1998 CHEVROLET ASTRO check oil

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
75,000 Miles (125 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
I7 Lubricate chassis components (or every 3 months, whichever occurs first).
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
An Emission Control Service.
(See footnote #.)
bearings (or at each brake relining, whichever occurs first).
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
90°F (32°C) or higher.
If you do not use your vehicle under any of these conditions, change the fluid
andfilter every
50,000 miles (83 000 km).
0 Inspect air cleaner filter if you are driving in dusty conditions. Replace filter
if necessary.
An Emission Co12trol Service. (See footnote?.)
velocity joints and axle seals for leaking. (See footnote
**.)
0 Check readfront axle fluid level and add fluid as needed. Check constant
I
DATE
I MILEAGE ACTUAL I SERVICED BY:

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
78,000 Miles (130 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
81,000 Miles (135 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
84,000 Miles (140 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 3 m ths, whichever occurs first).
(See footnote
#.)
DATE
DATE
I
DATE I
MILEAGE
7-24

Downloaded from www.Manualslib.com manuals search engine 1 Short Trip/City Maintenance Schedule I
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
velocity
joints and
axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
87,000 Miles (145 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
Lubricate chassis coinponents (or every 3 months, whichever occurs first).
An Emission Control Service.
(See footnote #.)
0 Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
90,000 Miles (I50 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
(Continued)
DATE
I MILEAGE ACTUAL I SERVICED BY
DATE I
7-25

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
96,000 Miles (160 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
99,000 Miles (165 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
I DATE I
I DATE I
ACTUAL
7-27

Downloaded from www.Manualslib.com manuals search engine Long TripMighway Maintenance Schedule
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will
not nullify
the emission warranty or limit recall liability prior to the
completion
of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at
the indicated intervals and the maintenance
be recorded.
## Lubricate the front suspension, ball joints and
kingpin bushings, steering linkage and transfer case
shift linkage, parking brake cable guides, and brake
pedal springs.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections”
in Part C of this schedule.
#’* Drive axle service (see “Recommended Fluids and
Lubricants”
in the Index for proper lubricant to use):
0 Locking Differential -- Drain fluid and refill at first
engine
oil change. At subsequent oil changes, check
fluid
level and add fluid as needed.
fluid as needed at every engine oil change.
0 Standard Differential -- Check fluid level and add
7-29

Downloaded from www.Manualslib.com manuals search engine 1 Long Tripmighway Maintenance Schedule r
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 12 months, whichever occurs first).
(See footnote
#.)
0 Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly r\
eaches 90°F
- In hilly or mountainous terrain.
(32°C)
or higher.
DATE 1
DATE I
7-30

Downloaded from www.Manualslib.com manuals search engine Long Trip/Highway Maintenance Schedule 1
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If~jou do not use your vehicle under any of tlwse conditions, change the fluid
and-filter
every 50,000 miles (83 000 krn).
rotation pattern and additional information. (See footnote +.)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
22,500 Miles (37 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Ernissiolz Control Service.
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote :k:l:.)
rotation pattern and additional information. (See footnote +.)
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
I DATE I
I DATE I
I MILEAGE ACTUAL I SERVICEDBY I
(Continued) ’
7-31

Downloaded from www.Manualslib.com manuals search engine Long Trip/Highway Maintenance Schedule
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
45,000 Miles (75 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check redfront axle fluid level and add fluid as needed. Check constant
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
90°F (32°C) or higher.
(Continued)
I DATE I
MILEAGE
DATE
I
I MILEAGE ACTUAL I SERVICEDBY: 1
7-33