1998 FORD EXPEDITION power steering

The parking brake is not designed
to stop a moving vehicle. However,
if the normal brakes fail, the
parking brake can be used to stop
your vehicle in an emergency.
Since the parking brake applies
only the rear brakes, the vehicle's
stopping distance will be adversely
affected.
Pull the release lever to release
the brake. Driving with the parking
brake on will cause the brakes to
wear out quickly and reduce fuel
economy.
STEERING
Your vehicle is equipped with
power steering. Power steering
uses energy from the engine to
help steer the vehicle.
Never hold the steering wheel to
the extreme right or the extreme
left for more than a few seconds
when the engine is running. This
action could damage the power
steering pump.
Speed sensitive steering
The steering in your vehicle is
speed sensitive. At high speeds,
BRAKE
HOOD
Driving
101

steering assist will decrease to
improve steering feel. At lower
speeds, maneuverability will be
increased.
If the amount of effort required to
steer your vehicle changes at a
constant vehicle speed, have the
power steering system checked by
your dealer or a qualified service
technician.
AIR SUSPENSION SYSTEM
(IF EQUIPPED)
The air suspension system is
designed to improve ride, handling
and general vehicle performance
for static, on and off-road driving
conditions.
²The load leveling feature of the
air suspension automatically
keeps the vehicle at a constant
level if a load is added or
removed from the vehicle.
²The height adjustment feature
automatically controls the
vehicle height over a range of
approximately 5 cm (2 inches)
based on vehicle speed, ignition
position and selection of two or
four-wheel drive modes.
Driving
102

The engine mini fuses are located
on the drivers side of the engine
compartment.
Slot
NumberFuse
Amperage
RatingCircuits Protected
1 5 amp Powertrain Control Module (PCM)
2 20 amp Trailer Tow Stop/Turn Lamps
3 10 amp Audio Rear Integrated Control Panel
(RICP), Compact Disc Changer, Radio
4 10 amp Running Board Lamps
5 20 amp Amplifier, Subwoofer Amplifier
6 Ð Not Used
CHANGING THE TIRES
If you get a flat tire while driving,
do not apply the brake heavily.
Instead, gradually decrease your
speed. Hold the steering wheel
firmly and slowly move to a safe
place on the side of the road.
6
5
4
3
2
1
Roadside emergencies
138

2. Automatic transmission fluid
dipstick
3. Engine oil filler
4. Engine oil dipstick
5. Power steering fluid reservoir
6. Brake fluid reservoir
7. Power distribution box
8. Air filter assembly
9. Engine coolant recovery
reservoir
10. Windshield washer fluid
reservoir
ENGINE OIL
Checking the engine oil
Check the engine oil each time you
fuel your vehicle.
1. Make sure the vehicle is on level
ground.
2. Turn the engine off and wait a
few minutes for the oil to drain
into the oil pan.
3. Set the parking brake and
ensure the gearshift is securely
latched in P (Park).
4. Open the hood. Protect yourself
from engine heat.
Maintenance and care
153

no air conditioning capability.
Continued operation will increase
engine temperature and cause the
engine to completely shut down.
The vehicle will coast to a stop.
As the engine temperature cools,
the engine may be re-started. Take
your vehicle to a service facility as
soon as possible to minimize
engine damage.
When fail-safe mode is
activated
²Pull off the road as soon as
possible.
²Immediately turn the engine off
to prevent severe engine
damage.
²Wait for the engine to cool.
²Check the coolant level.
CHECKING AND ADDING
POWER STEERING FLUID
Check the power steering fluid at
least twice a year. If adding fluid is
necessary, use only MERCONt
ATF power steering fluid.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge will be near the
center of the NORMAL band).
Maintenance and care
163

MOTORCRAFT PART NUMBERS
Component 4.6L engine 5.4L engine
Air filter FA-1632 FA-1632
Fuel filter FG-872 FG-872
Battery (standard) BXT-59 BXT-59
Battery (optional) BXT-65-750 BXT-65-750
Oil filter FL-820-S FL-820-S
PCV Valve EV-98 EV-233
Spark plugs*-platinum AWSF-32PP AWSF-22E
* Replacement double platinum spark plug ªEEº will replace ªEº and
ªEGº and ªPº will replace ªPº and ªPGº suffixed spark plugs.
REFILL CAPACITIES
Fluid Ford Part
NameApplication
Capacity
Engine oil
(includes filter
change)Motorcraft 5W30
Super Premium
Motor OilAll
5.7L
(6.0 quarts)
Brake fluid Ford High
Performance
DOT 3 Brake
FluidAll
Fill to line in
reservoir
Power steering
fluidMotorcraft
MERCONtAT FAll Fill to line in
reservoir
Transmission
fluidMotorcraft
MERCONtV
AT F4R70W
13.1L
(13.9 quarts)
Motorcraft
MERCONtAT FE4OD (4 x 2)15.0L
(15.9 quarts)
E4OD (4 x 4) 15.5L
(16.4 quarts)
Transfer case
fluidMotorcraft
MERCONtAT F4 x 4 vehicles 1.9L
(2.0 quarts)
Capacities and specifications
200

ItemFord part
nameFord part
numberFord
specification
Engine oil Motorcraft 5W30
Super Premium
Motor OilXO-5W30-QSP WSS-M2C153-G
with API
Certification
Mark
4x4 front wheel
bearings, 4x4
spindle needle
bearings, spindle
thrust bearings
& front drive
axle u-joint/slip
splineHigh
Temperature
4x4 Front Axle
& Wheel Bearing
GreaseE8TZ-19590-A ESA-M1C198-A
Automatic
transmission
(E4OD)Motorcraft
MERCONtAT FXT-2-QDX MERCONt
Automatic
transmission
(4R70W)Motorcraft
MERCONtV
AT FXT-5-QM
WSS-M2C202-B
Power steering
reservoirPremium Power
Steering FluidE6AZ-19582-AA ESW-M2C33-F
Rear axle
1Motorcraft SAE
75W140 High
Performance
Synthetic Rear
Axle LubeF1TZ-19580-B WSL-M2C192-A
Front axle 75W90 Gear
LubeF1TZ-19C547-MA WSL-M2C192-A
Transfer case -
Four wheel
driveMotorcraft
MERCONtAT FXT-2-QDX MERCONt
1Add 118 ml (4 oz.) of
EST-M2C118±A (friction modifier
Part No. C8AZ-19B546±A) for
Capacities and specifications
203

Fuel
calculating fuel economy .......182
improving fuel economy ........126
octane rating ...........................180
quality ......................................180
safety information relating to
automotive fuels .....................177
Fuel gauge ...................................13
Fuel pump shut-off switch .......127
Fuse panels
instrument panel ....................129
power distribution box ....133,137
Fuses ............................128,129,136
Gauges, Mechanical ....................13
engine coolant temperature
gauge .........................................14
Hazard flashers .........................127
Head restraints ...........................63
Headlamps
autolamp system .......................21
flashing ......................................39
high beam .................................39
turning on and off ....................20
Heating ........................................23
High beams
indicator light .............................9
Hood
release lever ............................152
Ignition
positions of the ignition ...........32
Instrument panel
lighting up panel and interior .21
Jump-starting your vehicle 145,147
attaching cables ......................146
disconnecting cables ..............147
Keys
key in ignition chime ...............13
Lamps
interior lamps .........................193
map lamps ...............................193
parking lamps .........................189
Liftgate ........................................53Lights, warning and indicator
air bag ..........................................8
anti-lock brakes (ABS) ..............9
anti-theft ...................................10
brake ............................................9
charging system ........................10
check engine ............................6,7
door ajar ....................................12
engine oil pressure ...................10
four-wheel drive ........................11
fuel reset ................................6,12
safety belt ...................................8
turn signal indicator ...................9
Load limits
trailer towing ..........................117
Lubricant specifications ...........202
Luggage rack .............................126
Message center ......................16,42
english/metric button ...............17
menu button .............................17
Mirrors
automatic dimming rearview
mirror ........................................46
heated ........................................51
side view mirrors (power) .......50
Moon roof ....................................42
Odometer .....................................15
Off road driving, 4-wheel drive 110
Overdrive ................................39,40
Overhead console
compass/temperature display ..40
storage compartment ...............41
Panic alarm feature, remote
entry system ................................56
Parking brake ............................100
Parts (see Motorcraft parts) ....200
Power door locks ........................48
Power steering
fluid, checking and adding ....163
Rear window
wiper ..........................................38
Refill capacities for fluids ........200
Index
209