1998 Lexus LS400 transmission

CHASSIS
237
SPECIFICATIONS
AUTOMATIC TRANSMISSION
Fluid capacity
Drain and refill
Fluid type
1.9 L (2.0 qt., 1.7 lmp.qt.)
Automatic transmission fluid Type T IV or equivalent
DIFFERENTIAL
Oil capacity
Oil type
Oil viscosity
1.3 L (1.4 qt., 1.1 lmp.qt.)
Hypoid gear oil API GL5
Above 18C (0F): SAE 90
Below 18C (0F): SAE 80W or SAE 80W90
BRAKES
Pedal clearance
Pedal freeplay
Brake pad wear limit
Parking brake lining wear limit
Parking brake adjustment
Fluid type
70 mm (2.8 in.) Min. *1
1 6 mm (0.04 0.24 in.)
1.0 mm (0.04 in.)
1.0 mm (0.04 in.)
5 7 clicks *
2
SAE J1703 or FMVSS No. 116 DOT 3
*1: Minimum pedal clearance when depressed with the pressure of 490 N (50 kgf, 110 lbf.) with the engine running
*
2: Parking brake adjustment when depressed with the pressure of 294 N (30 kgf, 66.1 lbf.)

CHASSIS
238 STEERING
Freeplay
Power steering fluid
Less than 30 mm (1.2 in.)
Automatic transmission fluid DEXRONII or III
TIRES AND WHEELS
Tire size
Tire inflation pressure
Recommended cold tire inflation pressure
Vehicle load up to four occupants
Vehicle loaded up to vehicle capacity weight
Wheel size
Wheel nut torque
P225/60R16 97V
Front 200 kPa (2.0 kgf/cm
2
or bar, 29 psi)
Rear 200 kPa (2.0 kgf/cm2 or bar, 29 psi)
Front 220 kPa (2.2 kgf/cm
2 or bar, 32 psi)
Rear 220 kPa (2.2 kgf/cm2 or bar, 32 psi)
For sustained high speeds above 160 km/h (100 mph), in
countries where such speeds are permitted by law, add 80 kPa (0.9
kgf/cm
2, 0.8 bar, 12 psi) to the front tires and rear tires, but never
exceed the maximum cold tire pressure molded on the tire
sidewall.
16 x 7 JJ
103 N·m (10.5 kgf·m, 76 ft·lbf.)

CHASSIS
240
CHECKING POWER STEERING
FLUID
63L0021
Check the fluid level on the dipstick. If necessary, add automatic
transmission fluid DEXRONII or III.
If the vehicle has been driven around 80 km/h (50 mph) for 20
minutes (a little more in frigid temperatures), the fluid is hot (60C
8 0C or 140F 175F). You may also check the level when the
fluid is cold (about room temperature, 10C 30C or 50F 85F)
if the engine has not been run for about five hours.
63L0031
1
If cold O.K. 2
If hot O.K. 3
Add fluid
1. Clean all dirt off the reservoir.
2. Remove the filler cap by turning it counterclockwise and wipe the
dipstick clean.
3. Reinstall the filler cap.
4. Remove the filler cap again and look at the fluid level. If the fluid
is cold, the level should be in the ”COLD” range on the dipstick.
Similarly, if it is hot, the fluid level should be in the ”HOT” range.
If the level is at the low side of either range, add automatic
transmission fluid DEXRON
II or III to bring the level within the
range.
5. After replacing the filler cap, visually check the steering box case,
vane pump and hose connections for leaks or damage.

ELECTRICAL COMPONENTS
251
No.FUSEAMPERECIRCUIT
1 TURN7.5Turn signal lights
2 WIPER20Windshield wipers
3 HEATER10
Air conditioning system,
Rear window defogger, Multiport
fuel injection system/sequential
multiport fuel injection system
4 FR FOG15Fog lights
5 ECUIG10Power steering control system,
Charging system,
Vehicle skid control system
6 PWRIG15
Automatic headlight leveling
system, Moon roof,
Headlight cleaner,
Power seat switch,
Tilt and telescopic steering, Shift
lock system
7 GAUGE10
Gauges and meters, service
reminder indicators and warning
buzzers,
Backup lights,
Vehicle skid control system,
Multiport fuel injection
system/sequential multiport fuel
injection system, Automatic
transmission system
8 IGN10SRS, Multiport fuel injection
system/sequential multiport fuel
injection system
9 RR FOG7.5No circuit
10 FUEL OPN10Fuel opener system
No.FUSEAMPERECIRCUIT
11 RR CIG15Rear cigarette lighter,
Power outlet
12 FR CIG15Front cigarette lighter, SRS
13 A/C7.5Air conditioning system
14 P RR
DOOR20Rear door lock,
Rear power window
15 STOP LP25Stop lights,
High mounted stop light
16 RADIO
NO.215
Audio system,
Outside rear view mirror,
Shift lock system,
Air conditioning system
17 PANEL7.5Instrument panel lights,
Air conditioning system, Glovebox
light, Audio system
18 STARTER7.5
Starting system,
Automatic transmission system,
Multiport fuel injection
system/sequential multiport fuel
injection system
19 TAIL7.5Tail lights, Side marker lights,
License plate lights
20 STOPS7.5
Shift lock system,
Height control system, Antilock
brake system,
Vehicle skid control system
21 RR S/HTR15No circuit
22 WASHER20Windshield washer

INDEX (A C)
278
A
”ABS” warning light 178
Adding washer fluid 261. . . . . . . . . . . . . . . . . . .
Adjustment
Driver’s seat lumbar support 73. . . . . . . . . . . .
Front seat cushion angle and height 72. . . . . .
Front seat position 71. . . . . . . . . . . . . . . . . . . .
Front seatback angle 72
Seat belts 80. . . . . . . . . . . . . . . . . . . . . . . . . . .
Airbags (SRS) 86. . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 247. . . . . . . . . . .
Antifreeze 233. . . . . . . . . . . . . . . . . . . . . . . . . . .
Antilock brake system 177. . . . . . . . . . . . . . . .
Antitheft steering column lock 157. . . . . . . . . .
Appearance care
Cleaning the interior 273
Protecting your Lexus from corrosion 270. . .
Washing and waxing 271
Audio system 132. . . . . . . . . . . . . . . . . . . . . . . .
Automatic air conditioning controls 121. . . . . . .
Automatic transmission
Driving with an automatic
transmission 160. . . . . . . . . . . . . . . . . . . . . .
Shift pattern 160. . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 163. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 62. . . . . . . . . . . . .
B
Battery
Checking battery condition 253. . . . . . . . . . . .
Recharging precautions 257. . . . . . . . . . . . . . .
Winter driving tips 182. . . . . . . . . . . . . . . . . . .
Before starting the engine 157. . . . . . . . . . . . . .
Belts
Seat belts 80. . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake pad wear limit warning light 178. . . . . . .
Brake system warning light 37. . . . . . . . . . . . . .
Brakes
Antilock brake system 177. . . . . . . . . . . . . . .
Booster 176. . . . . . . . . . . . . . . . . . . . . . . . . . .
Braking tips 176. . . . . . . . . . . . . . . . . . . . . . . .
Fluid level 239. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit warning light 178. . . . . . . . . . .
Parking 158. . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking brake reminder light 37. . . . . . . . . . . .
Breakin period 181. . . . . . . . . . . . . . . . . . . . . .
Brightness control 46. . . . . . . . . . . . . . . . . . . . .
C
Carbon monoxide caution 156. . . . . . . . . . . . . .
Cassette tape player 140
Car audio operating tips 148. . . . . . . . . . . . . . . .
Center vents 130. . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing the
blade type fuses 258. . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 239. . . . . . . . . . . . . . . . . .
Checking the cartridge type fuses 260. . . . . . . .
Checking the engine oil level 230. . . . . . . . . . . .
Child restraint 98. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint precautions 98. . . . . . . . . . . . . . .
Childprotector, Rear door 19. . . . . . . . . . . . . . .
Cigarette lighter and ashtray 52. . . . . . . . . . . . .
Cleaning the interior 273. . . . . . . . . . . . . . . . . . .
Clock 51. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather, Operation 182. . . . . . . . . . . . . . .
Compact disc player 143. . . . . . . . . . . . . . . . . . .
Converter, Threeway catalytic 155. . . . . . . . . .

INDEX (C E)
279
Consumer information
Uniform tire quality grading 244. . . . . . . . . . .
Controls, Instrument panel Pictorial index. . . . . .
Cooling system
Coolant level 233. . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 196. . . . . . . . . . . . . . . . . .
Radiator and reservoir 233. . . . . . . . . . . . . . . .
Radiator cap 196. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 182. . . . . . . . . . . . . . . . . . .
Corrosion prevention 270
Cruise control 168. . . . . . . . . . . . . . . . . . . . . . . .
Cruise information 42. . . . . . . . . . . . . . . . . . . . .
Cup holder 56. . . . . . . . . . . . . . . . . . . . . . . . . . . D
Defogger, Rear window 27. . . . . . . . . . . . . . . . .
Dimmer switch, Headlight 5, 24. . . . . . . . . . . .
Directional signals 5, 24. . . . . . . . . . . . . . . . . . .
Discharge warning light 39. . . . . . . . . . . . . . . . .
Does your vehicle need repairing? 217. . . . . . . .
Doityourself maintenance 221. . . . . . . . . . . .
Door locks 18. . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver’s seat 2, 70. . . . . . . . . . . . . . . . . . . . . . . .
Driving
Automatic transmission 160. . . . . . . . . . . . . . .
Driving tips 180. . . . . . . . . . . . . . . . . . . . . . . .
Driving position memory system 113. . . . . . . . . .
Driving tips
Driving tips in various conditions 181. . . . . . .
Driving with an automatic
transmission 160. . . . . . . . . . . . . . . . . . . . . .
Economical driving 189. . . . . . . . . . . . . . . . . .
Good braking practice 176. . . . . . . . . . . . . . . .
Good driving practice 166
Winter driving tips 182. . . . . . . . . . . . . . . . . . .
During breakin 181. . . . . . . . . . . . . . . . . . . . . .
E
Economical driving .
Saving money on both fuel and
repairs 189. . . . . . . . . .
Electrical system
Battery 253. 257. . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 249. . . . . . . . . . . . . . . . . . . . . .
Fuses 249, 258, 260. . . . . . . . . . . . . . . . . . . . .
Spark plugs 226. . . . . . . . . . . . . . . . . . . . . . . .
Electronic throttle control system 167. . . . . . . .
Emergency flasher switch 31. . . . . . . . . . . . . . .
Emergency, in case of
Blown fuse 259. . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 31. . . . . . . . . . . . . .
Flat tire 197. . . . . . . . . . . . . . . . . . . . . . . . . . .
If you lose your keys 210
If your vehicle needs to be towed 205. . . . . . .
If your vehicle will not start 193. . . . . . . . . . .
Jump starting 194. . . . . . . . . . . . . . . . . . . . . . .
Overheating 196. . . . . . . . . . . . . . . . . . . . . . . .
Towing 205. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine
Antifreeze 233. . . . . . . . . . . . . . . . . . . . . . . . .
Before starting the engine 157. . . . . . . . . . . . .

GAS STATION INFORMATION
Fuel selection:
Select premium unleaded gasoline with an Octane Rating of 91
(Research Octane Number 96) or higher for optimum engine
performance. However, if such premium type cannot be
obtained, you may temporarily use unleaded gasoline with an
Octane Rating as low as 87 (Research Octane Number 91).
Fuel tank capacity:
85 L (22.5 gal., 18.7 lmp.gal.)
Engine oil:
API SH, ”EnergyConserving II” or SJ, ”EnergyConserving”
multigrade engine oil or ILSAC multigrade engine oil.
Recommended oil viscosity SAE 5W30 if normal
temperatures are below 38C (100F)
Oil capacity: L (qt., lmp.qt.)
Drain and refill
with filter 5.6 (5.9, 4.9)
without filter 5.3 (5.6, 4.7)
See page 230 for detailed information.
Engine coolant:
Capacity: 10.8 L (11.4 qt, 10.4 lmp.qt.)
Coolant type Ethylene glycol coolant (Do not use alcohol
coolant.)
For checking the engine coolant, see page 233.
For changing the engine coolant, see the label on the coolant
reservoir.Automatic transmission:
Fluid type Automatic transmission fluid Type TIV or
equivalent
Tire information:
See page 241 through 247 for detailed information.
Tire pressure:
Tire size: P225/60R16 97V
cold tires
kPa (kgf/cm
2
or bar, psi)
Vehicle loaded up
Vehicle load up to vehicle capacity
up to occupants weight
Front tires 200 (2.0, 29) 220 (2.2, 32). . . . . . . . . . . . .
Rear tires 200 (2.0, 29) 220 (2.2, 32). . . . . . . . . . . . .
For sustained high speeds above 160 km/h (100 mph), in
countries where such speeds are permitted by law, add 80 kPa
(0.9 kgf/cm
2, 0.8 bar, 12 psi) to the front tires and rear tires, but
never exceed the maximum cold tire pressure molded on the tire
sidewall.
LS400 (U) 98