1997 HONDA ODYSSEY engine overheat

Towing a Trailer

Towing Safety

Your car will not stop as quickly with a trailer in tow. Leave extra distance
between your car and other vehicles.
Avoid braking or turning suddenly.
This could cause the trailer to
jackknife or possibly turn over.
Keep in mind that your total vehicle
is now much longer. Leave more
room when making turns. The trailer
tracks a smaller arc than the car and
can hit or run over something that
the car misses. When passing another vehicle, make sure the
trailer is clear before changing lanes. The car/trailer combination is more
affected by crosswinds and buffeting.
When being passed by a large vehicle, keep a constant speed and steer straight ahead. If there is too
much wind buffeting, slow down to
get out of the other vehicle's air

turbulence.

Towing a trailer puts an extra load on your car. You should have your
car serviced according to the
"Maintenance Schedule under
severe driving conditions" on page 143. This extra load is magnified when
you are driving in hilly terrain.
Watch the temperature gauge closely when climbing hills. If it gets
near the hot area, turn off the air
conditioning (if it is on). If this does
not reduce the heat, it may be
necessary to pull to the side of the
road and wait for the engine to cool.
If the automatic transmission shifts
frequently between 3rd and 4th gears, put it in D3. This will help
prevent the transmission fromoverheating. Help keep the brakes
from overheating by shifting to a lower gear when going downhill.

DrivingProCarManuals.comMain Menu Table of Contents s t

Spark Plugs

5. Torque the spark plug. (If you do not have a torque wrench, tighten
the spark plug two-thirds of a turn
after it contacts the cylinder head.)
Tightening torque:
13 lbf.ft (1.8 kgf.m, 18 N.m)

Tighten the spark plugs carefully. A
spark plug that is too loose can
overheat and damage the engine. Overtightening can cause damage to
the threads in the cylinder head.

6. Install the spark plug cap.
7. Repeat this procedure for the
other three spark plugs.
Maintenance
Specifications:
NGK:

Nippondenso:
ZFR5F-11

KJ16CR-L11

Spark Plug Gap:
0,043in (1.1mm

NOTICE
ProCarManuals.comMain Menu Table of Contents s t

Taking Care of the Unexpected

This section covers the more- common problems that motorists
experience with their cars. It gives
you information about how to safely evaluate the problem and what to do
to correct it. If the problem has stranded you on the side of the road,
you may be able to get going again. If not, you will also find instructions
on getting your car towed. Compact Spare Tire....................... 194
Changing a Flat Tire ..................... 195
If Your Engine Won't Start........... 201 Nothing Happens or the Starter Motor OperatesVery Slowly......................... 201
The Starter Operates Normally................................. 202
Jump Starting................................. 202 If Your Engine Overheats............. 204
Low Oil Pressure Indicator .......... 206
Charging System Indicator........... 207
Malfunction Indicator Lamp ........ 208Closing the Sunroof....................... 209

Fuses...............................................210

Checking and Replacing........... 211

Towing............................................ 215

Taking Care of the UnexpectedProCarManuals.comMain Menu s t

If Your Engine Overheats
The pointer of your car's tempera- ture gauge should stay in the mid-range under most conditions. It may
go higher if you are driving up a long steep hill on a very hot day. If it
climbs to the red mark, you should

determine the reason.

Driving with the temperature gauge
pointer at the red mark can cause serious damage to your engine. Your car can overheat for several
reasons, such as lack of coolant or a

mechanical problem. The only

indication may be the temperature

gauge climbing to or above the red mark. Or you may see steam or
spray coming from under the hood.

In either case, you should take

immediate action.
1. Safely pull to the side of the road.
Put the transmission in Neutral or
Park and set the parking brake.
Turn off the heating and cooling system and all other accessories.
Turn on the hazard warning indicators.
2. If you see steam and/or spray coming from under the hood, turnoff the engine.
3. If you do not see steam or spray, leave the engine running and
watch the temperature gauge. If the high heat is due to overloading (climbing a long, steep hill on a
hot day with the A/C running, for example), the engine should start
to cool down almost immediately. If it does, wait until the tempera-
ture gauge comes down to the mid-
point then continue driving.

Taking Care of the Unexpected

NOTICE

Steam and spray from an

overheated engine can

seriously scald you.

Do not open the hood if steam

is coming out.ProCarManuals.comMain Menu Table of Contents s t

If Your Engine Overheats
4. If the temperature gauge stays at the red mark, turn off the engine.
5. Wait until you see no more signs of steam or spray, then open the

hood.

6. Look for any obvious coolant leaks, such as a split radiator hose.
Everything is still extremely hot, so use caution. If you find a leak, it
must be repaired before you
continue driving (see Towing on
page 215).
7. If you don't find an obvious leak, check the coolant level in the
radiator reserve tank (see page113). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks.
8. If there was no coolant in the reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointer reaches the middle of the tempera-
ture gauge, or lower, before check-
ing the radiator.
9. Using gloves or a large heavy cloth, turn the radiator cap
counterclockwise, without pushing
down, to the first stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
10.Start the engine and set the
temperature control lever tomaximum. Add coolant to the
radiator up to the base of the filler
neck. If you do not have the
proper coolant mixture available,
you can add plain water. Remember to have the coolingsystem drained and refilled with
the proper mixture as soon as you

can.

11. Put the radiator cap back on tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See Towing on
page 215.)
12.If the temperature stays normal, check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the MAX mark. Put the cap back on

tightly.
Taking Care of the Unexpected

Removing the radiator cap
while the engine is hot can cause the coolant to spray out,seriously scalding you.
Always let the engine and radiator cool down before
removing the radiator cap.ProCarManuals.comMain Menu Table of Contents s t

Index

DANGER, Explanation of................. ii
Dashboard........................................ 32
Dashboard Compartment............... 68
Daytime Running Lights................. 40
Dead Battery, What to Do............ 202
Defects, Reporting Safety............. 234
Defogger, Rear Window................. 43
Defrosting the Windows................. 79 DEXRON ®
III Automatic
Transmission Fluid.................... 157
Dimensions..................................... 220
Dimming the Headlights................ 40
Dipstick Automatic Transmission........... 157

Engine Oil................................... 112

Directional Signals........................... 41
Disabled, Towing Your Car If...... 215
Disc Brake Wear Indicators......... 125
Disposal of Used Oil...................... 151 Doors Locking and Unlocking............... 50
Power Door Locks....................... 50
DOT Tire Quality Grading........... 223
Drive Belts...................................... 170
Driving............................................ 117

Economy..................................... 114

In Bad Weather.......................... 126

In Foreign Countries................. 109

Economy, Fuel............................... 114

Emergencies on the Road............. 193
Battery, Jump Starting.............. 202

Changing a Flat Tire................. 195
Charging System Indicator ...... 207
Checking the Fuses................... 211
Low Oil Pressure Indicator...... 206
Malfunction Indicator Lamp .... 208
Manually Closing Sunroof........ 209
Overheated Engine................... 204

Emergency Brake............................ 65

Emergency Flashers....................... 43
Emission Controls......................... 225
Engine

Belts............................................. 170

Coolant Temperature Gauge ..... 38
Malfunction Indicator
Lamp................................. 34, 208

Oil Pressure Indicator......... 34, 206 Oil, What Kind to Use............... 148

Overheating................................ 204

Specifications............................. 221

Ethanol in Gasoline ....................... 109

Evaporative Emission Controls.... 225

Exhaust Fumes................................ 29

Expectant Mothers, Use of Seat
Belts by......................................... 10

Exterior, Cleaning the................... 186

Fabric, Cleaning............................. 188
Fan, Interior...................................... 74
Features, Comfort and Convenience................................. 73
Filling the Fuel Tank..................... 110
Filter
Air................................................ 160

Oil................................................ 150

First Gear Position......................... 122 Flashers, Hazard Warning.............. 43
Flat Tire, Changing a.................... 195
CONTINUEDProCarManuals.comMain Menu s t

Index

Outside Mirrors............................... 64
Overheating, Engine..................... 204
Owner Maintenance Checks........ 146
Panel Brightness Control............... 41
Park Gear Position......................... 121
Parking............................................ 124
Parking Brake.................................. 65
Parking Lights.................................. 40
Parking Over Things that Burn... 227
PGM-FI System.............................. 226
Polishing and Waxing................... 187

Power
Door Locks................................... 50

Mirrors.......................................... 64

Steering....................................... 159

Windows....................................... 62

Pregnancy, Using Seat Belts.......... 10

Proper Seat Belt Usage..................... 7

Radiator Overheating.................... 204

Radio/Cassette Sound System....... 83
Rear A/C Unit.................................. 82
Rear End Towing........................... 215
Rear Lights, Bulb Replacement... 181
Rear View Mirror............................. 64
Rear Window Defogger.................. 44
Rear Window Wiper and Washer.. 43
Reclining the Seat Backs................ 55
Reclining the Second Seats............ 59
Reminder Lights.............................. 33
Remote Transmitter........................ 51
Removing the Second Seats........... 57
Replacement Information Air Cleaner Element.................. 160
Coolant........................................ 154
Engine Oil and Filter................. 150
Fuses........................................... 211Light Bulbs................................. 179
Schedule..................................... 140
Spark Plugs................................. 162
Timing Belt................................. 170
Tires............................................ 174
Wiper Blades.............................. 166
Replacing Seat Belts After a
Crash............................................. 11

Reserve Tank, Coolant.................. 113

Restraint, Child................................ 20
Reverse Gear Position................... 121

Rotation, Tire................................. 174

Safety Belts......................................... 5

Safety Defects, Reporting*.......... 234
Safety Labels, Location of.............. 30
Safety Messages................................ ii

Seat Belts............................................ 5

Advice for Pregnant Women...... 10
Cleaning...................................... 189

Frayed or Torn............................. 11
Maintenance................................. 11
Reminder Light and Beeper....... 34
Replacement................................. 11
System Components...................... 6
Tether Attachment Points.......... 26
Use During Pregnancy................ 10
Wearing a Lap/Shoulder Belt...... 7
Wearing the Lap Belt.................... 9

Seats.................................................. 54
Adjustments................................. 54

Driver's Seat Power
Height Adjustment.................. 55

Folding the Second Seats ........... 58ProCarManuals.comMain Menu s t