overhead
Lamps, MapReading Lamps,
Glove Box Lamp, Trunk Lamp,
Radio, Power Mirrors), Anti-Lock
Brakes, Variable Effort Steering
Power Seat
Radio
Heater/Air Conditioning Blower,
Daytime Running Lamps, Automatic Light Control
Cruise Control
Parking Lamps, Taillamps, Sidemarker Lamps, License
Lamps, Instrument Panel Lights,
Headlamp Warning Alarm
Cigarette Lighter
6-61

Fuse
HVAC BLO
MOT
PCM BATT
CLG FAN
HDLP
STOP LPS
PWR ACC
RR DEFG
ABS
IGN SW
Usage
Heater/Air Conditioner-High
Blower, Generator-Voltage Sense
Powertrain Computer
Engine Cooling
Fan
Lighting Circuits
Power Accessories,
Stop Lamp Circuits,
Rear Window Defogger
Anti-Lock Brakes, Variable
Effort Steering
Ignition Switch Circuits
Steering Wheel Controls (If Equipped) Fuse Panel
Your steering wheel radio controls are protected by
fuses.
For service, contact your service department.
Replacement Bulbs
OUTSIDE LAMPS ..................... BULB
Back-up Lamps ......................... 2057
Front Parking/Turn Signal Lamps ........ 2057 NA
Halogen Headlamps Center High-Mounted Stoplamp
............. 9 12
Low-Beam ................... - _. . 9006
High-Beam ........................... 9005
Stop/Tail/Turn Signal Lamps ............... 2057
INSIDE LAMPS ....................... BULB
Dome Lamp ............................. 16 1
6-64

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your dealer’s service
department or other qualified service center do these
jobs. Make sure
any necessary repairs are completed
at once.
Proper procedures to perform these services may
be
found in a service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot
an.d Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose
or missing parts, signs of
wear or lack
of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect
the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing
or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build-up
in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in
the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside of the
radiator
and air conditioning condenser. To help ensure
proper operation, a pressure test of the cooling system and
pressure cap is recommended at least once
a year.
Throttle System Inspection
Inspect the throttle system for interference or binding, and for damaged or missing parts. Replace
parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
7-34

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may
be obtained from
your dealer.
USAGE
Engine Oil
Engine Coolant
FLUIDLUBRICANT I
Engine Oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and
use only
GM Goodwrench@ DEX-COOL@
or Havoline@
DEX-COOL’
Coolant. See “Engine Coolant” in
the Index.
USAGE
Delco Supreme 1 l@ Brake Fluid Hydraulic Brake
FLUIDLUBRICANT
equivalent DOT-3 Brake Fluid).
(GM
Part No. 12377967 or
System
Hydraulic Clutch
No. 12345347 or equivalent
System Hydraulic Clutch Fluid (GM
Part
DOT-3
Brake Fluid).
Power Steering
Superlube (GM
Part Cylinders Multi-Pygse
Lubricant,
Key
Lock Transmission Fluid.
Transaxle
DEXRON@-111 Automatic
Automatic
or equivalent).
(GM
Part No. 12345349
Transaxle Synchromesh Transmission Fluid
Manual
105001 7 - 1 quart, or equivalent).
Part NO. 1052884 - 1 pint,
System
GM Power Steering Fluid (GM
No. 12346241 or equivalent).
7-36

Section 9 Index
Accessory Power outlet ......................... 2-50
Adapter Kit. CD ........................... 3.12. 3.15
Adding Equipment to Your Vehicle .................. 6-3
Adjuster. Seat ..................... ..... 1.2. 1.52
AirBag ....................................... 1-21
How Does it Restrain .......................... 1-25
How it Works ................................ 1-23
Location .................................... 1-23
Readiness Light ......................... 1.23. 2.57
What Makes it Inflate .......................... 1-25
What Will You See After it Inflates ............... 1-26
When Should
it Inflate ......................... 1-25
Aircleaner .................................... 6-19
Airconditioning ................................ 3-2
Air Conditioning Refrigerants ..................... 6-65
Alignment and Balance. Tire ...................... 6-48
Aluminum Wheels. Cleaning ...................... 6-55
Antenna. Fixed ................................. 3-25
Antifreeze ..................................... 6-25
Anti-Lock Servicing
................................... 1-27
Brake System Warning Light ................ 2.59. 4.7
Brakes ...................................... 4-7
Anti.Theft.
Radio .............................. 3-20
Appearancecare ............................... 6-50
Appearance Care Materials ....................... 6-57
ArbitrationPro gram .............................. 8-9
Ashtrays ...................................... 2-49
Audio Controls. Steering Wheel Touch Control ....... 3-22
Audio Equipment. Adding ......... 2.17.2.18.3.24. 6.59
Audio Systems ............ .................. 3-7
Auto-Down Window ............................ 2-33
Automatic Transaxle Check ....................... 7-31
Automatic Transaxle Park Mechanism Check ......... 7-33
Automatic Door Locks ............................ 2-5
Automatic Light Control ......................... 2-43
Automatic Overdrive ............................ 2-23
Automatic Transaxle ............................ 2-16
Starting Your Engine .......................... 2-16
Automatic Transaxle Fluid
........................ 6-20
Automatic Transaxle Operation .................... 2-21
Shifting ..................................... 2-21
Backing up When Towing a Trailer ............. 4-39
Back-up Lamp Bulb Replacement ................. 6-40
Battery ....................................... 6-36
Charging System Indicator Light ................. 2-58
Jumpstarting ................................. 5-3
Replacement. Keyless Entry ..................... 2-9
Saver ...................................... 2-46
Warnings .................................... 5-3
BBB Auto Line ................................. 8-9
Before Leaving on a Long Trip .................... 4-23
Better Business Bureau Mediation ................... 8-9
9-1