1998 Lexus ES300 air condition

AIR CONDITIONING AND AUDIO
130
20L040
A new disc may have rough edges on its inner and outer perimeter.
Remove the rough edges by pr essing the side of a ball±point pen or pencil
against the inner and outer edges of the disc as shown.
If you continue to play a disc with rough edges, flakes will fall on to th\
e signal
side of the disc and cause sound skipping or other problems.
CAUTION
Compact disc players use invisible laser beams which could
cause hazardous radiation exposure if directed outside the
unit. Be sure to operate the player correctly as instructed.

DRIVING TIPS
158

Crosswinds and rough roads will adversely affect handling of your vehicle
and trailer, causing sway. Pay attention to the rear from time to time to
prepare yourself for being passed by large trucks or buses, which may
cause your vehicle and trailer to sway. If swaying happens, firmly grip the
steering wheel and reduce speed immediately but gradually. Never
increase speed. If it is necessary to reduce speed, brake slowly. Steer
straight ahead. If you make no extreme correction with the steering or
brakes, your vehicle and trailer will stabilize.
 Be careful when passing other vehicles. Passing requires considerable
distance. After passing a vehicle, do not forget the length of your trailer
and be sure you have plenty of room before changing lanes.
 In order to maintain efficient engine braking and electrical charging
performance, do not use overdrive.
 Because of the added load of the trailer, your vehicle's engine may overheat
on hot days (at temperatures over 30C [85 F]) when going up a long or
steep gr ade with a trailer. If the engine coolant temperature gauge indicates
overheating, immediately turn off the air conditioning (if in use), pull your
vehicle off the road and stop in a safe spot. See ºIf your vehicle overheatsº\
on page 166 of this manual.
 Always place wheel blocks under both the vehicle and trailer wheels when
parking. Apply the parking brake firmly. Put the transmission in ºPº.
Avoid parking on a slope with a trailer, but if it cannot be avoided, do so
only after performing the following: 1. Apply the brakes and keep them applied.
2. Have someone place wheel blocks under both the vehicle and trailer
wheels.
3. When the wheel blocks are in place, release your brakes slowly until the
blocks absorb the load.
4. Apply the parking brake firmly.
5. Shift into ºPº and turn off the engine.
When restarting out after parking on a slope:
1. With the transmission in ºPº position, start the engine. Be sure to k\
eep the
brake pedal depressed.
2. Shift into the º2º, ºLº or ºRº position.
3. Release the parking brake and brake pedal and slowly pull or back away
from the wheel blocks. Stop and apply your brakes.
4. Have someone retrieve the blocks.
CAUTION

Do not exceed 72 km/h (45 mph) or the posted towing speed
limit, whichever is lower. Because instability (swaying) of
a towing vehicle±trailer combination usually increases as
the speed increases, exceeding 72 km/h (45 mph) may cause
loss of control.
Slow down and downshift before descending steep or long downhill
grades. Do not make sudden downshifts.
 Avoid holding the brake pedal down too long or too fr equently. This
could cause the brakes to overheat and result in reduced braking
efficiency.

DRIVING TIPS
160

Keep your vehicle tuned±up and in top shape. A dirty air cleaner,
improper valve clearance, dirty plugs, dirty oil and grease, brakes not
adjusted, etc. all lower engine performance and contribute to poor fuel
economy. For longer life of all parts and lower operating costs, keep all
maintenance work on schedule, and if you often drive under severe
conditions, see that your vehicle receives more frequent maintenance. (For
scheduled maintenance information, please refer to the separate ºOwner's
Manual Supplement/Maintenance Scheduleº.)
CAUTION
Never turn off the engine to coast down hills. Your power
steering and brake booster will not function without the
engine running. Also, the emission control system operates
properly only when the engine is running.

IN CASE OF AN EMERGENCY
166
IF YOUR VEHICLE OVERHEATS
If your engine coolant temperature gauge indicates overheating, if you
experience a loss of power, or if you hear a loud knocking or pinging noise,
the engine has probably overheated.
When the engine overheats
Pull safely off the road, stop the vehicle and turn on your emergency flashers.
Put the transmission in ºPº and apply the parking brake.
A: If steam is coming from your engine:
Turn off the engine. Leave the hood closed until there is no sign of steam or
coolant. Your engine could have been seriously damaged already. Call your
Lexus dealer for assistance.
CAUTION
To help avoid personal injury, keep the hood closed until there
is no steam. Escaping steam or coolant is sign of very high
pressure.
B: If no steam is coming from your engine:
Leave the engine running and turn off the air conditioning. Check the
following.
Is the cooling fan operating?
 Is the coolant in the acceptable range?
 Is the engine drive belt O.K.?
CAUTION
When the engine is running, keep hands and clothing away
from the moving fan and engine drive belt.
 Do not attempt to remove the radiator cap when the engine
and radiator are hot. Serious injury could result from
scalding hot fluid and steam blown out under pressure.
If the cooling fan is not operating or the coolant is not in the acceptabl\
e range,
turn off the engine and call your Lexus dealer.
If both conditions are O.K., after the engine coolant temperature has cooled
to normal, continue driving your vehicle.
If the engine coolant temperature does not cool down, or your vehicle
overheats again, have it checked as soon as possible by your Lexus dealer.

MAINTENANCE
184
Power steering fluid level
Check the level through the reservoir. The level should be in the ºHOTº or
ºCOLDº range depending on the fluid temperature. See page 206 for
additional information.
Exhaust system
Look for cracks, holes and loose supports. If you notice any change in the
sound of the exhaust or smell exhaust fumes, have the cause located and
corrected immediately. (See engine exhaust cautions in Section 3±1.)
DOES YOUR VEHICLE NEED
REPAIRING?
Be on the alert for changes in performance and sounds, and visual tip±o\
ffs that
indicate service is needed. Some important clues are:

Engine missing, stumbling, or pinging

Appreciable loss of power

Strange engine noises

A fluid leak under the vehicle (However, water dripping from the air
conditioning after use is normal.)

Change in exhaust sound (This may indicate a dangerous carbon monoxide
leak. Drive with the windows open and have the exhaust system checked
immediately.)

Flat±looking tires, excessive tire squeal when cornering, uneven tire wear

Vehicle pulls to one side when driving straight on a level road

Strange noises related to suspension movement

Loss of brake effectiveness, spongy feeling brake pedal, pedal almost
touches floors, vehicle pulls to one side when braking

Engine coolant temperature continually higher than normal
If you notice any of these clues, take your vehicle to your Lexus dealer a\
s soon
as possible. It probably needs adjustment or repair.
CAUTION
Do not continue driving with the vehicle unchecked. It could
result in serious vehicle damage and possibly personal injury.

ENGINE197
Engine oil consumption
It is normal that an engine should consume some engine oil during normal
engine operation. The causes of oil consumption in a normal engine are
as follows.
Oil is used to lubricate pistons, piston rings and cylinders. A thin film of
oil is left on the cylinder wall when a piston moves downwards in the
cylinder. High negative pressure generated when the vehicle is
decelerating sucks some of this oil into the combustion chamber. This oil
as well as some part of the oil film left on the cylinder wall is burned b\
y the
high temperature combustion gases during the combustion process.
 Oil is also used to lubricate the stems of the intake valves. Some of this\
oil
is sucked into the combustion chamber together with the intake air and i\
s
burned along with the fuel. High temperature exhaust gases also burn the
oil used to lubricate the exhaust valve stems. The amount of engine oil consumed depends on the viscosity of the oil, the
quality of the oil and the way the vehicle is driven.
More oil is consumed under driving conditions such as high speeds and
frequent acceleration and deceleration.
A new engine consumes more oil, since its pistons, piston rings and cyli\
nder
walls have not become conditioned.
When judging the amount of oil consumption, keep in mind that the oil
may have become diluted, making it difficult to judge the true level
accurately.
For example, if a vehicle is used for repeated short trips and consumes \
a
normal amount of oil, the dipstick may not show any drop in the oil level at
all, even after 1000 km (600 miles) or more. This is because the oil \
is
gradually becoming diluted with fuel or moisture, making it appear that the
oil level has not changed.
The diluting ingredients evaporate out when the vehicle is then driven at high
speeds, as on an expressway, making it appear that oil is excessively
consumed after driving at high speeds.
Importance of engine oil level check
One of the most important points in proper vehicle maintenance is to keep t\
he
engine oil at the optimum level so that oil function will not be impaired.
Therefore, it is essential that the oil level be checked regularly. Lexus
recommends that the oil level be checked every time you refuel the vehicle.
NOTICE
Failure to check the oil level regularly could lead to serious engine
trouble due to insufficient oil.
For detailed information on oil level check, see ºChecking the engine\
oil
levelº on page 198.

CHASSIS209
If you have tire damage such as cuts, splits, cracks deep enough to expose
the fabric, or bulges indicating internal damage, the tire should be
replaced.
If a tire often goes flat or cannot be properly repaired due to the size o\
r location
of a cut or other damage, it should be replaced. If you are not sure, c\
onsult
with your Lexus dealer.
If an air loss occurs while driving, do not continue driving with a deflat\
ed tire.
Driving even a short distance can damage a tire beyond repair.
Any tires which are over 6 years old must be checked by a qualified
technician even if damage is not obvious.
Tires deteriorate with age even if they have never or seldom been used.
This also applies to the spare tire and tires stored for future use.
Uniform tire quality grading
This information has been prepared in accordance with regulations
issued by the National Highway Traffic Safety Administration of the U.S.
Department of Transportation. It provides the purchasers and/or
prospective purchasers of Lexus vehicles with information on uniform
tire quality grading.
Your Lexus dealer will help answer any questions you may have as you
read this information.
DOT quality grades ± All passenger vehicle tires must conform to Federal
Safety Requirements in addition to these grades. These quality grades
are molded on the sidewall.
Treadwear
± The treadwear grade is a comparative rating based on the wear
rate of the tire when tested under controlled conditions on a specified
government test course. For example, a tire graded 150 would wear one and
a half (1 ± 1/2) times as well on the government course as a tire g\
raded 100.
The relative performance of tires depends upon the actual conditions of the\
ir
use, however, and may depart significantly from the norm due to variations
in driving habits, service practices and differences in road characteristics and
climate.
Traction A, B, C ± The traction grades, from highest to lowest, are A, B and
C, and they represent the tire's ability to stop on wet pavement as measured
under controlled conditions on specified government test surfaces of asphalt
and concrete. A tire marked C may have poor traction performance.

ELECTRICAL COMPONENTS217
No.FUSEAMPERECIRCUIT
1 ABS60Anti±lock brake system
2 DRL NO.25Vehicles sold in Canada
Daytime Running Light System
3 H±LP
LH (LO)10Vehicles sold in Canada
Left±hand headlight (low beam)
4
H±LP
RH(LO)10Vehicles sold in Canada
Right±hand headlight (low beam)
4
A/F HTR25Vehicles sold in California
Air fuel ratio sensor
5 ALT100Charging system
6 CDS NO.230No circuit
7 HTR50Air conditioning system, Seat
heater
8 MAIN40Headlight, Starting system
9 DOME7.5
Theft deterrent system, Clock,
Door courtesy light, Interior light,
Ignition switch light, Vanity light,
Wireless remote control system
10 ECU±B10Cruise control system, Air
conditioning system, Power seat
system
11 RAD NO.120Audio system
12 HAZ10Emergency flashers, Turn signal
lights
13 AM230Starting system
No.FUSEAMPERECIRCUIT
14 TEL5Telephone
15
H±LP LH15Vehicles sold in the U.S.A.
Left±hand headlight (high beam)
15 H±LP
LH HI15Vehicles sold in Canada
Left±hand headlight (high beam)
16 ALT±S5Charging system
17
H±LP RH15Vehicles sold in the U.S.A.
Right±hand headlight (high beam)
17 H±LP RH HI15Vehicles sold in Canada
Right±hand headlight (high beam)
18 EFI15Multiport fuel injection
19 HORN10Theft deterrent system
20 RDI FAN30Electronic cooling fan system
21 CDS30Air conditioning system
22 A/C10No circuit
23 S±HTR20Seat heater system
24 HTR10Air conditioning system
25 GAUGE10
Gauges and meters, service reminder
indicators and warning buzzers, Back±up
light, Door courtesy light, Seat heater, Power
window system
26 WIP20Windshield wipers and washer