1997 Oldsmobile Aurora ECU

3.
II II
Unclip the bulb
assembly from the
wiring harness and replace the
bulb assembly.
4. Reverse Steps 1 through 4 to replace the bulb
assembly, headlamp housing, air cleaner cover
and tube.
5. Replace the headlamp assembly by aligning the pin
and tightening the two bolts to secure it.
High-Beam Headlamp Bulbs
If you need to replace a headlamp bulb, do the following:
1. Remove the headlap assembly if you need more
hand clearance.
2. Pull up on the wiring harness. This unlocks the bulb.
- v-
3. Now you can reach in behind the lamp housing and
4. To replace the bulb, angle the new bulb into the
pull out
the bulb.
empty socket.
5. Push the base of the bulb down to lock it into place.
6. If you removed the headlamp assembly, reassemble
it by aligning the pin and tightening the two bolts to
secure it.

Front Turn Signal
The turn signal bulb is on the inboard edge of the
headlamp assembly.
To replace a bulb, do the following:
1.
2.
3.
4.
Remove the headlamp assembly if you need more
hand clearance.
Reach in and press the locking tab while twisting the
bulb assembly one-quarter of a turn
counterclockwise.
Replace the bulb and reverse Step
2 to reassemble.
If you removed the headlamp assembly, reassemble
it by aligning the pin and tightening the two bolts to
secure
it.
Headlamp Aiming
Your vehicle has the composite headlamp system. These
headlamps have horizontal and vertical aim indicators.
The aim has been pre-set at the factory and should need
no further adjustment.
If your vehicle is damaged in an accident and the
headlamp aim seems
to be affected, see your Aurora
retailer. Headlamps on damaged vehicles may require
recalibration
of the horizontal aim by your Aurora retailer.
To check the aim, the vehicle should be properly
prepared as
follows:
e
0
e
The vehicle must have all four tires on a perfectly
level surface.
The vehicle should not have
any snow, ice or mud
attached to it.
There should not be any cargo or loading of the
vehicle, except it should have a full tank
of gas and
one person or
160 lbs. (75 kg) on the driver’s seat.
Tires should be properly inflated.
I NOTICE:
To make sure your headlamps are aimed
properly, read all the instructions before
beginning. Failure to
follow these instructions
could cause damage to headlamp parts.
State inspection stations will allow a vertical reading of
plus
0.76 degrees or minus 0.76 degrees from the center
of the bubble.
It is recommended that the upper limit not exceed plus
0.4 degrees from the center of the bubble. Other drivers
may flash their high beams at
you if your adjustment is
much above plus
0.4 degrees.
6-37

Windshield Wiper Blade Replacement
Replacement blades come in different types and are
removed in different ways. Here’s how to remove the
type with a release hole:
1. Pull the windshield wiper arm away from the windshield.
Tires
Your new Aurora comes with high-quality tires made by
a leading tire manufacturer.
If you ever have questions
about your tire warranty and where to obtain service, see
your Aurora Warranty booklet for details.
I
Poorly maintained and improperly used tires
are dangerous.
Overloading your tires can cause
overheating as a result of
too much friction.
You could have an air-out and a serious
accident. See “Loading Your Vehicle”
in
the Index.
CAUTION: (Continued)
2. Insert a small screwdriver into the hole (A) and pull
the blade assembly off the wiper arm
(B).
3. Push the new wiper blade securely on the wiper arm.
For the proper windshield wiper blade length
and type, see
“Normal Maintenance Replacement
Parts” in the Index.
6-44

Tire Chains
NOTICE:
Use tire chains only where legal and only when
you must. Use only
SAE Class “S” type chains
that are the proper size for your tires. Install
them
on the front tires and tighten them as
tightly as possible with the ends securely
fastened. Drive slowly and follow the chain
manufacturer’s instructions.
If you can hear the
chains contacting your vehicle, stop and retighten
them.
If the contact continues, slow down until it
stops. Driving too
fast or spinning the wheels
with chains on will damage your vehicle.
Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into flame if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous
if you breathe their fumes in a closed space.
When you use anything from a container to clean your
Aurora, be sure to follow the manufacturer’s warnings
and instructions. And always open your doors or
windows when you’re cleaning the inside.
Never use these to clean your vehicle:
0 Gasoline
0 Benzene
Naphtha
0 Carbon Tetrachloride
Acetone
0 Paint Thinner
0 Turpentine
0 Lacquer Thinner
0 Nail Polish Remover
They can all be hazardous
-- some more than
others
-- and they can all damage your vehicle, too.
6-52

1. Buckle the center passenger position safety belt, and
then route the safety belts through the proper
slots in
the seat cushion. Don’t let the safety belt get twisted.
2. Slide the rear of the cushion up and under the
seatback
so the rear locating guides hook into the
wire loops
on the back frame.
3. With the seat cushion lowered, push rearward and
then press down on the seat cushion until the spring
locks on both ends engage.
4. Check to make sure the safety belts are properly
routed and that no portion
of any safety belt is
trapped under the seat.
Also make sure the seat
cushion
is secured.
Rear Compartment Fuse Blocks
V“
7- ?
d
Once the seat is removed,
you’ll find two fuse panels
on the driver’s side
of the
battery. Each is protected by
a plastic box with four tabs.
Pull
up on all four tabs at
the same time to loosen
them and pull off the box.
Of these two panels, the cover on the passenger’s side
fuse panel has an extra plastic cap attachment. You’ll
need to slide this out of the grooves which hold it there
before removing the rest
of the box.
To replace the covers, line the four tabs up and simply
snap them back into place. The extra plastic cap
attachment slides back into place.
6-67

Brake Adjustment
.................................. 6-31
Fluid
....................................... 6-28
Master Cylinder
.............................. 6-28
Parking
..................................... 2-28
PedalTravel
................................. 6-31
Replacing System Parts
........................ 6-3 1
System Warning Light ......................... 2-70
Trailer
...................................... 4-36
Transaxle Shift Interlock Check
.................. 7-41
Wear
....................................... 6-30
Brakes, Anti-Lock
............................... 4-7
Braking
........................................ 4-6
Braking in Emergencies
.......................... 4- 1 1
Break-In. New Vehicle
.......................... 2-20
Brightness Control
.............................. 2-46
BTSICheck
................................... 7-41
Bulb Replacement
.............................. 6-33
Exterior Front
................................ 6-34
Exterior Rear
................................ 6-39
Interior Lamps
............................... 6-43
Canadian Roadside Assistance
.................... 8-6
Capacities and Specifications
...................... 6-73
Carbon Monoxide
.......... 2-16,2-32,2-33,4-29, 4-35
Cassette Deck Service
........................... 7-39
Cassette Tape Player
....................... 3- 13. 3- 19
Care
....................................... 3-30
Errors
................................. 3-14, 3-19
Cellular Telephone Package
....................... 2-59
Center Passenger Position
........................ 1-3 1
Central Door Unlocking System
.................... 2-4
Certification Label
.............................. 4-30 Chains.
Safety
................................. 4-35
Chains. Tire
................................... 6-52
Change Oil Message
............................ 2-83
Changing a Flat Tire
............................. 5-24
Check Oil Level Message ........................ 2-83
Checking Your Restraint Systems
.................. 1-46
Chemical Paint Spotting
.......................... 6-59
Child Restraints
................................ 1-35
Securing in a Rear Outside Seat Position
........... 1-37
Securing in the Center Rear Seat Position
.......... 1-39
Securing in the Right Front Seat Position
.......... 1-41
TopStrap
................................... 1-36
Wheretoput
................................ 1-35
Cigarette Lighter
............................... 2-57
Circuit Breakers and Fuses
....................... 6-63
Cleaner.Air
................................... 6-15
Cleaning Aluminum or Chrome Wheels
....... .......... 6-58
Fabric
...................................... 6-53
Glass
....................................... 6-56
Inside of Your Aurora
......................... 6-53
Instrument Panel
............................. 6-55
LampLenses
................................ 6-57
Leather
..................................... 6-55
Outside of Your Aurora ........................ 6-57
Special Problems
............................. 6-54
Stains
...................................... 6-54
Tires
....................................... 6-58
Vinyl
....................................... 6-55
Wheels
..................................... 6-58
Windshield and Wiper Blades
.............. 2-39, 6-56
Climate Controls
................................ 3-2
Automatic Electronic
........................... 3-2
9-2
.. .

Vehicle Identification Number ................... 6-6 1
Lamps
........................................ 2-44
Courtesy
.................................... 2-47
Interior
..................................... 2-46
On Reminder
................................ 2-37
Panel
....................................... 2-46
Leaving Your Vehicle
............................. 2-8
Leaving Your Vehicle with the Engine Running
....... 2-30
Level Control. Electronic
......................... 4-31
Light Sensor. Twilight Sentinel
.................... 2-46
Lighter
....................................... 2-57
Lights Air Bag Readiness
....................... 1-20, 2-69
Battery Warning
.............................. 2-70
Anti-Lock Brake
System Warning
............ 2-72, 4-7
Brake System Warning
......................... 2-70
Engine Oil Pressure Light
...................... 2-77
Interior
..................................... 2-46
Parlung Brake Indicator
........................ 2-7 1
Safety Belt Reminder
...................... 1-7, 2-69
Service Engine Soon
.......................... 2-75
Traction Active
................................ 4-9
Traction Control System Active
.............. 2-73, 4-9
Traction Control System Warning
........... 2-72, 4-10
Traction Off Warning .......................... 4- 10
Loading Your Vehicle
........................... 4-30
Locks
......................................... 2-4
Anti-Lockout Feature
.......................... 2-8
Automatic Door
............................... 2-5
Cylinders
................................... 7-40
Door
........................................ 2-4
Ignition Transaxle Lock Check
.................. 7-42
Key Lock Cylinder Service
..................... 7-40
Delayed
Locking
............................. 2- 12 Memory Door
............................ 2.5, 2.11
PowerDoor
.................................. 2-5
Rear Door Security ............................. 2-7
Trunk
...................................... 2-15
Window
.................................... 2-34
Lubricants and Fluids
............................ 7-44
Lubrication Service, Body
........................ 7-40
Lumbar Controls
................................ 1-3
Magnasteer
TM ................................ 4-11
Maintenance, Normal Replacement
Parts ............ 6-74
Maintenance Record
............................ 7-46
Maintenance Schedule
............................ 7-1
Long Tripmighway Definition ................... 7-6
Long Trip/Highway Intervals
..................... 7-6
Owner Checks and Services
..................... 7-39
Periodic Maintenance Inspections
................ 7-43
Recommended Fluids and Lubricants
............. 7-44
Scheduled Maintenance Services
.................. 7-4
Short Trip/City Definition
....................... 7-5
Short Trip/City Intervals
........................ 7-5
Maintenance, Underbody
......................... 6-59
Maintenance When Trailer Towing
................. 4-38
Malfunction Indicator Lamp
...................... 2-75
MaxifuseRelay Center
.......................... 6-63
Memory Door Locks ........................ 2-5, 2-11
Memory Seat and Mirrors
........................ 2-11
Methanol
...................................... 6-4
Mirrors
....................................... 2-50
Convex Outside
.............................. 2-54
Electrochromic Daymight Rearview .............. 2-50
Heated Outside
............................... 2-54
Memory
.................................... 2-11
Parallel Park Assist
........................... 2-53
9-6

Radio Reception .............................. 3-29
Radios
.................................. 3-11. 3-17
Rain. Driving In
................................ 4- 18
Reading Lamps ........................... 2-49. 2-50
Compartment Fuse Block
....................... 6-67
Door Security Locks
........................... 2-7
Outside Seat Position
.......................... 1-25
Safety Belt Comfort Guides
..................... 1-29
Seatpassengers
.............................. 1-25
Seat Cushion. Removing
....................... 6-65
Towing
..................................... 5-13
Rear Storage Armrest
............................ 2-55
Rear Turn Signal Bulb Replacement
................ 6-39
Rearview Mirror
................................ 2-50
Compass Calibration
.......................... 2-52
Compass Variance
............................ 2-52
Electrochromic Daymight
...................... 2-50
Heated Outside
............................... 2-54
Parallel Park Assist
........................... 2-53
With Compass
............................... 2-50
RecallonDIC
................................. 2-86
Reclining Front Seatbacks
......................... 1-5
Recommended Fluids and Lubricants ............... 7-44
Refrigerants, Air Conditioning
.................... 6-74
Remote Rear
Window Defogger
............................. 3-9
Fuel Door Release
............................. 6-5
Trunk Release
................................ 2- 15
Remote Lock Control ............................. 2-8
Memory Seat and Mirrors
.................. 1-3, 2- 1 1
Personalization ............................... 2- 11
Resynchronization
............................. 2-9
Security Feedback
............................ 2- 10 Replacement
Bulbs ...................................... 6-72
Parts
....................................... 6-74
Wheel
...................................... 6-50
Replacing Safety Belts
........................... 1-47
Reporting Safety Defects
.......................... 8-8
Checking
................................... 1-46
Child
....................................... 1-35
Head
........................................ 1-6
Replacing Parts After a Crash ................... 1-47
Systemcheck
................................ 7-40
Retained Accessory Power
........................ 2-22
Reverse. Automatic Transaxle
..................... 2-26
Roadside Assistance. Canadian
..................... 8-6
Rocking Your Vehicle
........................... 5-35
Rotation. Tires
................................. 6-46
Restraints
Right Front Passenger Position
.................... 1-19
Roadside Assistance
.............................. 8-5
Safety Belt Extender
............................ 1-46
Safety Belts
.................................... 1-6
Adults
...................................... 1-11
Care ....................................... 6-56
Center Passenger Position
...................... 1-31
Children
.................................... 1-33
Driver Position
............................... 1-11
Extender
.................................... l-46
How to Wear Properly ......................... 1-11
Incorrect Usage
.................... 1-14, 1-44, 1-45
Larger Children
.............................. 1-43
LapBelt
.................................... 1-32
Lap-Shoulder
........................... 1-11, 1-25
9-8