1997 GMC SAVANA brake fluid

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
87,000 Miles (145 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
3 months, whichever occurs first).
(See footnote
#.)
0 Check axle fluid level and add fluid as
needed. (See footnote
** .)
r I I I
DATE SERVICED BY: ACTUAL MILEAGE
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
Cl Lubricate chassis components (or every
3 months, whichever occurs first).
(See footnote
#.)
0 Check axle fluid level and add fluid as
needed. (See footnote
**.)
0 Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
(Continued)
e 4m
ProCarManuals.com

I Long Tripmighway Maintenance Schedule -- Gasoline Engines
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles
(240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will
not nullify
the emission warranty or limit recall liability prior
to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
## Lubricate the front suspension, kingpin bushings,
steering linkage and rear driveline center splines.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections”
in Part C of this schedule.
** Drive axle service (see “Recommended Fluids and
Lubricants” in the Index for proper lubricant to use):
0 Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
0 Standard Differential -- Check fluid level and add
fluid as needed at every engine oil change.
ProCarManuals.com

30,000 Miles (50 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
An Emission Control Service.
0 Check axle fluid level and add fluid as
0 Clean and repack the front wheel bearings
needed. (See footnote
**.)
(or
at each brake relining, whichever
occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
(See footnote
+.)
0 Replace fuel filter. An Emission Control Service.
0 Replace air cleaner filter.
An Emission Control Service.
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required.
This is a Noise Emission
Control Service. Applicable
only to vehicles sold in
the United States.
(See footnote?.)
DATE
SERVICED BY: ACTUAL MILEAGE
7-35
ProCarManuals.com

52,500 Miles (87 500 km)
Cl Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
0 Check axle fluid level and add fluid as
needed. (See footnote
* *.)
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information. (See footnote
+.)
I
ACTUAL MILEAGE SERVICED BY
60,000 Miles (100 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
0 Check axle fluid level and add fluid as
needed. (See footnote
**.)
0 Clean and repack the front wheel bearings (or at each brake relining, whichever
occurs first).
Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional infomation.
(See footnote
+.)
0 Inspect engine accessory drive belt.
An Emission Control Service.
ProCarManuals.com

Long TripMighway Maintenance Schedule -- Gasoline Engines I
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
0 Check axle fluid level and add fluid as
needed. (See footnote
**.)
0 Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
(See footnote?.)
0 Replace fuel filter. An Emission Control Service.
0 Replace air cleaner filter.
An Emission Control Service.
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required.
This is a Noise Emission
Control Service. Applicable
only to vehicles sold in
the United Stutes.
0 Rotate tires. See “Tire Inspection and
Rotation’’
in the Index for proper rota
pattern and additional information.
(See footnote
+.)
.tion
I DATE I ACTUAL MILEAGE ISERVICED BY: I
7-42
ProCarManuals.com

Rear Axle Service
Check the gear lubricant level in the rear axle and add
if needed. See “Rear Axle” in the Index, A fluid loss
may indicate a problem. Check the axle and repair it
if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses
for proper hook-up, binding, leaks, cracks,
chafing,
etc. Inspect disc brake pads for wear and rotors
for surface condition.
Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment.
You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
7-50
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
(Gasoline
Engine)
Engine Coolant
Hydraulic Brake
System
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil”
in the Index.
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench’ DEX-COOL@
or Havoline@ DEX-COOL@
coolant. See “Engine Coolant” in
the Index.
Delco Supreme 11
@ Brake Fluid
(GM Part No. 12377967 or
equivalent DOT-3 brake fluid).
USAGE
Parking Brake
Cable Guides
Power Steering System
Automatic
Transmission
Key Lock
Cylinders
Chassis
Lubrication
FLUIDlLUBRICANT
Chassis lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI
## 2, Category LB
or GC-LB.
GM Power Steering Fluid
(GM Part
No. 1052884 - 1 pint,
10500 17 - 1 quart, or equivalent).
DEXRON@-IU Automatic
Transmission Fluid.
Multi-Purpose lubricant, Superlube@ (GM
Part No. 12346241
or equivalent).
Chassis lubricant
(GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI ## 2, Category LB
or GC-LB.
c
7-5 1
ProCarManuals.com

Section 9 Index
Adjustable Mast Antenna ........................ 3-28
AirBag
....................................... 1-25
Adding Equipment
............................ 1-32
How Does it Restrain
.......................... 1-30
How
it Works ................................ 1-28
Location
.................................... 1-28
Readiness Light
......................... 1.27. 2.5 1
Servicing ................................... 1-31
What Makes
it Inflate .......................... 1-29
What Will
You See After it Inflates ............... 1-30
When Should it Inflate
......................... 1-29
Aircleaner
.................................... 6-17
Air Conditioning
................................ 3 -7
Air Conditioning Refrigerants
..................... 6-67
Alignment and Balance. Tire
...................... 6-47
Aluminum Wheels. Cleaning
...................... 6-55
Antenna. Adjustable Mast
........................ 3-28
Antenna. Power
................................ 3-28
Antifreeze
..................................... 6-22
Anti-Lock
Brake System Warning Light
................ 2.53. 4.7
Brakes
...................................... 4-7
Appearance Care
............................... 6-49
Air Control.
Climate Control System
................. 3-3 Appearance
Care Materials
....................... 6-57
Arbitration Program .............................. 8-9
Audio Systems
.................................. 3-8
Automatic Transmission
Transmission Check
........................... 7-46
Transmission Fluid
............................ 6-18
Transmission Operation
........................ 2-20
Transmission Park Mechanism Check
............. 7-48
Axle. Locking Rear
............................. 2-23
Axle. Rear
.................................... 6-22
Ashtrays
...................................... 2-43
Shifting
..................................... 2-20
Battery
...................................... 6-32
Jump Starting
................................. 5-3
Replacement. Remote Keyless Entry
............... 2-8
Warnings
.................................... 5-3
Warnings
.................................... 5-3
Before Leaving on a Long Trip
.................... 4-21
Blizzard. Driving In
............................. 4-25
BBB Auto
Line
................................. 8-9
Better Business Bureau Mediation
................... 8-9
9-1
ProCarManuals.com