1998 FORD WINDSTAR warning light

Maintenance and Care
301
[MC23100(ALL)08/96]3.
To replace the fuel cap, align the tabs on the cap with the
notches on the filler pipe. Turn it clockwise until it stops.
*
[MC23200(ALL)08/96]4.
Push the fuel door closed.
[MC23250(ALL)08/96]
If the Service Engine Soon warning light comes on and stays on
when you start the engine, the fuel cap may not be properly
seated. Turn off the engine, remove the fuel cap and replace it,
being careful to align the cap properly. For more information,
seeWarning lightsin the Index.
*
[MC23300(ALL)01/96]
If you lose the fuel cap, replace it with an authorized Motorcraft
or equivalent part.
%*
[MC23400(ALL)01/96
]
RWARNING
If you do not use the proper fuel cap, the pressure in the
fuel tank can damage the fuel system or cause it to work
improperly in a collision.
*
[MC23500(ALL)01/96]
NOTE: If you replace your fuel cap with an aftermarket fuel
filler cap, the customer warranty may be void for any
damage to the fuel tank and/or fuel system.
[MC24100(ALL)08/96]
Choosing the Right Fuel
*
[MC24200(ALL)08/96]
Use only UNLEADED FUEL. Using leaded fuel is prohibited by
federal law. Any vehicle damage may not be covered by your
warranty.
[MC24300(ALL)08/96]
Your vehicle was not designed to use fuel containing
manganese-based additives such as MMT. Additionally, vehicles
certified to California emission standards (indicated on the
underhood Vehicle Emissions Control Information label) are
designed to operate on California reformulated gasolines. If
California reformulated gasoline is not available when you
refuel, your vehicle can be operated on non-California fuels.
However, even though your engine will perform adequately on
File:11wnmcs.ex
Update:Tue Oct 8 10:24:50 1996

308
*
[MC30500(ALL)01/96]
RWARNING
Do not park, idle, or drive your vehicle in dry grass or
other dry ground cover. The emission system heats up
the engine compartment and exhaust system, which can
start a fire.
*
[MC30600(ALL)01/96]
RWARNING
Do not remove the floor carpet in your vehicle. Emission
controls cause high exhaust temperatures under the floor.
*
[MC30700(ALL)05/96]
RWARNING
Exhaust leaks may result in the entry of harmful and
potentially lethal fumes into the passenger compartment.
Under extreme conditions excessive exhaust temperatures
could damage the fuel system, the interior floor covering,
or other vehicle components, possibly causing a fire.
*
[MC30900(ALL)01/96]
Watch for fluid leaks, strange odors, smoke and loss of oil
pressure. Also watch for the charge warning light, the check
engine light, or the temperature warning light. These sometimes
indicate that the emission system is not working properly.
*
[MC31000(ALL)01/96]
Do not make any unauthorized changes to your vehicle or
engine. Changes that cause more unburned fuel to reach the
exhaust system can increase the temperature of the engine or
exhaust system.
*
[MC31100(ALL)01/96]
By law, anyone who manufactures, repairs, services, sells, leases
vehicles, trades vehicles, or supervises a fleet of vehicles is not
permitted to intentionally remove an emission control device or
prevent it from working. In some of the United States and in
Canada, vehicle owners may be liable if their emission control
device is removed or is prevented from working.
File:11wnmcs.ex
Update:Tue Oct 8 10:24:50 1996

Maintenance and Care
311
%*
[MC34100(ALL)01/96]
The alignment of your headlamps should be checked if:
*
[MC34200(ALL)01/96]
n
oncoming motorists frequently signal you to turn off your
vehicle's high beams when you do not have the high beams
on
*
[MC34300(ALL)01/96]
n
the headlamps do not seem to give you enough light to see
clearly at night
*
[MC34400(ALL)01/96]
n
the headlamp beams are not pointed slightly down and to
the right
% [MC34500(ALL)04/96]
Replacing the Headlamp Bulb
*
[MC34600(ALL)03/96]
The headlamps on your vehicle use replaceable bulbs. When the
lamp burns out, simply replace the bulb, rather than the whole
lamp.
*
[MC34700(ALL)01/96]
RWARNING
Handle a halogen headlamp bulb carefully and keep out
of children's reach. Grasp the bulb only by its plastic
base and do not touch the glass. The oil from your hand
could cause the bulb to break the next time the
headlamps are operated.
*
[MC34800(ALL)01/96]
Do not remove the burned out bulb unless you can immediately
replace it with a new one. If a bulb is removed for an extended
period of time, contaminants may enter the headlamp and affect
its performance.
[MC34900(ALL)04/96]
To remove the headlamp bulb:
*
[MC35000(ALL)01/96]1.
Make sure that the engine is off and the headlamp switch on
the instrument panel is in the OFF position.
[MC35100(ALL)01/96]2.
Lift the hood and locate the headlamp bulb installed in the
rear of the headlamp. Remove the electrical connector from
the bulb by pulling the connector away from the bulb
assembly.
File:11wnmcs.ex
Update:Tue Oct 8 10:24:50 1996

Index
359
A
ABS warning light (see Anti-lock brake system)...... 12
Accessory position on the ignition............. 91
Additives, engine oil.................. 276
Air bag supplemental restraint system......167±168, 188
and child safety seats............168, 187±188
description...................167, 169
disposal...................... 173
driver air bag..................167, 169
indicator light..................... 17
operation...................... 169
passenger air bag.................. 169
proper seating................... 168
service and information labels............ 169
tone generator................... 173
wearing safety belts................. 167
Air cleaner filter, location............... 273
Air conditioning, manual heating and air
conditioning system............... 73
Alarm, activating remote personal............ 128
Antenna, radio (see Electronic sound system)...... 29,90
Antifreeze (see Engine coolant)............. 282
Anti-lock brake system (ABS)
description..................... 211
see also Brake.................... 211
warning light..................... 12
Anti-theft lug nuts and key............... 254
File:wnixs.ex
Update:Fri Oct 11 10:49:35 1996

360
Anti-theft system
arming the system................. 132
description..................... 132
disarming an untriggered system........... 133
disarming a triggered system............ 134
triggering...................132±133
warning light..................... 27
Appeals (see Dispute settlement board)......... 334
Assistance (see Customer assistance).......... 331
Audio system (see Electronic sound system)........ 29
Autolamp system (see Headlamps)........... 104
Autolock....................... 130
Automatic transaxle
driving with.................... 216
fluid, adding.................... 290
fluid, checking.................288±289
fluid, refill capacities................ 324
fluid, specification.................. 325
B
Backing up...................... 217
Basic vehicle warranty.................. 3
Battery........................ 290
acid, treating emergencies............262, 292
battery saver.................... 126
charging system warning light............. 15
how to service................... 290
jumping a disabled battery.............. 262
maintenance-free.................. 290
proper disposal, recycling.............. 291
servicing...................... 290
when storing your vehicle.............. 328
File:wnixs.ex
Update:Fri Oct 11 10:49:35 1996

361
Index
Brake fluid...................... 279
checking and adding................ 279
description..................... 279
specifications..................279, 325
Brakelamp, bulb replacement.............. 314
Brakes........................ 211
adjustment..................... 211
anti-lock...................... 211
anti-lock brake system (ABS) warning light....... 12
applying the brakes................. 213
brake warning light.............. 11,18,143
fluid, checking and adding.............. 279
fluid, refill capacities................ 279
fluid, specifications...............279, 325
front disc...................... 211
if brakes do not grip well.............. 213
lubricant specifications................ 325
master cylinder................... 279
new brake linings................... 4
noise......................211, 213
parking...................... 214
power braking................... 211
servicing....................213, 279
stopping distances................213, 230
when storing your vehicle.............. 328
Brake-shift interlock.................. 217
Break-in period..................... 4
Brights (high beams)................... 18
File:wnixs.ex
Update:Fri Oct 11 10:49:35 1996

362
Built-in child seat, operation.............. 175
Bulbs, replacing
headlamps..................... 311
specifications.................... 318
C
Canada, customer assistance.............. 339
Canada, warranty information.............. 3
Canadian Motor Vehicle Arbitration Plan (CAMVAP) . . . 339
Capacities for refilling fluids.............. 324
Carbon monoxide in exhaust.............. 208
Cargo net....................... 124
Car seats for children (see Child safety seats)...... 187
Cassette tape player
(see Electronic sound system)...... 43,48,60,63
Catalytic converter.................. 307
CD player (see Electronic sound system).......... 36
Changing a tire.................... 247
Charging system warning light.............. 15
Childproof locks.................... 110
Child safety restraints................. 174
built-in child seat.................. 175
child safety belts.................. 186
child safety seats.................. 187
Child safety seats................... 187
and air bags................168, 187±188
attaching with tether straps............. 199
automatic locking mode (retractor).......... 187
built-in child seat.................. 175
in front seat................168, 187±188
in rear outboard seat................ 187
in rear seat..................... 187
tether anchorage hardware.............. 199
File:wnixs.ex
Update:Fri Oct 11 10:49:35 1996

364
Compact disc player (see Electronic sound system) . . . 30, 36
Compact disc radio (see Electronic sound system)..... 30
Console, description.................. 121
Controls, mirrors................... 117
Coolant (see Engine coolant).............. 282
checking and adding................ 282
drain and flush................... 286
preparing for storage................ 328
proper solution................... 284
refill capacities................... 324
specifications..................283, 325
temperature gauge.................. 22
warnings...................... 282
Cupholder(s)...................... 90
Customer Assistance Center, Ford (U.S.)......... 332
Customer Assistance Centre, Ford of Canada...... 339
D
Daytime running light system.............. 88
Defrost
rear window..................... 83
windshield...................... 71
Dipstick....................... 277
automatic transaxle fluid............... 289
engine oil..................... 277
Disabled vehicle (see Towing)............. 268
Dispute Settlement Board............... 334
Doors........................ 108
door ajar warning light................ 17
lubricant specifications................ 325
File:wnixs.ex
Update:Fri Oct 11 10:49:35 1996