1998 GMC SIERRA automatic transmission

Long TriplHighway Maintenance Schedule -- -asoline Engines 1
45,000 Miles (75 000 km) (Continued)
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
velocity
joints and axle seals for leaking. (See footnote
:c*.)
insulation for damage or looseness. Adjust or replace as required.
This is a Noise Emission Control Service. Applicable only to \:elzicle.s
sold in the United States.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and filter if the vehicle’s GVWR is over
8600 lbs. or if the vehicle is mainly driven under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
MILEAGE
90°F (32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use ?:out* vehicle under my of these conditions,
change the fluid nnd.filter at
100,000 miles (I 66 000 km).
Manual transmission fluid doesn’t require change.
7-32
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines I
100,000 Miles (166 000 km)
0
0
0 0
Inspect spark plug wires.
An E~nission Control Service.
Replace spark plugs.
An Emission Control Service.
Change automatic transmission fluid and filter if the vehicle’s GVWR is over
8600 lbs. or if the vehicle is mainly driven under one or more of these condi\
tions:
- In heavy city traffic where the outside temperature regularly reaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
Manual transmission fluid doesn’t require change.
If you haven’t used your vehicle under severe service conditions listed
previously and, therefore, haven’t changed your automatic transmission fluid,
change both the fluid and filter.
Manual transmission fluid doesn’t require change.
Inspect Positive Crankcase Ventilation (Pcv) valve.
At7 Emission Control Service.
90°F (32°C) or higher.
DATE
MILEAGE I SERVICED B’
7-38
ProCarManuals.com

At Least Twice a Year Manual Transmission Check
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look
for any other loose or damaged
safety belt system parts.
If you see anything that might
keep a safety belt system from doing its
job, ha\:e it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken
air bag coverings,
and have them repaired or replaced. (The air
bag system
does
not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace blade
inserts that appear worn
or damaged or that streak or
miss areas
of the windshield. Also see "Wiper Blactes,
Cleaning"
in the Index.
Air Cleaner Filter Restriction Indicator Check
Your vehicle has an indicator on the engine that lets you
know when the air cleaner filter
is dirty and needs to be
changed. Check indicator at least twice
a year or when
your
oil is changed. See "Air Cleaner" in the Index for
more information. Inspect your air cleaner filter
restriction indicator more often
if the vehicle is used in
dusty areas or under off road conditions. Check the transmission fluid
level; add
if needed. See
"Manual Transmission"
in the Index. Check for leaks.
A fluid loss may indicate a problem. Have the system
inspected and repaired
if needed.
Automatic Transmission Check
Check the transmission fluid level: add if needed. See
"Automatic Transmission"
in the Index. A fluid loss may
indicate a problem. Check the system and repair
if needed.
Hydraulic Clutch System Check
Check the fluid level in the clutch reservoir. See
"Hydraulic Clutch Fluid"
in the Index. A fluid loss in
this system could indicate a problem. Have the system
inspected and repaired at once.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified
in Part D.
7-41
ProCarManuals.com

Body Lubrication Service
Lubricate all fuel doors, body hood, body door hinges,
body door hinge
pins, hood latch assembly, pivots,
spring anchor, release pawl, tailgate hinges, and tailgate
handle pivot points, latch bolt, locks and folding seat
hardware. Part
D tells you what to use. More frequent
lubrication may be required when exposed to
a corrosive
environment.
Starter Switch Check
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
3. On automatic transmission vehicles, try to start the
engine
in each gear. The starter should work only in
PARK
(P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to start the engine. The starter should work
only when the clutch is pushed down all the way
to
the floor. If the starter works when the clutch isn’t
pushed
all the way down, your vehicle needs service.
Brake-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake (see “Parking
Brake” in the Index
if necessary) and the
regular brake.
NOTE: Do not use the accelerator pedal, and be
ready to
turn off the engine immediately if it starts.
When you are doing this check, the vehicle could
move suddenly. If
it does, you or others could be
injured. Follow the steps below.
I. Before you start, be sure you have enough room
around the vehicle. It should be parked
on a
level surfxe.
7-42
ProCarManuals.com

2.
3.
Firmly apply the parking brake (see “Parking Brake”
in the Index if necessary).
NOTE: Be ready to apply the regular brake
immediately
if the vehicle begins to move.
With the engine off, turn the key to the
RUN
position, but don’t start the engine. Without applying
the regular brake, try to move the shift lever
out of
PARK
(P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle’s BTSI
needs service.
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
LOCK in each shift lever position.
With an automatic transmission, the key should turn
to
LOCK only when the shift lever is in PARK (P).
0 With a manual transmission, the key should
turn to
LOCK only when the shift lever is in
REVERSE (R).
On vehicles with a key release button, try to
turn the key
to
LOCK without pressing the button. The key should
turn to
LOCK only when you press the key button.
On
all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there
is room in front of your vehicle in case
it begins to roll. Be ready
to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
0 To check the parking brake’s holding ability:
With the engine running and transmission
in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal.
Do this until the vehicle is
held by the parking brake only.
0 To check the PARK (P) mechanism‘s holding ability:
With the engine running, shift to
PARK (P). Then
release all brakes.
7-43
ProCarManuals.com

USAGE
Automatic
Transmission
Key Lock
Cylinders
Linkage
I
Chassis Lubrication
Front Wheel
Bearings
Differential,
Front and Rear
Axle
FLUIDLUBRICANT
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-Pur ose Lubricant,
Superlube
L (GM Part
No. 1234624 1 or equivalent).
Lubriplate@ Lubricant Aerosol
(GM Part No. 12346293 or
equivalent) or lubricant meeting
requirements
of NLGI # 2
Category LB or GC-LB.
Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements of
NLGI # 2, Category LB or
GC-LB.
Wheel Bearing Lubricant meeting
requirements
of NLGI # 2,
Category GC or GC-LB (GM Part
No. 1 OS 1344 or equivalent).
Axle Lubricant (GM Part
GL-5 Gear Lubricant.
NO. 1052271) or SAE 8OW-90
USAGE
Differential, C3
(HD3500)
Trucks With
Dana Rear Axle
Transfer Case
Windshield
Washer Solvent
Front Axle
Propshaft Spline,
Rear Driveline
Center Splines
and Universal
Joints
One-Piece
Propshaft Spline
(Two-Wheel
Drive with Auto.
Trans
.)
FLUIDLUBRICANT
SAE 75W- 140 Synthetic Gear
Lubricant (GM Part
No. 12346 140) or equivalent.
DEXRON@-111 Automatic
Transmission Fluid.
GM Optikleen@ Washer Solvent
(GM Part
No. 105 15 15)
or equivalent.
Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of
NLGI # 2, Category LE or
GC-LB.
Spline Lubricant, Special
Lubricant (GM Part
No. 12345879) or lubricant
meeting requirements of
GM 998530.
7-47
ProCarManuals.com

Section 9 Index
Accessory Power Outlet ......................... 2-59
AirBag ....................................... 1-23
Adding Equipment
............................ 1-3 1
How Does it Restrain .......................... 1-28
How it Works ................................ 1 -26
Location .................................... 1-26
Readiness Light ......................... 1.25, 2.65
What Makes it Inflate .......................... 1-27
What Will You See After
it Inflates ............... 1-28
When Should it Inflate ......................... 1-27
Air Bag
Off Light .......................... 1.58. 2.65
Air Cleaner
.................................... 6- 18
Air Cleaner Filter Restriction Indicator Check ........ 7-41
Air Conditioning ............................ 3.3. 3.4
Air Conditionillg Refrigerants ..................... 6-79
Alignment and Balance. Tire
...................... 6-59
Antenna
...................................... 3-26
Antifreeze
........................... 6-28.6-79.7-46
Anti-Lock Brake System Warning Light
................ 2.68. 4.7
Brakes ...................................... 4-7
Appearance Care
............................... 6-6 I
Adding Equipment to the Outside of Your Vehicle ...... 6-3
Servicing
................................... 1-30
Aluminum Wheels. Cleaning ...................... 6-67
Appearance Care and Materials .................... 6-69
Arbitration Program .............................. 8-9
Armrest Storage Compartment
.................... 2-56
Audio Equipment. Adding
........................ 3-24
Audio System
.................................. 3-7
Automatic Transmission
Check
...................................... 7-41
Fluid
.................................. 6-21. 7-47
Operation ................................... 2-15
Park Mechanism Check
........................ 7-43
Starting Your Engine
.......................... 2-12
Axle. Front
............................... 6-27. 7-47
Axle. Locking Rear
............................. 2-32
Axle. Rear
............................... 6-26. 7-47
Ashtrays ...................................... 2-58
Battery
...................................... 6-39
Jump Starting
................................. 5-3
Warnings ................................ 5-3. 5-5
BBB Auto Line ................................. 8-9
Better Business Bureau Mediation ................... 8-9
Blizzard. Driving
In ............................. 4-38
Replacement.
Keyless Entry ..................... 2-8
9-1
ProCarManuals.com

Tachometer .................................. 2-63
Voltmeter
................................... 2-67
Garage Door Opener
............................ 2-5 1
GAWR ....................................... 4-43
Gear Positions. Automatic Transmission
............. 2- 15
Gear Positions. Manual Transmission .......... 2- I8 . 2- 19
GloveBox .................................... 2-51
Gross Axle Weight Rating ........................ 4-43
Gross Vehicle Weight Rating
...................... 4-43
Guide en Franpis
11
GVWR ....................................... 4-43
.. .................................
Halogen Bulbs ................................ 6-39
Hazard Warning Flashers
.......................... 5-2
Head Restraints ................................. 1-5
Headlamps .................................... 2-41
Bulb Replacement
....................... 6-40. 6.4 I
High/Low Beam Changer ...................... 2-36
On Reminder
................................ 2-42
Wiring
..................................... 6-71
Heating
........................................ 3-5
High-Beam Headlamps
.......................... 2-36
Hill and Mountain Roads
......................... 4-34
Hitches. Trailer
................................. 4-55
Hood
Checking Things Under ......................... 6-9
Release
..................................... 6-10
Horn ......................................... 2-34
Hydraulic Clutch Fluid
...................... 6-25 . 7-46
Hydraulic Clutch System Check
................... 7-41
Hydroplaning
.................................. 4-30
Hearing Ilnpaired
. Customer Assistance .............. 8-4
Highway Hypnosis
.............................. 4-33 Ignition
Positions
..............................
Brakesystem ................................ 7-45
Drive Axle
.................................. 7-45
Engine Cooling System
........................ 7-44
Exhaust
Systems ............................. 7-44
Steering
.................................... 7-44
Suspension
.................................. 7-44
Throttle Linkage
.............................. 7-44
Transfer Case (Four-Wheel Drive)
............... 7-45
Instrument Panel
............................... 2-60
Cleaning
.................................... 6-64
Cluster
..................................... 2-62
FuseBlock
.................................. 6-72
Intensity Control
............................. 2-43
Interior Lamps
................................. 2-43
.................................... J ack. Tire 5-25
Jump Starting
................................... 5-3
Key Lock Cylinders Service
..................... 7-41
Key Release Button
............................. 2-12
Keyless Entry System ............................ 2-6
Keys
.......................................... 2-2
9-5
ProCarManuals.com